NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
315 reports173,000 miles · Nov 25, 2020
Steering
POWER STEERING ASSIST IS UNRELIABLE. IT WOULD STOP WORKING INTERMITTENTLY A FEW DAYS AGO AND NOW IT DOESNT WORK EXCEPT FOR THE FIRST START OF THE DAY AND I'VE HAD IT LOOKED AT SHOP HERE IN TOWN IT THREW A CODE THAT A LOCAL FORD DEALERSHIP TOLD ME WAS THE STEERING COLUMN NEEDED REPLACING. I WAS ALSO INFORMED THAT THIS VEHICLE HAD…
Read full complaint
POWER STEERING ASSIST IS UNRELIABLE. IT WOULD STOP WORKING INTERMITTENTLY A FEW DAYS AGO AND NOW IT DOESNT WORK EXCEPT FOR THE FIRST START OF THE DAY AND I'VE HAD IT LOOKED AT SHOP HERE IN TOWN IT THREW A CODE THAT A LOCAL FORD DEALERSHIP TOLD ME WAS THE STEERING COLUMN NEEDED REPLACING. I WAS ALSO INFORMED THAT THIS VEHICLE HAD A PREVIOUS RECALL FOR THE SAME ISSUE AND THAT MY MARINER DIDN'T HAVE THE RECALLED PARTS REPLACED BUT THE PCM WAS REPROGRAMMED. I WAS TOLD THAT THE REPLACEMENT WOULD NOT BE COVERED UNDER THE PREVIOUS RECALL ISSUED BY FORD MOTOR CO.
NHTSA ODI #11376371
116,175 miles · Nov 5, 2020
Service BrakesCrash
MY DAUGHTER WAS INVOLVED IN AN ACCIDENT DUE TO FAULTY BRAKES. WE HAVE HAD THE VEHICLE IN TO HAVE REPAIRS AT THREE DIFFERENT SHOPS, THE LAST TWO BEING AT FORD. THE FIRST TWO SHOPS COULD NEVER GET THE BRAKES RIGHT. FORD FINALLY GOT THEM TO WORK FOR A PERIOD OF TIME. THEY WENT OUT AGAIN. FORD HAD THE CAR FOR ANOTHER MONTH- IT TAKES…
Read full complaint
MY DAUGHTER WAS INVOLVED IN AN ACCIDENT DUE TO FAULTY BRAKES. WE HAVE HAD THE VEHICLE IN TO HAVE REPAIRS AT THREE DIFFERENT SHOPS, THE LAST TWO BEING AT FORD. THE FIRST TWO SHOPS COULD NEVER GET THE BRAKES RIGHT. FORD FINALLY GOT THEM TO WORK FOR A PERIOD OF TIME. THEY WENT OUT AGAIN. FORD HAD THE CAR FOR ANOTHER MONTH- IT TAKES MONTHS EVERY TIME. PAID ANOTHER $2445. AND STILL NO BRAKES. HAVE CONTACTED FORD CORPORATE AND THEY REFUSE TO HELP OR GIVE ME DOCUMENTATION TO THAT EFFECT. FORD CASES ARE CAS-28178357 AND CAS-27857368. I HAVE TWO OTHER MARINERS AND THIS ONE JUST ISN'T RIGHT. PLEASE ADVISE MY OPTIONS. I DON'T WANT TO SELL OR TRADE THIS WITH A PROBLEM THAT COULD POSSIBLY HURT OR KILL SOMEONE. THANKS!
NHTSA ODI #11373175
90,000 miles · Oct 29, 2020
Service Brakes
OUR SON IS DRIVING THIS CAR WIT 90K MILES ON IT. HAD 1200 OF BREAK WORK DONE AFTER FEELING LIKE THE PEDAL WAS GOING DOWN TOO FAR AND HE COULD NOT STOP WELL AND THEN IT ENDED UP NEEDING A NEW EHCU TO THE TUNE OF 2600$. THIS IS A VERY CRITICAL COMPONENT AND FROM WHAT I READ, THERE ARE A LOT OF PEOPLE EXPERIENCING THIS PROBLEM. …
Read full complaint
OUR SON IS DRIVING THIS CAR WIT 90K MILES ON IT. HAD 1200 OF BREAK WORK DONE AFTER FEELING LIKE THE PEDAL WAS GOING DOWN TOO FAR AND HE COULD NOT STOP WELL AND THEN IT ENDED UP NEEDING A NEW EHCU TO THE TUNE OF 2600$. THIS IS A VERY CRITICAL COMPONENT AND FROM WHAT I READ, THERE ARE A LOT OF PEOPLE EXPERIENCING THIS PROBLEM. IT SHOULD NOT FAIL AND FORD AS NOT ISSUED A RECALL. I CALLED FORD TO SEE IF THERE COULD BE ANY ASSISTANCE AND THEY SAID NO. GOOD CARS ARE BEING JUNKED FOR THIS REASON AND IT IS A SEVERE SAFETY ISSUE.
NHTSA ODI #11367005
165,000 miles · Oct 26, 2020
Service Brakes, Hydraulic
WHEN USING THE BRAKES THERE'S A LOSS OF ABOUT HALF OF THE BRAKE PEDAL, AND MOST LIKELY THE ABS SYSTEM. THE PART RETAILS FOR $1,747.32. THE PROBLEM FROM TALKING TO MECHANICS AND SEARCHING IS APPARENTLY STICKING VALVE(S) WHICH IN TURN MAKES THE BRAKE FLUID BY-PASS HALF OF THE SYSTEM. IN OTHER WORDS YOU ONLY HAVE THE USE OF PART OF…
Read full complaint
WHEN USING THE BRAKES THERE'S A LOSS OF ABOUT HALF OF THE BRAKE PEDAL, AND MOST LIKELY THE ABS SYSTEM. THE PART RETAILS FOR $1,747.32. THE PROBLEM FROM TALKING TO MECHANICS AND SEARCHING IS APPARENTLY STICKING VALVE(S) WHICH IN TURN MAKES THE BRAKE FLUID BY-PASS HALF OF THE SYSTEM. IN OTHER WORDS YOU ONLY HAVE THE USE OF PART OF THE BRAKE SYSTEM. OUR CAR HAS 170K MILES BUT THAT'S ~ 90% HIGHWAY MILES, WE BOUGHT IT ~6YRS AGO WITH 15K MILES, WHICH MEANS THE BRAKES DON'T GET THAT MUCH USE. THE REAR SHOES WERE JUST REPLACED FOR THE 1ST TIME @ 170K AND THE FRONT PADS HAVE BEEN DONE ONCE. FORD CARES SO MUCH ABOUT THE LIVES OF PEOPLE DRIVING THEIR CARS THAT THEY CONTINUE TO SELL THE SAME PART (MODULATOR VALVE - FORD (9L8Z-2C346-C)) WITHOUT ANY ENGINEERING CHANGES/UPDATES, EVEN THOUGH THIS IS A COMMON PROBLEM ACROSS CAR LINES AND EVEN TRUCKS. THEY HAVE ISSUED A RECALL, #19S54 FOR SELECT 2006-10 FORD FUSION, MERCURY MILAN AND LINCOLN MKZ VEHICLES THAT EXHIBIT THE SAME ISSUE, "A NORMALLY CLOSED VALVE INSIDE THE HYDRAULIC CONTROL UNIT MAY STICK OPEN, WHICH COULD RESULT IN EXTENDED BRAKE PEDAL TRAVEL, POTENTIALLY INCREASING THE RISK OF A CRASH.". AN INTERESTING POINT IN THE RECALL IS THIS: "THE SYSTEM WILL BE PRESSURE-FLUSHED WITH DOT 4 BRAKE FLUID AND THE DOT 3 RESERVOIR CAP WILL BE REPLACED WITH A NEW DOT 4 CAP." OUR VEHICLE HAS A DOT3 CAP, IS DOT3 WHAT CAUSES THE PROBLEM WITH "STUCK OR SLOW-RESPONDING VALVES" PER RECALL, AND DOT4 KEEPS VALVES FROM STICKING OR BECOMING SLOW ACTING BECAUSE OF THE VISCOSITY DIFFERENCE BETWEEN THE 2? FROM AMSOIL "DOT 3 IS THE MOST COMMON TYPE USED IN CARS AND TRUCKS TODAY. DOT 4, HOWEVER, IS GAINING POPULARITY DUE TO WIDESPREAD USE OF ANTI-LOCK BRAKING SYSTEMS AND TRACTION CONTROL, WHICH BENEFIT FROM DOT 4 FLUID?S LOWER VISCOSITY." THIS: "AS OF 2006, MOST CARS PRODUCED IN THE U.S. USE DOT 4 BRAKE FLUID." EXCEPT FOR FORD APPARENTLY.
NHTSA ODI #11373310
Mileage unknown · Oct 22, 2020
SteeringUnknown Or OtherWheels
LAST YEAR IN APRIL I GOT THE CAR , DIDN'T HAVE IT FOR A WEEK THE POWER STEERING WENT OUT . I GOT IT FIXED . HERE IT IS 2020 OF AUGUST , THE POWER STEERING ASSIST CAME ON . THE STEERING WHEEL LOCKED UP ON ME . I DON'T HAVE THE MONEY TO KEEP REPLACING THIS SAME PART . I LOOKED INTO THE RECALLS FOR THE VEHICLE . I SEEN A COUPLE , C…
Read full complaint
LAST YEAR IN APRIL I GOT THE CAR , DIDN'T HAVE IT FOR A WEEK THE POWER STEERING WENT OUT . I GOT IT FIXED . HERE IT IS 2020 OF AUGUST , THE POWER STEERING ASSIST CAME ON . THE STEERING WHEEL LOCKED UP ON ME . I DON'T HAVE THE MONEY TO KEEP REPLACING THIS SAME PART . I LOOKED INTO THE RECALLS FOR THE VEHICLE . I SEEN A COUPLE , CALLED A NUMBER I SEEN THEY SAID THE RECALL EXPIRED. SO I'M BACK TO SQUARE ONE . I DON'T KNOW EXACTLY WHAT PART I NEED .
NHTSA ODI #11365714
167,400 miles · Oct 4, 2020
Steering
UNEXPECTED SUDDEN LOSS OF POWER STEERING WHILE MAKING A RIGHT HAND TURN ONTO MAJOR ROADWAY CAUSING CONTACT WITH CURB.
NHTSA ODI #11362649
150,000 miles · Sep 16, 2020
Electrical SystemElectronic Stability Control (esc)Steering
VEHICLE SUDDENLY LOSES POWER STEERING ASSISTANCE WHILE DRIVING. IF THE IGNITION KEY IS CYCLED THE POWER STEERING ASSIST MAY FUNCTION AGAIN. THE AFFECTED COMPONENT WAS DETERMINED TO BE THE POWER STEERING CONTROL MODULE (PSCM) WITHIN THE STEERING COLUMN. A RECALL WAS ISSUED FOR THIS IN 2014, HOWEVER ONLY THE SOFTWARE WAS UPDATED W…
Read full complaint
VEHICLE SUDDENLY LOSES POWER STEERING ASSISTANCE WHILE DRIVING. IF THE IGNITION KEY IS CYCLED THE POWER STEERING ASSIST MAY FUNCTION AGAIN. THE AFFECTED COMPONENT WAS DETERMINED TO BE THE POWER STEERING CONTROL MODULE (PSCM) WITHIN THE STEERING COLUMN. A RECALL WAS ISSUED FOR THIS IN 2014, HOWEVER ONLY THE SOFTWARE WAS UPDATED WHEN THE VEHICLE WAS BROUGHT IN FOR REPAIR. THE MALFUNCTIONING COMPONENTS WERE NOT REPLACED AND THE ISSUE HAS RETURNED.
NHTSA ODI #11355433
164,000 miles · Sep 2, 2020
Steering
TL* THE CONTACT OWNS A 2009 MERCURY MARINER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE LOSS POWER STEERING ASSIST WITHOUT WARNING. THE CONTACT DROVE THE VEHICLE TO HER RESIDENCE. THE CONTACT TOOK THE VEHICLE TO SHEEHY FORD LINCOLN OF RICHMOND (10601 MIDLOTHIAN TURNPIKE, RICHMOND, VA 23235) WHERE THE VEHI…
Read full complaint
TL* THE CONTACT OWNS A 2009 MERCURY MARINER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE LOSS POWER STEERING ASSIST WITHOUT WARNING. THE CONTACT DROVE THE VEHICLE TO HER RESIDENCE. THE CONTACT TOOK THE VEHICLE TO SHEEHY FORD LINCOLN OF RICHMOND (10601 MIDLOTHIAN TURNPIKE, RICHMOND, VA 23235) WHERE THE VEHICLE WAS DIAGNOSED WITH A POWER STEERING MODULE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 164,000.
NHTSA ODI #11352730
150,000 miles · Aug 17, 2020
SuspensionUnknown Or Other
THE VEHICLE AC UNIT WATER DRAINS DIRECTLY OVER THE FRONT SUB-FRAME AND RUSTS THROUGH THE FRAME, AT WHICH POINT THE FRONT DRIVER SIDE SUSPENSION WILL COLLAPSE AND LOSS OF STEERING RESULTS. THIS PROBLEM WAS ACKNOWLEDGED FOR SOME ESCAPE VEHICLES, BUT NOT ITS MERCURY MARINER EQUIVALENT, EVEN THOUGH IT SHARES SAME PART/PROBLEM. DEA…
Read full complaint
THE VEHICLE AC UNIT WATER DRAINS DIRECTLY OVER THE FRONT SUB-FRAME AND RUSTS THROUGH THE FRAME, AT WHICH POINT THE FRONT DRIVER SIDE SUSPENSION WILL COLLAPSE AND LOSS OF STEERING RESULTS. THIS PROBLEM WAS ACKNOWLEDGED FOR SOME ESCAPE VEHICLES, BUT NOT ITS MERCURY MARINER EQUIVALENT, EVEN THOUGH IT SHARES SAME PART/PROBLEM. DEALER REFUSES TO COVER REPAIR AND CUST SEVICE SUGGESTED I CONTACT NHTSA.
NHTSA ODI #11349924
150,000 miles · Aug 16, 2020
Service Brakes
AFTER ABS ACTIVATED BRAKE PADEL BECAME SOFT. MY VEHICLE HAS A SIMLAR PROBLEM EXPAINED UNDER ''SAFETY RECALL 19S54 ' ANTI-LOCK BRAKE SYSTEM HYDRAULIC CONTROL UNIT VALVE FUNCTION''. EVENTHOUGH FORD RECALLED SEVERAL UNITES, MY VIN DID NOT LIST UNDER THE RECALLED UNITS.
NHTSA ODI #11349677
NHTSA investigations
2DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
PE13003 · Electronic Throttle Body Malfunction
Opened Feb 21, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Engine
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting in intermittent electrical connectivity and reduced engine power. When this condition occurs, the Malfunction Indicator Lamp (MIL) or Wrench light will illuminate and the vehicle may enter a limited limp home mode.Ford?s trade name for the feature is Failure Mode Effects Management (FMEM) mode.In this mode, engine power and vehicle speed are reduced, while full function of the power steering, power braking, lighting, and climate control systems are maintained.ODI?s complaint analysis indicate that the predominant failure mode involved reduced motive power associated with the limited limp home mode with engine speeds limited to approximately 900 RPM. Analysis of warranty claims provided by Ford identified 59,807 claims related to ETB replacements and approximately 50 percent of claims are associated with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed.Ford described several factors where the ETB motor may fail resulting in DTCs P2111 or P2112 but the failure is not an existing stuck open or closed ETB valve position.According to Ford, the ETB control strategy provides the driver with three FMEM modes that allow varying degrees of vehicle mobility depending on the severity of the fault detected.DTCs associated with stuck open or closed throttle valves are designated the highest failure severity resulting in engine speeds limited to high idle corresponding to the limited limp home mode.Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability.Other FMEM limp modes may result in reduced engine performance but will maintain vehicle speed above 20mph. During this investigation, Ford and its suppliers, Delphi and Igarashi, updated the powertrain control module (PCM) software to include a throttle body motor cleaning cycle during key-on and modified the ETB internal motor components design, surface finish and material composition to improve durability. Additionally, Ford developed a remedy procedure and issued a special Customer Satisfaction Program (CSP) 13N03 extending the ETB warranty coverage and instructing dealers to update the powertrain calibration to improve vehicle performance in the event that intermittent electrical connectivity of the throttle body motor contacts occurs. The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through January 31, 2015 regardless of mileage.Owners of the affected vehicles will be contacted by mail to take their vehicle to a Ford dealer who will reprogram the PCM to the latest calibration. The bulletin was sent to dealers on January 17, 2014 and the owner letter mailing began on January 27, 2014. See the investigative file for copies of Ford's bulletin and owner letter. This preliminary evaluation is closed. The closing of this investigation does not constitute a finding that
Illustration