Months back there were times the power steering would go out, it would be for short amount of times and always came back. As of 40+ days ago the power steering has totally gone out and has not once come back. The dash says "power steering assist fault" The other issue is the wrench on the dash. It's normally after driving for qu…
Read full complaint
Months back there were times the power steering would go out, it would be for short amount of times and always came back. As of 40+ days ago the power steering has totally gone out and has not once come back. The dash says "power steering assist fault" The other issue is the wrench on the dash. It's normally after driving for quite some time. Even if there has been a break on the car while grocery shopping etc. when it comes on the car goes into limp mode. VERY DANGEROUS as we cannot tell when it'll happen. There has been multiple times the light turns green we take off, get to about 15-20MPH and she just stops. The dash reads to safetly pull over and I believe it says to shut off the car. This has been happening for 5+ months. There is also random over heating when that happens. This is based on how I remember it. Because of the safety issues I have not driven the vehicle. My husband drives it because he can handle no power steering better then me... Not that it's better for anyone to use..
NHTSA ODI #11585642
Mileage unknown · Apr 27, 2022
Unknown Or Other
The passenger side front tire became disconnected while driving. The frame rusted and broke causing the tire to separate from the vehicle. The tow truck driver commented that he had never seen this before. I had the vehicle towed to Firestone only to have them tell me they could not fix the vehicle. The vehicle has not been thor…
Read full complaint
The passenger side front tire became disconnected while driving. The frame rusted and broke causing the tire to separate from the vehicle. The tow truck driver commented that he had never seen this before. I had the vehicle towed to Firestone only to have them tell me they could not fix the vehicle. The vehicle has not been thoroughly inspected, but is available to be inspected. I noticed a change in the steering wheel position for about a week prior to the tire separating. If the tire would have separated from the vehicle while driving on a highway or busy street, more damage and possible injury could have resulted.
NHTSA ODI #11462509
Mileage unknown · Feb 2, 2022
Unknown Or OtherCrash
I was making a turn and the vehicle seemed as if the steering locked up. It randomly does this and is starting to be more and more often. It has already made me run off of the road and hit a culvert causing even further damage.
NHTSA ODI #11450026
Mileage unknown · Jan 13, 2022
SteeringUnknown Or Other
My wife is driving the car and the power steering quits working several times. Off and on. Speed varies.. Very scary!
NHTSA ODI #11447398
Mileage unknown · Oct 22, 2020
SteeringUnknown Or OtherWheels
LAST YEAR IN APRIL I GOT THE CAR , DIDN'T HAVE IT FOR A WEEK THE POWER STEERING WENT OUT . I GOT IT FIXED . HERE IT IS 2020 OF AUGUST , THE POWER STEERING ASSIST CAME ON . THE STEERING WHEEL LOCKED UP ON ME . I DON'T HAVE THE MONEY TO KEEP REPLACING THIS SAME PART . I LOOKED INTO THE RECALLS FOR THE VEHICLE . I SEEN A COUPLE , C…
Read full complaint
LAST YEAR IN APRIL I GOT THE CAR , DIDN'T HAVE IT FOR A WEEK THE POWER STEERING WENT OUT . I GOT IT FIXED . HERE IT IS 2020 OF AUGUST , THE POWER STEERING ASSIST CAME ON . THE STEERING WHEEL LOCKED UP ON ME . I DON'T HAVE THE MONEY TO KEEP REPLACING THIS SAME PART . I LOOKED INTO THE RECALLS FOR THE VEHICLE . I SEEN A COUPLE , CALLED A NUMBER I SEEN THEY SAID THE RECALL EXPIRED. SO I'M BACK TO SQUARE ONE . I DON'T KNOW EXACTLY WHAT PART I NEED .
NHTSA ODI #11365714
150,000 miles · Aug 17, 2020
SuspensionUnknown Or Other
THE VEHICLE AC UNIT WATER DRAINS DIRECTLY OVER THE FRONT SUB-FRAME AND RUSTS THROUGH THE FRAME, AT WHICH POINT THE FRONT DRIVER SIDE SUSPENSION WILL COLLAPSE AND LOSS OF STEERING RESULTS. THIS PROBLEM WAS ACKNOWLEDGED FOR SOME ESCAPE VEHICLES, BUT NOT ITS MERCURY MARINER EQUIVALENT, EVEN THOUGH IT SHARES SAME PART/PROBLEM. DEA…
Read full complaint
THE VEHICLE AC UNIT WATER DRAINS DIRECTLY OVER THE FRONT SUB-FRAME AND RUSTS THROUGH THE FRAME, AT WHICH POINT THE FRONT DRIVER SIDE SUSPENSION WILL COLLAPSE AND LOSS OF STEERING RESULTS. THIS PROBLEM WAS ACKNOWLEDGED FOR SOME ESCAPE VEHICLES, BUT NOT ITS MERCURY MARINER EQUIVALENT, EVEN THOUGH IT SHARES SAME PART/PROBLEM. DEALER REFUSES TO COVER REPAIR AND CUST SEVICE SUGGESTED I CONTACT NHTSA.
NHTSA ODI #11349924
Mileage unknown · Dec 7, 2019
Unknown Or Other
FAULTY SEAL ON THE REAR WINDOW HAS CAUSED WATER TO SEEP INTO THE HATCH RELEASE MECHANISM. REAR DOOR WILL NOT OPEN. THERE IS NO REPAIR THAT CAN FIX THIS ISSUE. CANNOT CHANGE REAR LIGHTS DUE TO BEING UNABLE TO OPEN THE REAR DOOR.
NHTSA ODI #11287686
105,000 miles · Jan 5, 2019
Fuel/propulsion SystemSteeringUnknown Or Other
ON OCTOBER 18, 2018 I RECEIVED THE POWER STEERING ASSIST FAILURE ERROR ON MY INSTRUMENT PANEL WHEN TURNING ON MY VEHICLE. I HAD DRIVEN IT EARLIER IN THE DAY WITHOUT ISSUE. PREVIOUSLY I HAD THE OCCASIONAL WARNING NOISE AND QUICK FLASH OF AN ERROR (TOO QUICK FOR ME TO READ ALL THE WAY) AND WOULD HAVE MOMENTARY DIFFICULTY TURNING. …
Read full complaint
ON OCTOBER 18, 2018 I RECEIVED THE POWER STEERING ASSIST FAILURE ERROR ON MY INSTRUMENT PANEL WHEN TURNING ON MY VEHICLE. I HAD DRIVEN IT EARLIER IN THE DAY WITHOUT ISSUE. PREVIOUSLY I HAD THE OCCASIONAL WARNING NOISE AND QUICK FLASH OF AN ERROR (TOO QUICK FOR ME TO READ ALL THE WAY) AND WOULD HAVE MOMENTARY DIFFICULTY TURNING. THIS ISSUE MAKES IT ALMOST IMPOSSIBLE TO STEER THE VEHICLE. RESEARCH INDICATES THAT IT IS MOST LIKELY A MALFUNCTIONING TORQUE SENSOR. I REACHED OUT TO FORD AFTER LEARNING OF RECALLS FOR THE 2009 MODEL YEAR. I WAS INFORMED THAT MY VIN WAS NOT INCLUDED IN THE RECALL. FORD WAS UNWILLING TO ASSIST WITH THE COST OF REPAIRS IN ANY WAY. THEIR SUGGESTION WAS TO KEEP THE RECEIPT ON THE SLIM CHANCE THAT THE RECALL WOULD BE EXPANDED. THIS IS UNACCEPTABLE. HAD I BEEN ON A HIGHWAY WHEN THIS OCCURRED IT COULD HAVE BEEN FATAL TO MYSELF OR OTHERS. THIS REPAIR WILL COST IN THE NEIGHBORHOOD OF $1000 OR MORE. I WILL NEED TO HAVE THE WORK DONE AT A DEALERSHIP TO ENSURE THE REPAIR IS DONE CORRECTLY AND THAT FORD WON'T GIVE ME REIMBURSEMENT ISSUES SHOULD THE RECALL BE EXPANDED. THIS OCCURRED LESS THAN A YEAR AFTER THE FUEL INLET VALVE FAILED ON THE VEHICLE, CAUSING IT TO SHUT DOWN WHILE DRIVING AND RENDERING IT UNABLE TO BE STARTED. THE REAR HATCH HAS NOT BEEN ABLE TO BE OPENED FOR OVER THREE YEARS BECAUSE OF AN ISSUE WITH THE LATCH. I HAVE HAD ISSUES WITH THE CLIMATE CONTROL SYSTEM AND WELL. THERE WERE ISSUES WITH AIR CONDITIONING WHEN I PURCHASED THE VEHICLE (APRIL 2015). THE ISSUES WERE NOT APPARENT PREVIOUS TO PURCHASE BECAUSE OF THE WEATHER AT THE TIME. WITHIN A MONTH THE WEATHER WARMED UP. WHEN I ATTEMPTED TO USE THE A/C IT WAS ONLY BLOWING HOT AIR. THE DEALERSHIP WAS WILLING TO FIX THE ISSUE FREE OF CHARGE BECAUSE OF THE CIRCUMSTANCES. HOWEVER, THE ISSUE IS OCCURRING AGAIN EVEN AFTER HAVING AN A/C RECHARGE PERFORMED.
NHTSA ODI #11165415
Mileage unknown · Dec 3, 2016
EngineUnknown Or Other
MY TRUCK STALLS. I PURCHASED A NEW BATTERY, AND IT CONTINUES TO STALL WHILE DRIVING OR IDLING.
NHTSA ODI #10929723
Mileage unknown · May 7, 2016
Unknown Or Other
SLIGHT GRINDING NOISE WHEN MAKING A HARD LEFT TURN, AS INTO A DRIVEWAY. (RELITIVELY SLOW SPEED, NOT CREEPING)
Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
PE13003 · Electronic Throttle Body Malfunction
Opened Feb 21, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Engine
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting in intermittent electrical connectivity and reduced engine power. When this condition occurs, the Malfunction Indicator Lamp (MIL) or Wrench light will illuminate and the vehicle may enter a limited limp home mode.Ford?s trade name for the feature is Failure Mode Effects Management (FMEM) mode.In this mode, engine power and vehicle speed are reduced, while full function of the power steering, power braking, lighting, and climate control systems are maintained.ODI?s complaint analysis indicate that the predominant failure mode involved reduced motive power associated with the limited limp home mode with engine speeds limited to approximately 900 RPM. Analysis of warranty claims provided by Ford identified 59,807 claims related to ETB replacements and approximately 50 percent of claims are associated with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed.Ford described several factors where the ETB motor may fail resulting in DTCs P2111 or P2112 but the failure is not an existing stuck open or closed ETB valve position.According to Ford, the ETB control strategy provides the driver with three FMEM modes that allow varying degrees of vehicle mobility depending on the severity of the fault detected.DTCs associated with stuck open or closed throttle valves are designated the highest failure severity resulting in engine speeds limited to high idle corresponding to the limited limp home mode.Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability.Other FMEM limp modes may result in reduced engine performance but will maintain vehicle speed above 20mph. During this investigation, Ford and its suppliers, Delphi and Igarashi, updated the powertrain control module (PCM) software to include a throttle body motor cleaning cycle during key-on and modified the ETB internal motor components design, surface finish and material composition to improve durability. Additionally, Ford developed a remedy procedure and issued a special Customer Satisfaction Program (CSP) 13N03 extending the ETB warranty coverage and instructing dealers to update the powertrain calibration to improve vehicle performance in the event that intermittent electrical connectivity of the throttle body motor contacts occurs. The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through January 31, 2015 regardless of mileage.Owners of the affected vehicles will be contacted by mail to take their vehicle to a Ford dealer who will reprogram the PCM to the latest calibration. The bulletin was sent to dealers on January 17, 2014 and the owner letter mailing began on January 27, 2014. See the investigative file for copies of Ford's bulletin and owner letter. This preliminary evaluation is closed. The closing of this investigation does not constitute a finding that
2009 Mercury Mariner Problems, Complaints & Recalls | Skip That Year
Illustration