The contact owns a 2008 Mercury Mariner. The contact stated while her husband was driving 75 MPH, the vehicle lost power steering functionality. There was no warning light illuminated. The contact stated that her husband exited the freeway and veered to the side of the road while using physical force to steer the vehicle. The co…
Read full complaint
The contact owns a 2008 Mercury Mariner. The contact stated while her husband was driving 75 MPH, the vehicle lost power steering functionality. There was no warning light illuminated. The contact stated that her husband exited the freeway and veered to the side of the road while using physical force to steer the vehicle. The contact's husband was able to drive to the residence even though the failure persisted. The dealer was not notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and informed the contact that the vehicle could not be repaired under NHTSA Campaign Number: 14V284000 (Steering) because the VIN was not included. The failure mileage was approximately 186,000.
NHTSA ODI #11504744
Mileage unknown · Jan 30, 2023
Steering
The power stearing went out all at once and a light popped up saying power assit fault
NHTSA ODI #11504559
95,000 miles · Dec 29, 2022
Steering
The contact owns a 2008 Mercury Mariner. The contact received notification of NHTSA Campaign Number: 14V284000 (Steering). The contact took the vehicle to a local dealer and had the recall repair completed. The vehicle was not repaired. The contact stated that on December 27, 2022, while exiting her garage porch the steering whe…
Read full complaint
The contact owns a 2008 Mercury Mariner. The contact received notification of NHTSA Campaign Number: 14V284000 (Steering). The contact took the vehicle to a local dealer and had the recall repair completed. The vehicle was not repaired. The contact stated that on December 27, 2022, while exiting her garage porch the steering wheel became difficult to turn. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer and made them aware of the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 95,000.
NHTSA ODI #11499384
238,000 miles · Nov 9, 2022
Steering
The contact owns a 2008 Mercury Mariner. The contact stated while driving at an undisclosed speed and making a left turn, the vehicle lost power steering functionality and was difficult to turn. The vehicle was taken to the dealer and the contact was informed that the vehicle was experiencing the failure listed in NHTSA Campaign…
Read full complaint
The contact owns a 2008 Mercury Mariner. The contact stated while driving at an undisclosed speed and making a left turn, the vehicle lost power steering functionality and was difficult to turn. The vehicle was taken to the dealer and the contact was informed that the vehicle was experiencing the failure listed in NHTSA Campaign Number: 14V284000 (Steering) however, the vehicle was previously repaired under the recall. The manufacturer was contacted and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 238,000.
NHTSA ODI #11492934
Mileage unknown · Oct 5, 2022
Steering
Our torque sensor needs replacing. McFarland Ford in Exeter said that the torque sensor was repaird via recall at First Ford in Fall River, MA 2014. We have NEVER had a problem with steering. First Ford in Fall River informed me that if we brought the vehicle in for an oil change, any recall item would have been checked, and …
Read full complaint
Our torque sensor needs replacing. McFarland Ford in Exeter said that the torque sensor was repaird via recall at First Ford in Fall River, MA 2014. We have NEVER had a problem with steering. First Ford in Fall River informed me that if we brought the vehicle in for an oil change, any recall item would have been checked, and if they found no problem with it at that time, it was reported, and that ended the recall status for our vehicle. Please, we need your help. My husband is 83; I am 70. This whole thing smells. How can checking something we had no problem with cancel a recall status on our vehicle. There was no warning. Our vehicle worked fine. We got in the next morning, and the steering wheel wouldn't turn.
NHTSA ODI #11487955
185,669 miles · Sep 19, 2022
Steering
The contact owns a 2008 Mercury Mariner. The contact stated that the vehicle was included in NHTSA Campaign Number: 14V284000 (Steering) and an inspection was performed along with a software update. The contact stated while driving approximately 20 MPH, the vehicle lost power steering functionality making it difficult to turn to…
Read full complaint
The contact owns a 2008 Mercury Mariner. The contact stated that the vehicle was included in NHTSA Campaign Number: 14V284000 (Steering) and an inspection was performed along with a software update. The contact stated while driving approximately 20 MPH, the vehicle lost power steering functionality making it difficult to turn to the left or the right. The contact pulled over to the side of the roadway and turned off and restarted the vehicle and the power steering functionality was restored. The failure occurred three times on the same day. The dealer was contacted and informed of the failure however, the vehicle had not been taken the dealer to be diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 185,669.
NHTSA ODI #11485177
Mileage unknown · Aug 30, 2022
Steering
The contact owns a 2008 Mercury Mariner. The contact stated while her mother-in-law was driving 70 MPH, the vehicle lost power steering functionality. The contact's mother-in-law pulled the vehicle off the road and drove to an independent mechanic. The contact’s mother-in-law stated there was no warning light illuminated. The me…
Read full complaint
The contact owns a 2008 Mercury Mariner. The contact stated while her mother-in-law was driving 70 MPH, the vehicle lost power steering functionality. The contact's mother-in-law pulled the vehicle off the road and drove to an independent mechanic. The contact’s mother-in-law stated there was no warning light illuminated. The mechanic diagnosed the vehicle and determined that the electrical power steering assist needed to be replaced. The mechanic related the failure to NHTSA Campaign Number: 14V284000 (Steering) however, the vehicle was not included in the recall. The vehicle had not been repaired. The manufacturer was informed of the failure. The failure mileage was unknown.
NHTSA ODI #11482031
Mileage unknown · Aug 15, 2022
Steering
Drove fine day before got in next morning wheel very tight hard to turn Took to shop they said loss of electric power steering. Guy said this vehicle had trouble with that Checked for any recalls NHTSA had this on their site as a recall started in 2014 I called dealership here in town and guy basically laughed at me because was…
Read full complaint
Drove fine day before got in next morning wheel very tight hard to turn Took to shop they said loss of electric power steering. Guy said this vehicle had trouble with that Checked for any recalls NHTSA had this on their site as a recall started in 2014 I called dealership here in town and guy basically laughed at me because was a 2008 and said not going to fix your car forever. Recall has expired. It’s a safety issue.
NHTSA ODI #11479294
Mileage unknown · Apr 22, 2022
Steering
THE PROBLEM IS WITH THE ELECTRIC POWER ASSIST SYSTEM. I HAVE A TORQUE SENSOR PROBLEM OR SOMETHING THAT WANT LET THE POWER STEERING WORK. FORD HAD A RECALL FOR THIS PROBLEM FOR THIS YEAR MODEL. WHEN I CALL THEM THEY RESPOND AS MY CAR WAS NOT COVERED. IM HAVING THE SAME ISSUE THAT THE RECAll WAS FOR. NOT SURE WHY ITS NOT COVERED.
NHTSA ODI #11461796
Mileage unknown · Mar 14, 2022
Steering
While driving suddenly a beep on the dashboard and a notice appeared, the steering wheel got too hard to make it turn, the notice on the dashboard "Power Steering Assist Fault" the part can"t be found anywhere but refurbished at a high price, it is very unsafe to drive while making turns. Wondering if this could be a good reason…
Read full complaint
While driving suddenly a beep on the dashboard and a notice appeared, the steering wheel got too hard to make it turn, the notice on the dashboard "Power Steering Assist Fault" the part can"t be found anywhere but refurbished at a high price, it is very unsafe to drive while making turns. Wondering if this could be a good reason to order recall on this part. Vehicle was inspected by a Mechanic. what do I need to do now? Thanks
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
2008 Mercury Mariner Problems, Complaints & Recalls | Skip That Year
Illustration