NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
29 reportsClear category filterMileage unknown · Aug 11, 2022
Service Brakes
Brakes go to floor dealer said they see nothing. They gave my vehicle back brake are normal again.two months go by it happens again but it fixed itself after 2 days. This just happen again 8/5/2022. I see a recall NHTSA campaign #19V904000 ,MFG campaign #19S54 Also a NHTSA recall#150546 How am I going to drive with brakes on the…
Read full complaint
Brakes go to floor dealer said they see nothing. They gave my vehicle back brake are normal again.two months go by it happens again but it fixed itself after 2 days. This just happen again 8/5/2022. I see a recall NHTSA campaign #19V904000 ,MFG campaign #19S54 Also a NHTSA recall#150546 How am I going to drive with brakes on the floor My vehicle is a 2008 Mercury Mariner Thanks in advance
NHTSA ODI #11478775
Mileage unknown · Jun 15, 2021
Service Brakes
I lost all braking ability and the pedal goes to the floor. This is a Mercury Mariner Hybrid and Ford Escape Hybrid issue, it doesn't affect the non-hybrid models. Ford knows about this as there are hundreds and hundreds of complaints online about it and it's a $5000+ fix. I have not been able to drive my Mariner Hybrid since 20…
Read full complaint
I lost all braking ability and the pedal goes to the floor. This is a Mercury Mariner Hybrid and Ford Escape Hybrid issue, it doesn't affect the non-hybrid models. Ford knows about this as there are hundreds and hundreds of complaints online about it and it's a $5000+ fix. I have not been able to drive my Mariner Hybrid since 2018.
NHTSA ODI #11421022
70,000 miles · Apr 30, 2021
Forward Collision AvoidanceService Brakes
2008 MERCURY MARINER. THE VEHICLE SPORADICALLY AND INTERMITTENTLY BRAKES WHILE DRIVING AND ACCELERATING. THIS WAS A REPORTED ISSUE MANY YEARS AGO ON THESE CARS BUT FORD NEVER ISSUED A RECALL EVEN THOUGH THERE ARE A NUMBER OF BRAKING ISSUES WITH THIS VEHICLE. THIS MAKES THE VEHICLE EXTREMELY DANGEROUS TO DRIVE IF YOUR BRAKES WITH…
Read full complaint
2008 MERCURY MARINER. THE VEHICLE SPORADICALLY AND INTERMITTENTLY BRAKES WHILE DRIVING AND ACCELERATING. THIS WAS A REPORTED ISSUE MANY YEARS AGO ON THESE CARS BUT FORD NEVER ISSUED A RECALL EVEN THOUGH THERE ARE A NUMBER OF BRAKING ISSUES WITH THIS VEHICLE. THIS MAKES THE VEHICLE EXTREMELY DANGEROUS TO DRIVE IF YOUR BRAKES WITHOUT WARNING LOCK UP. I CONTACTED THE LOCAL DEALER AND FORD CORPORATE AND THEY WERE OF NO HELP. I ALSO FILED AN INCIDENT REPORT WITH FORD CORPORATE #CAS31601808.
NHTSA ODI #11414571
98,000 miles · Apr 10, 2021
Service Brakes
DRIVING, COMING TO A STOPLIGHT, THE BRAKES SUDDENLY FAILED, THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. PUMPING I WAS ABLE TO GET JUST ENOUGH BRAKES TO STOP BEFORE COLLIDING WITH THE CAR IN FRONT OF US. THE SERVICE ABS AND EMERGENCY BRAKE SERVICE WARNING LIGHTS CAME ON AFTER THE NEAR COLLISION. I TOOK THE CAR TO A FORD DEAL…
Read full complaint
DRIVING, COMING TO A STOPLIGHT, THE BRAKES SUDDENLY FAILED, THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. PUMPING I WAS ABLE TO GET JUST ENOUGH BRAKES TO STOP BEFORE COLLIDING WITH THE CAR IN FRONT OF US. THE SERVICE ABS AND EMERGENCY BRAKE SERVICE WARNING LIGHTS CAME ON AFTER THE NEAR COLLISION. I TOOK THE CAR TO A FORD DEALERSHIP AND WAS TOLD THE HCU UNIT HAD FAILED. THIS IS A $4,000 PART THAT WE HAD ALREADY REPLACED AT 76,000 MILES,. THE NEW PART FAILED AGAIN WITHOUT WARNING ONLY 22,000 MILES LATER.
NHTSA ODI #11407375
120,000 miles · Mar 3, 2021
Service Brakes
MY VEHICLE HAD DIFFICULTY IN STOPPING, NEEDING THE PEDAL TO BE PRESSED ALMOST TO THE FLOOR BEFORE IT STOPPED. I CHANGED THE MASTER CYLINDER IN HOPES THAT IT WOULD FIX THE PROBLEM BUT IT DIDN'T. THE BRAKES PERIODICALLY WOULD WORK PROPERLY, BUT ONCE AGAIN THE PROBLEM WOULD RETURN. I STOPPED BY THE FORD DEALERSHIP AND THEY ADVIS…
Read full complaint
MY VEHICLE HAD DIFFICULTY IN STOPPING, NEEDING THE PEDAL TO BE PRESSED ALMOST TO THE FLOOR BEFORE IT STOPPED. I CHANGED THE MASTER CYLINDER IN HOPES THAT IT WOULD FIX THE PROBLEM BUT IT DIDN'T. THE BRAKES PERIODICALLY WOULD WORK PROPERLY, BUT ONCE AGAIN THE PROBLEM WOULD RETURN. I STOPPED BY THE FORD DEALERSHIP AND THEY ADVISED ME THAT THE 2008 MERCURY MILAN WAS RECALLED FOR THIS DEFECT, HOWEVER, MY 2008 MARINER WASN'T ON THE LIST TO BE RECALLED. THE DEALERSHIP ADDED THAT THE PARTS FOR THE REPAIR WAS ON BACK ORDER. I STILL DRIVE THE CAR BUT CAUTIOUS WHENEVER I NEED TO BRAKE.
NHTSA ODI #11398982
150,000 miles · Feb 1, 2021
Service Brakes
THE ABS HYDROLIC CONTROL UNIT HAS MALFUNCTIONED RESULTING IN FAULTY BRAKES AND DANGEROUS DRIVING CONDITIONS. I HAVE TO PUT THE BRAKE PEDAL TO THE GROUND TO GET ANY TYPE OF BRAKING TO BE DONE. THIS TAKES EXTRA SECONDS THAT COULD RESULT IN AN ACCIDENT IF I HAD TO SUDDENLY BRAKE. THIS SEEMS TO BE A COMMON PROBLEM AND MANY MARINERS …
Read full complaint
THE ABS HYDROLIC CONTROL UNIT HAS MALFUNCTIONED RESULTING IN FAULTY BRAKES AND DANGEROUS DRIVING CONDITIONS. I HAVE TO PUT THE BRAKE PEDAL TO THE GROUND TO GET ANY TYPE OF BRAKING TO BE DONE. THIS TAKES EXTRA SECONDS THAT COULD RESULT IN AN ACCIDENT IF I HAD TO SUDDENLY BRAKE. THIS SEEMS TO BE A COMMON PROBLEM AND MANY MARINERS AND ESCAPES HAVE IDENTICAL PROBLEMS. I WOULD LIKE MY VIN TO BE ADDED TO THE RECALL LIST TO HAVE THIS PROBLEM FIXED.
NHTSA ODI #11391024
155,000 miles · Nov 16, 2020
Service BrakesUnknown Or Other
RE:NHTSA IDENTIFIER 19V904 FORD INTERNAL REFERENCE NUMBER:19S54 ALTHOUGH MERCURY MARINERS ARE NOT LISTED IN THIS RECALL, MY 2008 MERCURY MARINER HAS THE EXACT SAME ISSUE, STICKING ABS VALVE. FORD WILL NOT RECOGNIZE MY VEHICLE AS PART OF THIS RECALL. I HAVE HAD 2 DIFFERENT CERTIFIED MECHANICS WORK ON THE VEHICLE AND BOTH ME…
Read full complaint
RE:NHTSA IDENTIFIER 19V904 FORD INTERNAL REFERENCE NUMBER:19S54 ALTHOUGH MERCURY MARINERS ARE NOT LISTED IN THIS RECALL, MY 2008 MERCURY MARINER HAS THE EXACT SAME ISSUE, STICKING ABS VALVE. FORD WILL NOT RECOGNIZE MY VEHICLE AS PART OF THIS RECALL. I HAVE HAD 2 DIFFERENT CERTIFIED MECHANICS WORK ON THE VEHICLE AND BOTH MECHANICS HAVE INSTALLED NEW BRAKE BOOSTERS, BRAKE PADS AND MASTER CYLINDERS. THE RESULTS FROM THEIR WORK DID NOT RESOLVE THE ISSUE OF SOFT BRAKES. THE PROBLEM BEGAN WHEN I MADE AN ABRUPT STOP WHILE DRIVING ON A CITY STREET. THE BRAKES WERE NEVER FULLY FUNCTIONAL AFTER THAT. I BELIEVE THE SITUATION WITH MY MARINER IS IDENTICAL TO THE ISSUE IDENTIFIED IN THE NHTSA IDENTIFIER 19V904. I ALSO BELIEVE THAT MERCURY MARINERS SHOULD BE INCLUDED IN THIS FORD RECALL.
NHTSA ODI #11374844
Mileage unknown · Sep 27, 2020
Electronic Stability Control (esc)Fuel/propulsion SystemService Brakes
ABS LIGHT ,REGEN BRAKES DISABLED AND CHECK BRAKE SYSTEM MESSAGE COMES ON AT ANYTIME WHILE DRIVING. LOSE BRAKING POWER, CAUSING DRIVER TO PUSH BRAKE VERY HARD TO STOP AND BRAKE PEDAL SOMETIMES GOES TO THE FLOOR. WHEN CAR STOPS SOMETIMES IT WON'T RESTART FOR DAYS. IT HAS A NEW BATTERY. COOLANT CODE COMES ON ALSO AND THE CAR ISN'T…
Read full complaint
ABS LIGHT ,REGEN BRAKES DISABLED AND CHECK BRAKE SYSTEM MESSAGE COMES ON AT ANYTIME WHILE DRIVING. LOSE BRAKING POWER, CAUSING DRIVER TO PUSH BRAKE VERY HARD TO STOP AND BRAKE PEDAL SOMETIMES GOES TO THE FLOOR. WHEN CAR STOPS SOMETIMES IT WON'T RESTART FOR DAYS. IT HAS A NEW BATTERY. COOLANT CODE COMES ON ALSO AND THE CAR ISN'T RUNNING HOT. THIS IS A DANGEROUS PROBLEM AND NEEDS A RECALL. OTHER THAN THAT THE CAR RUNS GREAT.
NHTSA ODI #11361396
60,000 miles · Jun 24, 2020
Service Brakes
I STARTED HAVING PROBLEMS WITH MY BRAKES. WHEN I STEP ON THE BRAKE THE PEDAL WOULD GO ALMOST ALL THE WAY TO THE FLOOR. I WOULD REACT BY PUMPING THE BRAKE WHICH WOULD MAKE THEM WORK. I DIDN'T DRIVE WITH THE BRAKES DOING THAT VERY LONG BECAUSE I TOOK THE CAR TO A REPAIR SHOP AND I SPENT 450 DOLLARS ON BRAKE WORK WITH BEING TOLD TH…
Read full complaint
I STARTED HAVING PROBLEMS WITH MY BRAKES. WHEN I STEP ON THE BRAKE THE PEDAL WOULD GO ALMOST ALL THE WAY TO THE FLOOR. I WOULD REACT BY PUMPING THE BRAKE WHICH WOULD MAKE THEM WORK. I DIDN'T DRIVE WITH THE BRAKES DOING THAT VERY LONG BECAUSE I TOOK THE CAR TO A REPAIR SHOP AND I SPENT 450 DOLLARS ON BRAKE WORK WITH BEING TOLD THAT THE PROBLEM WAS WITH THE ABS SYSTEM AND THE DISABLED THE ABS SYSTEM SO THAT IT DIDN'T INTERFERE WITH STOPPING THE CAR. THERE HAVE BEEN RECALLS ON OTHER FORD PRODUCTS BECAUSE OF ABS PROBLEMS. THE PROBLEM OCCURRED WHILE I WAS DRIVING EVERY TIME I WANTED TO STOP AND WHEN I STOPPED FOR A LIGHT I FELT LIKE THE BRAKES MIGHT QUIT WORKING AND THE CAR COULD ENTER THE INTERSECTION. *TR
NHTSA ODI #11330650
120,000 miles · May 21, 2020
Service Brakes
BRAKES SUDDENLY STOPPED WORKING WHILE MY 17 YEAR OLD DAUGHTER WAS DRIVING. A MESSAGE APPEARS 'REGEN BRAKES DISABLED, CHECK BRAKE SYSTEM'. WENT TO DEALERSHIP AND WAS TOLD HCU AND MASTER CYLINDER NEEDS TO BE REPLACED $4000 REPAIR. NOT ACCEPTABLE SEEING SO MANY COMPLAINTS OF THIS ISSUE THAT FORD HAS NOT YET ISSUED A RECALL. *TR
NHTSA ODI #11325410
Official recalls
3Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
May 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration