IllustrationPower steering goes out at regular intervals. in the same type of issue as the following Recall notice 14S05/NHTSA Or the Electric assist system as bad.
2008 Mercury Mariner
Owner reports · Recalls · Investigations
More warning signs than most Mariner years
Owner complaints for the 2008 Mercury Mariner are substantially higher than the model-year median of 63.
About this comparison →How this year compares
Owner complaints by model year
Compare all Mariner years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
2125–50K
5150–75K
8075–100K
146100–150K
84150K+
404 reports with mileage · 57 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 297 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports0 fire reports5 injury reports
Electrical System complaints
27 reportsTHE CAR WAS DRIVING DOWN THE ROAD (A CITY STREET, NOT A HIGHWAY) AND A TRIANGULAR LIGHT CAME ON THE DASH, ALONG WITH A MESSAGE TO STOP SAFELY. THE ENGINE SHUT DOWN AND I HAD TO COAST INTO A PARKING LOT. THIS HAD HAPPENED PREVIOUSLY AND I HAD PAID A DEALERSHIP TO REPLACE THE HYBRID COOLING PUMP. I LATER FOUND OUT THAT THIS PART H…
Read full complaint
THE CAR WAS DRIVING DOWN THE ROAD (A CITY STREET, NOT A HIGHWAY) AND A TRIANGULAR LIGHT CAME ON THE DASH, ALONG WITH A MESSAGE TO STOP SAFELY. THE ENGINE SHUT DOWN AND I HAD TO COAST INTO A PARKING LOT. THIS HAD HAPPENED PREVIOUSLY AND I HAD PAID A DEALERSHIP TO REPLACE THE HYBRID COOLING PUMP. I LATER FOUND OUT THAT THIS PART HAD BEEN RECALLED AND WAS REIMBURSED BY THE MANUFACTURER FOR THE ORIGINAL REPAIR. THE SAME PART HAS FAILED AGAIN ACCORDING TO THE DEALERSHIP, BUT UPON CONTACTING THE MANUFACTURER, THEY REFUSE TO REPLACE THE PART AGAIN.
THE VEHICLE WILL STALL WHEN IT COMES TO A STOP, MID TURN, SLOWING DOWN, AND SOMETIMES ACCELERATING. SEVERAL WEBSITES SHOW 100'S OF COMPLAINTS FROM PEOPLE WITH THE SAME ISSUE. IT IS A MAY SAFETY CONCERN BECAUSE IT DIES AT ANY POINT WHILE DRIVING.
I WAS DRIVING ON THE INTERSTATE IN TRAFFIC AND HAD A COMPLETE LOSS OF POWER STEERING, MAKING IT NEARLY IMPOSSIBLE TO PULL OVER OR GET OFF THE HIGHWAY.
FORD'S RECALL "CODE 14S19" ON 2005-2008 MARINER HYBRIDS AND ESCAPE HYBRIDS SHOULD COVER ALL OF THESE HYBRIDS BUT IT HAS EXCEPTIONS! FORD HAS ISSUED A RECALL ON *SOME* OF THE 2005-2008 FORD ESCAPE HYBRIDS AND *SOME* OF THE CORRESPONDING MERCURY MARINER HYBRIDS. HOWEVER THEY ARE REFUSING TO ISSUE A RECALL ON MY PARTICULAR 2008 …
Read full complaint
FORD'S RECALL "CODE 14S19" ON 2005-2008 MARINER HYBRIDS AND ESCAPE HYBRIDS SHOULD COVER ALL OF THESE HYBRIDS BUT IT HAS EXCEPTIONS! FORD HAS ISSUED A RECALL ON *SOME* OF THE 2005-2008 FORD ESCAPE HYBRIDS AND *SOME* OF THE CORRESPONDING MERCURY MARINER HYBRIDS. HOWEVER THEY ARE REFUSING TO ISSUE A RECALL ON MY PARTICULAR 2008 MARINER HYBRID (WHICH IS EXHIBITING THE ELECTRONIC OVERHEATING PROBLEM DESCRIBED IN THE RECALL WHERE THE STOP SAFELY NOW COMES ON AND THERE IS AN IMMEDIATE LOSS OF POWER). THEY ARE REFUSING TO FIX MY MARINER JUST BECAUSE THE VIN NUMBER DOES NOT MATCH THE PARTICULAR MANUFACTURING LOT COVERED BY THE ORIGINAL FORD RECALL - THOUGH MY SUV DOES FALL IN THE DATE RANGE MENTIONED IN THE RECALL) I AM CERTAIN THIS RECALL SHOULD COVER MORE HYBRID SUV THAN FORD HAS ADMITTED TO, AND SINCE THE MARINERS HAD A VERY LIMITED PRODUCTION RUN, IT IS LESS LIKELY THAT THERE WIL BE A SIGNIFICANT NUMBER OF COMPLAINTS DUE TO THIS VERY SERIOUS LIFE THREATENING ISSUE - AND I WOULD LIKE TO EMPHASIZE THAT THERE HAVE BEEN NUMEROUS COMPLAINTS ABOUT THIS INCLUDING ON NHTSA. FORD SHOULD EXPAND THIS RECALL TO INCLUDE ALL DEFECTIVE FORD ESCAPES AND MARINER HYBRIDS BEFORE SERIOUS ACCIDENTS START OCCURRING AS A RESULT OF VEHICLES SHUTTING OFF DURING OPERATION BECAUSE OF EITHER DRIVE ELECTRONICS OVER HEATING DUE TO A BAD COOLANT PUMP, (AND POSSIBLY OTHER CAUSES?). ----RELEVANT RECALL-- NHTSA VEHICLE SAFETY RECALLS RECALL NUMBER 14V526000 RECALL DATE 09/03/2014 COMPONENT HYBRID PROPULSION SYSTEM FORD CONTACT NUMBER FOR RECALLS 1-866-436-7332. RELEVANT LINKS: HTTPS://WWW.NHTSA.GOV/VEHICLE/2007/MERCURY/MARINER%252520HYBRID
SPEEDOMETER INSTRUMENT CLUSTER GAUGES KEEP GOING OUT AND CAUSING SUV TO NOT START
TL* THE CONTACT OWNS A 2008 MERCURY MARINER. THE CONTACT STATED THAT THE POWER STEERING BECAME INOPERBALE AFTER THE VEHICLE WAS COLD STARTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO LOCATED FAILURE CODE: B2278 (STEERING TORQUE SENSOR). THE DEALER (KOONS SILVER SPRING FORD, 3111 AUTOMOBILE BLVD #1, SILVER SPRING, MD …
Read full complaint
TL* THE CONTACT OWNS A 2008 MERCURY MARINER. THE CONTACT STATED THAT THE POWER STEERING BECAME INOPERBALE AFTER THE VEHICLE WAS COLD STARTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO LOCATED FAILURE CODE: B2278 (STEERING TORQUE SENSOR). THE DEALER (KOONS SILVER SPRING FORD, 3111 AUTOMOBILE BLVD #1, SILVER SPRING, MD 20904, (855) 458-6764) DIAGNOSED THAT A NEW STEERING COLUMN ASSEMBLY AND IGNITION HOUSING ASSEMBLY WERE NEEDED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 115,000.
IN MARCH 2018, I NOTICED THE STEERING WHEEL WOULD SHAKE WHEN COMING TO A STOP SIGN OR STOP LIGHT AND MAKE A GRINDING SOUND. IT CONTINUED TO DO THIS EVERY TIME FOR A COUPLE WEEKS. THEN TOWARD MID MARCH, I WAS BACKING OUT OF A DRIVEWAY AND THE POWER STEERING TOTALLY WENT OUT.IT STATED ON PANEL "POWER STEERING DEFAULT ASSIST." IT T…
Read full complaint
IN MARCH 2018, I NOTICED THE STEERING WHEEL WOULD SHAKE WHEN COMING TO A STOP SIGN OR STOP LIGHT AND MAKE A GRINDING SOUND. IT CONTINUED TO DO THIS EVERY TIME FOR A COUPLE WEEKS. THEN TOWARD MID MARCH, I WAS BACKING OUT OF A DRIVEWAY AND THE POWER STEERING TOTALLY WENT OUT.IT STATED ON PANEL "POWER STEERING DEFAULT ASSIST." IT TOOK EXTREME EFFORT TO STEER THE WHEEL TO THE SIDE AS THE STEERING WHEEL WAS EXTREMELY RIGID. BECAUSE IT IS A SAFETY HAZARD TO DRIVE, IT HAS ONLY BEEN DRIVEN TO MOVE CAR IN APARTMENT PARKING LOT. I GOT THIS VEHICLE IN JUNE 2017 FROM A CAR DEALER WITH NO WARRANTY. FORD SAYS THIS VIN # IS NOT INCLUDED IN RECALL FOR TORQUE PROBLEM WITH POWER STEERING FAILURE. AS THIS IS A MANUFACTURING DEFECT AND A SAFETY HAZARD, I WANT THIS VEHICLE VIN ADDED TO RECALL LIST. IF I DRIVE IT ON OPEN ROAD, IT WILL SURELY CAUSE INJURY TO MY FAMILY. I CAN'T EVEN MANEUVER THE STEERING WHEEL.
TL* THE CONTACT OWNS A 2008 MERCURY MARINER. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED AND THE CONTACT WAS UNABLE TO STEER THE VEHICLE. THE CONTACT WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO CONWAY FORD (2393 US-501, CONWAY, SC 29526) WHERE IT WAS D…
Read full complaint
TL* THE CONTACT OWNS A 2008 MERCURY MARINER. WHILE DRIVING 35 MPH, THE STEERING WHEEL SEIZED AND THE CONTACT WAS UNABLE TO STEER THE VEHICLE. THE CONTACT WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO CONWAY FORD (2393 US-501, CONWAY, SC 29526) WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN LOCK MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING). THE FAILURE MILEAGE WAS UNKNOWN. *TT CONTACT STATES THAT WHEN VEHICLE WAS LEFT OVER NIGHT IN A PARKING GARAGE THE STEERING WAS COMPLETELY OUT UPON STARTING VEHICLE. THE ONLY WAY STEERING WOULD WORK IS WITH THE HELP WITH ANOTHER PERSON TURNING THE WHEEL. CONTACT STATES IGNITION STOPPED WORKING AS WELL AND NEEDED TO BE REPLACED. *TT
MANUFACTURER'S FAULTY IGNITION LOCK MODULE WEARS OUT PREMATURELY AND VEHICLE OFTEN DOESN'T START. CAUSED CONSISTENT BUT INTERMITTENT PROBLEM FOR LAST 3 YEARS. RESEARCH SHOWS THIS IS A COMMON PROBLEM ON 2008-2012 MARINERS, FORD ESCAPES AND 2008-2011 FORD FOCUS, WHICH ALL USE THE SAME IGNITION LOCK.
Official recalls
315V606000 · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:floor Shift
Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
14V526000 · Hybrid Propulsion System
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
14V284000 · Steering:electric Power Assist System
May 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO