THE RECALL THAT FORD IS RECALLS 2007MERCURY MARINER WHILE DRIVING VEHICLE JUST SHUTS OFF I WAS WITH MY DAUGHTER DRIVING ON THE HIGHWAY LUCKY I WAS ABLE TO SWITCH ALL 4 LANES THE ENGINE GETS HOT TEMPTER GAUGE READING NORMAL IT STAYS IN THE MIDDLE TURN VEHICLE TTB BACK ON PRESS PEDAL NO POWER PUMP THE PEDAL AND HOPES IT STAYS ON…
Read full complaint
THE RECALL THAT FORD IS RECALLS 2007MERCURY MARINER WHILE DRIVING VEHICLE JUST SHUTS OFF I WAS WITH MY DAUGHTER DRIVING ON THE HIGHWAY LUCKY I WAS ABLE TO SWITCH ALL 4 LANES THE ENGINE GETS HOT TEMPTER GAUGE READING NORMAL IT STAYS IN THE MIDDLE TURN VEHICLE TTB BACK ON PRESS PEDAL NO POWER PUMP THE PEDAL AND HOPES IT STAYS ON ITS BEEN ACTING THREE MONTHS. *TR
NHTSA ODI #11327297
116,245 miles · Apr 11, 2017
Electrical System
TAKATA RECALL I WAS ON THE EXPRESS WAY IN MOTION AND THE CAR SHUT DOWN MEANING THAT ALL OF THE GADGES SHUT DOWN. THEN THE CAR JUST COAST UNTIL I COULD PULL OVER WITHOUT BEING HURT OR HURTING OTHER DRIVERS. NOTHING SHOWED UP JUST SHUT DOWN.
NHTSA ODI #10971929
100,006 miles · Feb 6, 2017
Electrical SystemEngine
MY SON WAS USING OUR CAR HE DROVE IT TO WORK... ALL WAS FINE...HE USED THE CAR TO GO GET LUNCH IN THE SHOPPING CENTER... DROVE BACK FROM THE SHOPPING CENTER TO A PARKING SPOT OUTSIDE HIS JOB LOCATION... HE THEN COMPLETED HIS SHIFT AT DICK'S SPORTING GOODS WHERE MY WIFE AND I MET UP WITH HIM...WE ALL PROCEEDED TO OUR CAR AND TRUC…
Read full complaint
MY SON WAS USING OUR CAR HE DROVE IT TO WORK... ALL WAS FINE...HE USED THE CAR TO GO GET LUNCH IN THE SHOPPING CENTER... DROVE BACK FROM THE SHOPPING CENTER TO A PARKING SPOT OUTSIDE HIS JOB LOCATION... HE THEN COMPLETED HIS SHIFT AT DICK'S SPORTING GOODS WHERE MY WIFE AND I MET UP WITH HIM...WE ALL PROCEEDED TO OUR CAR AND TRUCK WHICH WERE PARKED ACROSS FROM ONE ANOTHER...MY WIFE AND SON GOT IN THE MERCURY I GOT IN MY TRUCK... MY SON TRIED TO START THE MERCURY BUT IT WOULD NOT TURN OVER...MY WIFE TRIED STILL WOULD NOT TURN OVER ... CHECKED THE BATTERY ALL WAS GOOD SO I THOUGHT MAYBE THE STARTER? HAD IT TOWED , AND A STARTER REPLACED? STILL NOTHING ... MY MECHANIC SAID IT WAS THE MOTOR ? AND I WOULD NEED A NEW MOTOR !!! SO I LOOKED ON LINE AND FOUND SOMETHING ABOUT A CLASS ACTION LAWSUIT INVOLVING MERCURY MARINER 2005 TO 2008 MINE IS A 2007 ? CALLED THEM BUT THE SAID I HAVE TO CONTACT FORD MOTOR COMPANY MY SELF ???? SO THAT IS WHAT LED ME TO YOU!!! CAN YOU HELP?
NHTSA ODI #10949952
10,500 miles · Feb 17, 2016
Electrical System
TL* THE CONTACT OWNS A 2007 MERCURY MARINER. AFTER DRIVING AND PARKING THE VEHICLE, THE CONTACT COULD NOT REMOVE THE KEY FROM THE IGNITION. THE CONTACT HAD TO TURN THE STEERING WHEEL AND MANEUVER THE KEY IN ORDER TO GET IT TO RELEASE. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES AND WAS GRADUALLY GETTING WORSE. THE…
Read full complaint
TL* THE CONTACT OWNS A 2007 MERCURY MARINER. AFTER DRIVING AND PARKING THE VEHICLE, THE CONTACT COULD NOT REMOVE THE KEY FROM THE IGNITION. THE CONTACT HAD TO TURN THE STEERING WHEEL AND MANEUVER THE KEY IN ORDER TO GET IT TO RELEASE. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES AND WAS GRADUALLY GETTING WORSE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 10,500.
NHTSA ODI #10836641
75,000 miles · Feb 1, 2012
Electrical System
THE ENGINE SHUT DOWN WHILE ON THE HIGHWAY AND A LIGHT APPEARED ON THE DASH SAYING "STOP SAFELY NOW". I STOPPED, TURNED OFF THE ENGINE, AND TURNED IT BACK ON. I TOOK IT TO A AN AUTHORIZED FORD REPAIR SHOP AND THEY SAID THEY WEREN'T SURE WHAT THE PROBLEM WAS. I DIDN'T HAVE ANOTHER PROBLEM FOR 9 MONTHS AND THEN THE SAME THING HA…
Read full complaint
THE ENGINE SHUT DOWN WHILE ON THE HIGHWAY AND A LIGHT APPEARED ON THE DASH SAYING "STOP SAFELY NOW". I STOPPED, TURNED OFF THE ENGINE, AND TURNED IT BACK ON. I TOOK IT TO A AN AUTHORIZED FORD REPAIR SHOP AND THEY SAID THEY WEREN'T SURE WHAT THE PROBLEM WAS. I DIDN'T HAVE ANOTHER PROBLEM FOR 9 MONTHS AND THEN THE SAME THING HAPPENED. AGAIN NO PROBLEM FOR ABOUT 2 MONTHS AND THEN IT HAPPENED AGAIN REPEATEDLY. AFTER PULLING OVER AND RESTARTING THE SAME PROBLEM WOULD REOCCUR ABOUT EVERY 15 MILES. I MADE IT TO A FORD DEALERSHIP. THEY ARE NOW REPLACING THE COOLANT PUMP. I DID SOME READING ON-LINE AND THIS APPEARS TO BE A COMMON PROBLEM WITH ESCAPE AND MARINER HYBRIDS. SHOULDN'T THERE BE A RECALL OF THE FAULTY PUMP? *TR
NHTSA ODI #10446134
37,900 miles · May 3, 2009
Electrical System
2008 MERCURY MARINER HYBRID NO CRANK. VEHICLE WAS FOUND TO HAVE DAMAGED HIGH VOLTAGE WIRING HARNESS. HARNESS RUNS ALONG UNDERNEATH THE PASSENGER SIDE OF THE VEHICLE CABIN. HARNESS IS PARTIALLY ENCASED PVC. PVC WAS DAMAGED POSSIBLY DUE TO ROAD HAZARD HITTING UNDERNEATH THE VEHICLE. HIGH VOLTAGE HARNESS WAS DAMAGED RESULTING IN EN…
Read full complaint
2008 MERCURY MARINER HYBRID NO CRANK. VEHICLE WAS FOUND TO HAVE DAMAGED HIGH VOLTAGE WIRING HARNESS. HARNESS RUNS ALONG UNDERNEATH THE PASSENGER SIDE OF THE VEHICLE CABIN. HARNESS IS PARTIALLY ENCASED PVC. PVC WAS DAMAGED POSSIBLY DUE TO ROAD HAZARD HITTING UNDERNEATH THE VEHICLE. HIGH VOLTAGE HARNESS WAS DAMAGED RESULTING IN ENTIRE HARNESS BEING REPLACED. FORD WOULD NOT PAY FOR REPAIR. THIS IS A SERIOUS ISSUE AND POSSIBLY A DESIGN FLAW. I STILL HAVE THE HARNESS IN MY POSSESSION AND WOULD BE WILLING TO PROVIDE IT FOR PURPOSE OF INVESTIGATION. *TR
NHTSA ODI #10267617
150 miles · Nov 22, 2006
Air BagsElectrical System
THIS PROBLEM OCCURS ON MY 2007 MERCURY MARINER HYBRID WITH LESS THAN 2,500 MILES. WHEN THERE IS A FRONT SEAT ADULT PASSENGER THE LIGHT ON THE DASH INTERMITTENTLY LIGHTS TO STATE "PASS AIRBAG OFF". THE ONLY OTHER TIME THIS LIGHT IS ILLUMINATED IS BRIEFLY DURING START UP. IT IS THE INTERMITTENT NATURE OF THIS LIGHT COMING ON AND …
Read full complaint
THIS PROBLEM OCCURS ON MY 2007 MERCURY MARINER HYBRID WITH LESS THAN 2,500 MILES. WHEN THERE IS A FRONT SEAT ADULT PASSENGER THE LIGHT ON THE DASH INTERMITTENTLY LIGHTS TO STATE "PASS AIRBAG OFF". THE ONLY OTHER TIME THIS LIGHT IS ILLUMINATED IS BRIEFLY DURING START UP. IT IS THE INTERMITTENT NATURE OF THIS LIGHT COMING ON AND GOING OFF WHEN THERE IS A PASSENGER THAT CAUSES ANXIETY FOR THE DRIVER AND PASSENGER. THERE HAVE ONLY BEEN ADULT PASSENGERS IN THIS VEHICLE. I HAVE TAKEN THE VEHICLE TO THE FORD-LINCOLN-MERCURY DEALER AND THE SERVICE ADVISOR SAID THERE WAS NOTHING THAT COULD BE DONE TO FIX THIS SITUATION. SHE SUGGESTED THAT THE PASSENGER SIT IN THE BACK SEAT. THIS IS AN UNACCEPTABLE SOLUTION. *JB
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
2007 Mercury Mariner Problems, Complaints & Recalls | Skip That Year
Illustration