← New search

2005 Mercury Grand Marquis

Owner reports · Recalls · Investigations

More warning signs than most Grand Marquis years

Owner complaints for the 2005 Mercury Grand Marquis are substantially higher than the model-year median of 78.

About this comparison →

When problems were reported

Mileage at the reported incident

395 reports with mileage · 92 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Exterior Lighting. Review the 292 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Air Bags. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

24 crash reports5 fire reports13 injury reports

What owners actually said

487 reports
105,000 miles · Nov 19, 2018
Steering

TL* THE CONTACT OWNS A 2005 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED WITHOUT WARNING AND HAD TO BE TURNED WITH FORCE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V704000 (STEERING) AND 13V385000 (STEERING), BUT EXHIBITED THE SAME FAILURES RELATED TO THE RECALL CAMPAIGNS. THE VEHICLE …

Read full complaint

TL* THE CONTACT OWNS A 2005 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED WITHOUT WARNING AND HAD TO BE TURNED WITH FORCE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V704000 (STEERING) AND 13V385000 (STEERING), BUT EXHIBITED THE SAME FAILURES RELATED TO THE RECALL CAMPAIGNS. THE VEHICLE WAS NOT INCLUDED IN NHTSA ACTION NUMBER: PE14021 (STEERING, ENGINE AND ENGINE COOLING). THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

NHTSA ODI #11152486

108,802 miles · Nov 15, 2018
Exterior Lighting

TL* THE CONTACT OWNS A 2005 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT THE HEADLIGHTS FAILED TO ILLUMINATE. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HEADLIGHT SWITCH FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS …

Read full complaint

TL* THE CONTACT OWNS A 2005 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT THE HEADLIGHTS FAILED TO ILLUMINATE. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HEADLIGHT SWITCH FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V861000 (EXTERIOR LIGHTING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 108,802.

NHTSA ODI #11151727

107,000 miles · Oct 9, 2018
Visibility

TL* THE CONTACT OWNS A 2005 MERCURY GRAND MARQUIS. WHILE THE VEHICLE WAS STATIONARY, THE AIR CONDITIONER FRACTURED AND CAUSED THE DEFROSTER TO BECOME INOPERATIVE. THE CONTACT STATED THAT HOT AIR BLEW FROM THE DEFROSTER AND IT FAILED TO CLEAR THE WINDSHIELD AND SIDE WINDOWS. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE MODE DOOR AC…

Read full complaint

TL* THE CONTACT OWNS A 2005 MERCURY GRAND MARQUIS. WHILE THE VEHICLE WAS STATIONARY, THE AIR CONDITIONER FRACTURED AND CAUSED THE DEFROSTER TO BECOME INOPERATIVE. THE CONTACT STATED THAT HOT AIR BLEW FROM THE DEFROSTER AND IT FAILED TO CLEAR THE WINDSHIELD AND SIDE WINDOWS. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE MODE DOOR ACTUATOR UNDERNEATH THE DASHBOARD NEEDED TO BE REPLACED. MIKE FITZPATRICK FORD (238 BULLSBORO DRIVE, NEWNAN, GEORGIA 30263) WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 107,000.

NHTSA ODI #11139304

95,178 miles · Sep 18, 2018
Air Bags

AIR BAG LIGHT ILLUMINATED UPON VEHICLE STARTUP. LIGHT FLASHES 3,4 THREE TIMES THEN REMAINS CONSTANT. DIAGNOSTICS INDICATES MALFUNCTION DRIVER AND PASSENGER SIDE SEATBELT PRETENSIONERS. FORD ESTIMATED REPLACEMENT COST $1,400.00. OEM PART NUMBERS SUPERSEDED BY REPLACEMENT NUMBERS. SHOULD BE RECALLED!!!

NHTSA ODI #11130192

48,000 miles · Aug 28, 2018
Air BagsSeat Belts

AIR BAG LIGHT STAYS ON. WHEN STARTING CAR, GET 3 DINGS TWICE, PAUSE, REPEAT ... I HAVE BEEN TOLD BY A LOCAL DEALER IT WILL COST $600-$1200 TO FIX. CONSIDERING THE NUMBER OF COMPLAINTS ON THIS ISSUE AND THE FACT THAT IT IS A SAFETY ISSUE, WHY HAS NHTSA NOT REQUIRED A RECALL? SINCE I CANNOT AFFORD THE COST, I GUESS I WILL HAVE …

Read full complaint

AIR BAG LIGHT STAYS ON. WHEN STARTING CAR, GET 3 DINGS TWICE, PAUSE, REPEAT ... I HAVE BEEN TOLD BY A LOCAL DEALER IT WILL COST $600-$1200 TO FIX. CONSIDERING THE NUMBER OF COMPLAINTS ON THIS ISSUE AND THE FACT THAT IT IS A SAFETY ISSUE, WHY HAS NHTSA NOT REQUIRED A RECALL? SINCE I CANNOT AFFORD THE COST, I GUESS I WILL HAVE TO LIVE WITH IT AS I AM SURE MANY OTHERS ARE DOING.

NHTSA ODI #11123013

110,000 miles · Aug 10, 2018
Air Bags

TL* THE CONTACT OWNS A 2005 MERCURY GRAND MARQUIS. WHEN THE VEHICLE WAS STARTED, THE AIR BAG WARNING INDICATOR ILLUMINATED AND REMAINED LIT, WHICH WAS A SAFETY CONCERN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V861000 (EXTERIOR LIGHTING). THE CONTACT CALLED SETH WADLEY FORD LINCOLN AT 877-710-2709 (LOCATED A…

Read full complaint

TL* THE CONTACT OWNS A 2005 MERCURY GRAND MARQUIS. WHEN THE VEHICLE WAS STARTED, THE AIR BAG WARNING INDICATOR ILLUMINATED AND REMAINED LIT, WHICH WAS A SAFETY CONCERN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V861000 (EXTERIOR LIGHTING). THE CONTACT CALLED SETH WADLEY FORD LINCOLN AT 877-710-2709 (LOCATED AT 333 N. BUTLER ROAD, PAULS VALLEY, OK 73075) AND WAS INFORMED TO SCHEDULE A DIAGNOSTIC TEST. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT BACK TO THE DEALER. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI #11118948

74,000 miles · Jul 7, 2018
Exterior Lighting

LIGHTS GO OFF. BOTH STATIONARY AND MOVING. VERY SCARY. CONTACTED DEALER AND THE SAID THEY CAN'T GET THE RECALLED PART FOR MY CAR. THE LIGHTING MODGULE

NHTSA ODI #11110018

124,000 miles · Jun 15, 2018
Steering

I NOV 2014 I TOOK MY GRAND MARQUIS IN FOR A SAFETY RECALL FOR THE LCM (LIGHT CONTROL MODULE),. WHILE THERE, THEY ALSO REPLACED THE LOWER STEER SHAFT FOR A SECOND RECALL THAT I WAS UNAWARE OF (RECALL 13S08). I HAVE BEEN HAVING ISSUES WITH THE STEERING LOCKING UP AT LOW SPEEDS, SO I HAD THE FORD DEALERSHIP CHECK IT. THE SHOWED ME …

Read full complaint

I NOV 2014 I TOOK MY GRAND MARQUIS IN FOR A SAFETY RECALL FOR THE LCM (LIGHT CONTROL MODULE),. WHILE THERE, THEY ALSO REPLACED THE LOWER STEER SHAFT FOR A SECOND RECALL THAT I WAS UNAWARE OF (RECALL 13S08). I HAVE BEEN HAVING ISSUES WITH THE STEERING LOCKING UP AT LOW SPEEDS, SO I HAD THE FORD DEALERSHIP CHECK IT. THE SHOWED ME THE LOWER SHAFT THAT HAD BEEN REPLACE UNDER THE RECALL (BY THEM) AND SHOWED ME THE INTERMEDIATE SHAFT THAT NOW NEEDS REPLACE DUE TO BEING FROZEN FROM CORROSION. THAT PART WAS ALSO PART OF THE RECALL 13S08, BUT WAS NOT REPLACED. THERE WAS A SECOND RECALL ISSUED ALSO 13R01. NOW FORD IS TELLING ME THERE IS NO OPEN RECALLS ON MY VEHICLE AND THAT DUE TO AGE AND MILEAGE IT IS NO LONGER COVERED UNDER WARRANTY. THIS IS NOT A WARRANTY ISSUE, IT IS A SAFETY RECALL ISSUE, THAT WAS NOT PROPERLY FIXED THE FIRST TIME. FORD NOW WANTS TO CHARGE ME $600 FOR PARTS AND LABOR FOR A REPAIR THAT SHOULD HAVE BEEN COMPLETED UNDER A SAFETY RECALL.

NHTSA ODI #11102018

Mileage unknown · Jun 6, 2018
Exterior Lighting

TL* THE CONTACT OWNS A 2005 MERCURY GRAND MARQUIS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V861000 (EXTERIOR LIGHTING); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (NEWINS BAY SHORE FORD…

Read full complaint

TL* THE CONTACT OWNS A 2005 MERCURY GRAND MARQUIS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V861000 (EXTERIOR LIGHTING); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (NEWINS BAY SHORE FORD IN BAY SHORE, NY) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI #11100143

111,000 miles · Jun 4, 2018
Air Bags

DASHBOARDL LIGHT IS ON TOLD IT WAS AN AIRBAG PROBLEM

NHTSA ODI #11099524

Official recalls

4

15V861000 · Exterior Lighting:headlights

Dec 22, 2015

Ford Motor Company (Ford) is recalling certain model year 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles manufactured October 3, 2001, to August 2, 2005. The affected vehicles have a lighting control module (LCM) that may fail, resulting in a loss of headlights.

Consequence & remedy

Consequence: A loss of headlights can reduce driver visibility and increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the LCM, free of charge. The recall began April 14, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S39.

14V704000 · Steering:rack And Pinion:pinion Shaft

Nov 5, 2014

Ford Motor Company (Ford) is recalling certain model year 2005-2011 Ford Crown Victoria, 2005-2011 Mercury Grand Marquis vehicles manufactured March 23, 2004, to August 30, 2011, and 2005-2011 Lincoln Town Car vehicles manufactured March 8, 2004, to August 30, 2011, and on which the upper intermediate shaft was serviced during the course of safety recall 13V-385. The prior repairs may not have been correctly performed.

Consequence & remedy

Consequence: Improper servicing of the upper intermediate shaft could cause the shaft to separate, which can then result in a loss of steering control, and increasing the risk of a crash.

Remedy: Ford will notify the owners of vehicles whose repair records reflect that the upper intermediate steering shaft was repaired during the course of the prior recall 13V-385. Dealers will inspect and replace the upper immediate shaft if necessary free of charge. The recall began November 17, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S25.

13V385000 · Steering

Aug 29, 2013

Ford is recalling certain model year 2005-2011 Ford Crown Victoria (including Crown Victoria Police Interceptors), Mercury Grand Marquis, and Lincoln Town Car vehicles. The affected vehicles are currently registered or were originally sold in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. Severe corrosion can seize the lower intermediate shaft which may cause the upper intermediate shaft to collapse and the steering column lower bearing to separate.

Consequence & remedy

Consequence: If the lower bearing separates, the vehicle may experience a loss of steering, increasing the risk of a crash.

Remedy: Ford will notify owners and dealers will replace the lower intermediate shaft, free of charge. The upper intermediate shaft and steering column lower bearing will be inspected to identify any damage that may have occurred as a result of lower intermediate shaft corrosion, and repaired or replaced as necessary. If the steering column lower bearing has separated, a retainer clip will be installed. The recall began on October 23, 2013. Owners may contact Ford at 1-866-436-7332. Ford's recall number is 13S08.

05V518000 · Electrical SYSTEM:12V/24V/48V Battery:cables

Nov 9, 2005

ON CERTAIN PASSENGER VEHICLES, THE BATTERY CABLE INCLUDES A FUSIBLE LINK THAT MAY CONTACT AND SUBSEQUENTLY CHAFE ON A #2 CROSS MEMBER ATTACHING BOLT.

Consequence & remedy

Consequence: THIS CONDITION MAY RESULT IN HEAT DAMAGE AND COULD LEAD TO A FIRE.

Remedy: DEALERS WILL INSPECT THE FUSIBLE LINK AND POSITION IT AWAY FROM THE CROSS MEMBER BOLT. IF THE FUSIBLE LINK HAS ALREADY CHAFED AND COPPER WIRES HAVE BEEN EXPOSED, THE FUSIBLE LINK WILL BE REPLACED. THE RECALL BEGAN ON NOVEMBER 18, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673, OR LINCOLN/MERCURY AT 1-800-521-4140.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

PE15028 · Loss Of Headlights

Opened Aug 10, 2015 · Closed Jan 8, 2016

Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights

The Office of Defects Investigation (ODI) opened an investigation concerning the loss of headlights in model year (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The subject vehicles share the same architecture and major components.ODI has received 636 unique reports (for all submission dates) related to the alleged defect, with owners describing a loss of both low and/or high beam headlights occurring while driving.ODI identified 4 Vehicle Owner Questionnaire ( VOQ) reports alleging minor crash or loss of control incidents due to headlight failures.Drivers alleged running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 4173 unique reports related to the alleged problem.There were a total of 11 crashes reported within that group as well as one injury that occurred when the vehicle struck an unseen object on the side of the road when the headlights failed. Ford also submitted 49,843 warranty claims related to headlight failures.Most reports indicate that the headlights failed without warning leaving the driver with no forward lighting, however some noted the headlights flickered or dimmed prior to turning off.Consumers also noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is physically actuated.On December 21st, 2015 Ford notified ODI that it would conduct a safety recall (15V-861) to remedy headlight failures on (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.According to Ford, the headlights of the vehicle are controlled by the Lighting Control Module (LCM) located in the engine compartment of the vehicle.The LCM uses an internal relay, mounted to a circuit board, to control power to the headlights. The headlight relay is soldered to the circuit board at six different terminals. The original equipment LCMs were manufactured in a manner that resulted in the solder joints fatiguing and/or cracking as a result of repeated thermal cycling and/or vibration, a defect condition. The condition could be exacerbated by manufacturing quality issues such as an insufficient amount of solder, effecting the continuity between the circuit board and the relay terminal, and resulting in loss of headlights while driving.Other lighting functions are unaffected by this condition.The LCM manufacturing processes were revised to address the defect condition and Ford has been conducting a warranty extension program to cover defective LCMs since late 2013.Under the recall Ford will replace any remaining defective LCMs in recalled vehicles with remedy LCMs once they become available.See NHTSA recall 15V-861 for further details on the safety recall.The recall action initiated by Ford addresses the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Exterior Lighting

The Office of Defects Investigation (ODI) opened an investigation concerning the loss of headlights in model year (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The subject vehicles share the same architecture and major components.ODI has received 636 unique reports (for all submission dates) related to the alleged defect, with owners describing a loss of both low and/or high beam headlights occurring while driving.ODI identified 4 Vehicle Owner Questionnaire ( VOQ) reports alleging minor crash or loss of control incidents due to headlight failures.Drivers alleged running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 4173 unique reports related to the alleged problem.There were a total of 11 crashes reported within that group as well as one injury that occurred when the vehicle struck an unseen object on the side of the road when the headlights failed. Ford also submitted 49,843 warranty claims related to headlight failures.Most reports indicate that the headlights failed without warning leaving the driver with no forward lighting, however some noted the headlights flickered or dimmed prior to turning off.Consumers also noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is physically actuated.On December 21st, 2015 Ford notified ODI that it would conduct a safety recall (15V-861) to remedy headlight failures on (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.According to Ford, the headlights of the vehicle are controlled by the Lighting Control Module (LCM) located in the engine compartment of the vehicle.The LCM uses an internal relay, mounted to a circuit board, to control power to the headlights. The headlight relay is soldered to the circuit board at six different terminals. The original equipment LCMs were manufactured in a manner that resulted in the solder joints fatiguing and/or cracking as a result of repeated thermal cycling and/or vibration, a defect condition. The condition could be exacerbated by manufacturing quality issues such as an insufficient amount of solder, effecting the continuity between the circuit board and the relay terminal, and resulting in loss of headlights while driving.Other lighting functions are unaffected by this condition.The LCM manufacturing processes were revised to address the defect condition and Ford has been conducting a warranty extension program to cover defective LCMs since late 2013.Under the recall Ford will replace any remaining defective LCMs in recalled vehicles with remedy LCMs once they become available.See NHTSA recall 15V-861 for further details on the safety recall.The recall action initiated by Ford addresses the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the identification (ODI) numbers found in the attached list.

Exterior Lighting:headlights

The Office of Defects Investigation (ODI) opened an investigation concerning the loss of headlights in model year (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The subject vehicles share the same architecture and major components.ODI has received 636 unique reports (for all submission dates) related to the alleged defect, with owners describing a loss of both low and/or high beam headlights occurring while driving.ODI identified 4 Vehicle Owner Questionnaire ( VOQ) reports alleging minor crash or loss of control incidents due to headlight failures.Drivers alleged running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 4173 unique reports related to the alleged problem.There were a total of 11 crashes reported within that group as well as one injury that occurred when the vehicle struck an unseen object on the side of the road when the headlights failed. Ford also submitted 49,843 warranty claims related to headlight failures.Most reports indicate that the headlights failed without warning leaving the driver with no forward lighting, however some noted the headlights flickered or dimmed prior to turning off.Consumers also noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is physically actuated.On December 21st, 2015 Ford notified ODI that it would conduct a safety recall (15V-861) to remedy headlight failures on (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.According to Ford, the headlights of the vehicle are controlled by the Lighting Control Module (LCM) located in the engine compartment of the vehicle.The LCM uses an internal relay, mounted to a circuit board, to control power to the headlights. The headlight relay is soldered to the circuit board at six different terminals. The original equipment LCMs were manufactured in a manner that resulted in the solder joints fatiguing and/or cracking as a result of repeated thermal cycling and/or vibration, a defect condition. The condition could be exacerbated by manufacturing quality issues such as an insufficient amount of solder, effecting the continuity between the circuit board and the relay terminal, and resulting in loss of headlights while driving.Other lighting functions are unaffected by this condition.The LCM manufacturing processes were revised to address the defect condition and Ford has been conducting a warranty extension program to cover defective LCMs since late 2013.Under the recall Ford will replace any remaining defective LCMs in recalled vehicles with remedy LCMs once they become available.See NHTSA recall 15V-861 for further details on the safety recall.The recall action initiated by Ford addresses the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the identification (ODI) numbers found in the attached list.

DP15002 · Loss Of Headlamp/exterior Lighting

Opened Apr 1, 2015 · Closed Aug 11, 2015

Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights

In a letter dated October 2, 2014 the Office of Defects Investigation (ODI) was initially petitioned by the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.ODI analyzed Vehicle Owner Questionnaire (VOQ) complaints received from consumers and identified a total of 605 reports (for all submission dates) alleging headlight failure.The complaints indicate failures of both low beam headlights typically while driving, a defect condition that was evaluated under a prior ODI investigation (PE08066).Most consumer VOQs indicate that the headlights failed suddenly and without warning leaving the driver with no forward lighting, however some report the headlights flickered or dimmed prior to turning off.In some cases drivers were able to turn the headlights back on after a period of time while others reported the headlights would not come back on at all.Consumers noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is actuated.ODI identified 4 VOQ reports alleging minor crash or loss of control incidents due to headlight failures.Drivers indicated running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's April 7, 2015 Information Request letter, Ford provided data indicating it has received 3,092 complaints of failed headlights related to the Lighting Control Module (LCM), a device that controls the headlights and other lighting functions.This number includes the complaints Ford reviewed and classified as headlight failure due specifically to the LCM.Within Ford's complaints, there are 11 reports alleging a crash occurred.These drivers reported hitting objects, including other vehicles after the headlights failed causing damage to the affected vehicles.One driver was injured when their car struck an unseen object in the road, jerking the steering wheel from their hands and injuring their shoulder.In total 15 crash allegations were identified, all of which have occurred since ODI's prior evaluation of this issue.This petition has been granted.Preliminary Evaluation PE15-028 has been opened to assess the scope, frequency, and safety-related consequences of the alleged defect.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SarchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Exterior Lighting

In a letter dated October 2, 2014 the Office of Defects Investigation (ODI) was initially petitioned by the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.ODI analyzed Vehicle Owner Questionnaire (VOQ) complaints received from consumers and identified a total of 605 reports (for all submission dates) alleging headlight failure.The complaints indicate failures of both low beam headlights typically while driving, a defect condition that was evaluated under a prior ODI investigation (PE08066).Most consumer VOQs indicate that the headlights failed suddenly and without warning leaving the driver with no forward lighting, however some report the headlights flickered or dimmed prior to turning off.In some cases drivers were able to turn the headlights back on after a period of time while others reported the headlights would not come back on at all.Consumers noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is actuated.ODI identified 4 VOQ reports alleging minor crash or loss of control incidents due to headlight failures.Drivers indicated running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's April 7, 2015 Information Request letter, Ford provided data indicating it has received 3,092 complaints of failed headlights related to the Lighting Control Module (LCM), a device that controls the headlights and other lighting functions.This number includes the complaints Ford reviewed and classified as headlight failure due specifically to the LCM.Within Ford's complaints, there are 11 reports alleging a crash occurred.These drivers reported hitting objects, including other vehicles after the headlights failed causing damage to the affected vehicles.One driver was injured when their car struck an unseen object in the road, jerking the steering wheel from their hands and injuring their shoulder.In total 15 crash allegations were identified, all of which have occurred since ODI's prior evaluation of this issue.This petition has been granted.Preliminary Evaluation PE15-028 has been opened to assess the scope, frequency, and safety-related consequences of the alleged defect.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SarchNHTSAID under the identification (ODI) numbers found in the attached list.

Exterior Lighting:headlights

In a letter dated October 2, 2014 the Office of Defects Investigation (ODI) was initially petitioned by the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.ODI analyzed Vehicle Owner Questionnaire (VOQ) complaints received from consumers and identified a total of 605 reports (for all submission dates) alleging headlight failure.The complaints indicate failures of both low beam headlights typically while driving, a defect condition that was evaluated under a prior ODI investigation (PE08066).Most consumer VOQs indicate that the headlights failed suddenly and without warning leaving the driver with no forward lighting, however some report the headlights flickered or dimmed prior to turning off.In some cases drivers were able to turn the headlights back on after a period of time while others reported the headlights would not come back on at all.Consumers noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is actuated.ODI identified 4 VOQ reports alleging minor crash or loss of control incidents due to headlight failures.Drivers indicated running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's April 7, 2015 Information Request letter, Ford provided data indicating it has received 3,092 complaints of failed headlights related to the Lighting Control Module (LCM), a device that controls the headlights and other lighting functions.This number includes the complaints Ford reviewed and classified as headlight failure due specifically to the LCM.Within Ford's complaints, there are 11 reports alleging a crash occurred.These drivers reported hitting objects, including other vehicles after the headlights failed causing damage to the affected vehicles.One driver was injured when their car struck an unseen object in the road, jerking the steering wheel from their hands and injuring their shoulder.In total 15 crash allegations were identified, all of which have occurred since ODI's prior evaluation of this issue.This petition has been granted.Preliminary Evaluation PE15-028 has been opened to assess the scope, frequency, and safety-related consequences of the alleged defect.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SarchNHTSAID under the identification (ODI) numbers found in the attached list.

PE14021 · Steering Column Shaft Obstruction

Opened Jul 7, 2014 · Closed Nov 21, 2014

Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System; Steering

On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.

Additional source detail variants (2)

Engine And Engine Cooling:exhaust System

On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.

Steering

On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.

PE08066 · Loss Of Headlight Function

Opened Nov 26, 2008 · Closed Mar 24, 2009

Status: closed (inferred from source dates) · Exterior Lighting:headlights

THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF COMPLAINT REPORTS, FIELD AND TECHNICAL DATA PROVIDED BY FORD AND COMPLAINANT INTERVIEWS. FORD FOUND THAT SOME LIGHTING CONTROL MODULES (LCM) IN THE SUBJECT VEHICLES CONTAINED DEFECTIVE SOLDER JOINTS ON THE PRINTED CIRCUIT BOARD.THIS CONDITION CAN LEAD TO POOR HEADLIGHT PERFORMANCE RANGING FROM INTERMITTENT OUTAGE AND DIMMING TO EVENTUAL HEADLIGHTS FAILURE.THE FAILURE DOES NOT AFFECT OTHER LIGHTING FUNCTIONS (PARK, EMERGENCY FLASHER, BRAKE AND FLASH TO PASS LIGHTS).THE AGENCY IS AWARE OF A TOTAL OF 306 CONSUMERS COMPLAINTS AND NO REPORT OF CRASH, INJURY OR FATALITY.FORD REPORTS 2,074 WARRANTY CLAIMS RELATED TO HEADLIGHT FAILURE LINKED TO THE LCM DURING THE FIRST THREE YEARS OF OPERATION.ABOUT 12% (247) OF THESE CLAIMS ARE SPECIFIC TO HEADLIGHT FAILURE WHILE DRIVING.THE AVERAGE WARRANTY RATE FOR HEADLIGHT FAILING WHILE DRIVING IS LOW (0.05%).FORD REPORTS A SLIGHTLY HIGHER WARRANTY RATE EXPERIENCED FOR THE CROWN VICTORIA POLICE INTERCEPTOR VEHICLES AND THIS IS ATTRIBUTED TO THE HIGHER DUTY CYCLE OF THESE VEHICLES (HEADLIGHTS ON FOR LONGER PERIODS).A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.