The contact owns a 2005 Mercury Grand Marquis. The contact stated while driving 45 MPH, the headlights fluctuated off and on without warning. The vehicle was taken to an independent mechanic who stated that the vehicle had experienced the failure listed in NHTSA Campaign Number: 15V861000 (Exterior Lighting) and referred the con…
Read full complaint
The contact owns a 2005 Mercury Grand Marquis. The contact stated while driving 45 MPH, the headlights fluctuated off and on without warning. The vehicle was taken to an independent mechanic who stated that the vehicle had experienced the failure listed in NHTSA Campaign Number: 15V861000 (Exterior Lighting) and referred the contact to the dealer. The dealer was contacted and stated that the vehicle was not included in the recall. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 81,000. The contact stated the failure happened at any speed and that the vehicle was repaired.
NHTSA ODI #11503810
227,000 miles · Sep 19, 2022
Exterior Lighting
The contact owns a 2005 Mercury Grand Marquis. The contact stated that while driving, the front headlights intermittently failed. The contact stated that he replaced the headlight bulbs, but the failure recurred. No warning light was illuminated. The contact referenced NHTSA Campaign Number: 15V861000 (Exterior Lighting). The de…
Read full complaint
The contact owns a 2005 Mercury Grand Marquis. The contact stated that while driving, the front headlights intermittently failed. The contact stated that he replaced the headlight bulbs, but the failure recurred. No warning light was illuminated. The contact referenced NHTSA Campaign Number: 15V861000 (Exterior Lighting). The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and advised the contact to call the NHTSA Hotline. The failure mileage was approximately 227,000.
NHTSA ODI #11485205
Mileage unknown · Jun 7, 2022
Exterior Lighting
The lcm light control module is malfunctioning and Ford/Mercury say that this vehicle is not part of the recall.
NHTSA ODI #11467950
93,000 miles · May 16, 2022
Exterior Lighting
The contact owns a 2005 Mercury Grand Marquis. The contact stated that several years ago while driving at night at an undisclosed speed, the headlights became inoperable. The contact was able to restart the vehicle and the headlights resumed normal operation. The contact took the vehicle to a dealer and had the headlights servic…
Read full complaint
The contact owns a 2005 Mercury Grand Marquis. The contact stated that several years ago while driving at night at an undisclosed speed, the headlights became inoperable. The contact was able to restart the vehicle and the headlights resumed normal operation. The contact took the vehicle to a dealer and had the headlights serviced under a Customer Satisfaction Program. Recently, the contact stated while driving 55 MPH, the headlights became inoperable without warning. The contact was forced to use the hazard lights after multiple attempts to restart the headlights had failed. The contact coasted the vehicle to the nearest gas station and upon arrival the headlights began to operate. The vehicle was taken back to the dealer where he was given an estimate for the repair. The manufacturer was also notified of the failure but offered no assistance. The vehicle had yet to be repaired. The failure mileage was approximately 93,000.
NHTSA ODI #11464830
140,000 miles · Feb 14, 2022
Exterior Lighting
The contact owns a 2005 Mercury Grand Marquis. The contact stated that while driving at undisclosed speeds, the headlights would intermittently turn off and back on. The contact stated that while driving over bumps in the roadway or depressing the accelerator pedal, the headlights would become inoperable. The vehicle was taken t…
Read full complaint
The contact owns a 2005 Mercury Grand Marquis. The contact stated that while driving at undisclosed speeds, the headlights would intermittently turn off and back on. The contact stated that while driving over bumps in the roadway or depressing the accelerator pedal, the headlights would become inoperable. The vehicle was taken to an independent mechanic and diagnosed with an intermittent electrical short in the headlight module. The contact was notified of NHTSA Campaign Number: 15V861000 (Exterior Lighting) however, the VIN was not included. The dealer and manufacturer were made aware of the failure. The vehicle was not repaired. The approximate failure mileage was 140,000.
NHTSA ODI #11451907
Mileage unknown · Feb 1, 2021
Exterior Lighting
THE HEADLIGHTS HAVE FAILED DUE TO DEFECTIVE LIGHT CONTROL MODULE. THIS FAILURE IS NOTED AS FORD RECALL # 15S39, DATED APRIL 14,2017. FORD CUSTOMER SERVICE REP SAYS VEHICLE NOT INCLUDED BUT DID NOT PROVIDE INFORMATION ABOUT RECALL #. CANNOT DRIVE CAR AT NIGHT, EXCEPT TO PULL LEVER FOR BRIGHT LIGHT TOWARD ME (DRIVER).
NHTSA ODI #11391018
139,922 miles · Oct 3, 2020
Exterior Lighting
I WAS OUT DRIVING AT AROUND 9:30 PM AND MY HEADLIGHTS JUST WENT OUT, AFTER I GOT HOME I LOOKED FOR LIGHTING ISSUES WITH THE CAR AND DISCOVERED A RECALL. THE NEXT MORNING I CONTACTED AUTONATION FORD IN MEMPHIS TN, WHERE I RESIDE AND SCHEDULED AN APPOINTMENT TO TAKE CARE OF THE RECALL. I TOOK IT IN ON 8/11/20 , WHERE THEY DID A LC…
Read full complaint
I WAS OUT DRIVING AT AROUND 9:30 PM AND MY HEADLIGHTS JUST WENT OUT, AFTER I GOT HOME I LOOKED FOR LIGHTING ISSUES WITH THE CAR AND DISCOVERED A RECALL. THE NEXT MORNING I CONTACTED AUTONATION FORD IN MEMPHIS TN, WHERE I RESIDE AND SCHEDULED AN APPOINTMENT TO TAKE CARE OF THE RECALL. I TOOK IT IN ON 8/11/20 , WHERE THEY DID A LCM BYPASS THAT WAS TOLD TO ME BY THE SERVICE ADVISOR GARVIN. I PICKED THE CAR UP ON 8/15/20 AND THE LIGHTS WERE WORKING WHEN I LEFT THE AUTONATION BUT AFTER I GOT HOME 30 MINUTES LATER I WENT TO DROP OFF SOME MAIL AT THE MAIL DROP AND THE LIGHTS WENT BACK OUT. I CALL AUTONATION SERVICE DEPARTMENT AND SPOKE WITH SERVICE MANAGER THOMAS AND EXPLAINED THE PROBLEM TO HIM AND MY SITUATION AND WAS TOLD TO BRING IT BACK IN WHEN I COULD. I TOOK IT BACK ON MY FIRST OFF DAY THAT THEY WERE OPEN . I WAS THEN TOLD THAT THEY WOULD LOOK AT THE WORK THEY DID AND IF IT WERE STILL IN PLACE ANYTHING EXTRA WOULD COST ME OUT OF POCKET. I DON'T FEEL AS IF I SHOULD HAVE TO PAY FOR AN ISSUE THAT WASN'T PROPERLY REPAIRED. AS OF TODAY OCTOBER 3,2020 I STILL HAVE NO HEADLIGHTS. I HAVE REPLACED THE MULTIFUNCTION SWITCH, REPLACED THE BULBS AND I STILL HAVE NO HEADLIGHTS.
NHTSA ODI #11362564
Mileage unknown · Feb 19, 2020
Exterior Lighting
2005 FORD GRAND MARQUIS. CONSUMER WRITES IN REGARDS TO LIGHTING CONTROL MODULE SAFETY RECALL. *LD THE CONSUMER STATED THE EXPERIENCE AT THE DEALERSHIP WAS UNFAVORABLE. THE VEHICLE WAS NOT REPAIRED. *JS
NHTSA ODI #11309233
110,000 miles · Jan 16, 2020
Exterior Lighting
LIGHTS GOING ON AND OFF I READ RECALL ON THE LIGHTNING CONTROL MODULE FOR MY 2005 MERCURY MARQUIS. THIS HAPPENS IN MOTION ON INTERSTATE. SAFETY HAZARD COULD CAUSE ME TO WRECK
NHTSA ODI #11299796
Mileage unknown · Jan 7, 2020
Electrical SystemExterior Lighting
I PURCHASED A 05 MERCURY GRAND MARQUIS AND HAD ISSUES WITH THE HEADLIGHTS GOING OUT WHILE DRIVING AT NIGHT. I SEEN THAT THERE WAS A RECALL ON THIS ISSUE FOR MY VEHICLE BUT WHEN I CALLED THE FORD DEALER THEY SAID MY CAR WASN'T REGISTERED FOR A RECALL. THEY SAID I WOULD HAVE TO PAY $135 FOR A DIAGNOSTIC TEST AND LEAVE MY CAR FOR 2…
Read full complaint
I PURCHASED A 05 MERCURY GRAND MARQUIS AND HAD ISSUES WITH THE HEADLIGHTS GOING OUT WHILE DRIVING AT NIGHT. I SEEN THAT THERE WAS A RECALL ON THIS ISSUE FOR MY VEHICLE BUT WHEN I CALLED THE FORD DEALER THEY SAID MY CAR WASN'T REGISTERED FOR A RECALL. THEY SAID I WOULD HAVE TO PAY $135 FOR A DIAGNOSTIC TEST AND LEAVE MY CAR FOR 24 HOURS. NO ONE WAS ABLE TO INFORM ME WHY MY SPECIFIC VEHICLE WAS EXCLUDED FROM THE RECALL. IF I'M TELLING THEM THAT I'M HAVING A PROBLEM THAT THEY CLEARLY KNOW ABOUT WHY ARE THEY CHARGING ME TO FIX IT?
Ford Motor Company (Ford) is recalling certain model year 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles manufactured October 3, 2001, to August 2, 2005. The affected vehicles have a lighting control module (LCM) that may fail, resulting in a loss of headlights.
Consequence & remedy
Consequence: A loss of headlights can reduce driver visibility and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the LCM, free of charge. The recall began April 14, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S39.
Ford Motor Company (Ford) is recalling certain model year 2005-2011 Ford Crown Victoria, 2005-2011 Mercury Grand Marquis vehicles manufactured March 23, 2004, to August 30, 2011, and 2005-2011 Lincoln Town Car vehicles manufactured March 8, 2004, to August 30, 2011, and on which the upper intermediate shaft was serviced during the course of safety recall 13V-385. The prior repairs may not have been correctly performed.
Consequence & remedy
Consequence: Improper servicing of the upper intermediate shaft could cause the shaft to separate, which can then result in a loss of steering control, and increasing the risk of a crash.
Remedy: Ford will notify the owners of vehicles whose repair records reflect that the upper intermediate steering shaft was repaired during the course of the prior recall 13V-385. Dealers will inspect and replace the upper immediate shaft if necessary free of charge. The recall began November 17, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S25.
Ford is recalling certain model year 2005-2011 Ford Crown Victoria (including Crown Victoria Police Interceptors), Mercury Grand Marquis, and Lincoln Town Car vehicles. The affected vehicles are currently registered or were originally sold in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. Severe corrosion can seize the lower intermediate shaft which may cause the upper intermediate shaft to collapse and the steering column lower bearing to separate.
Consequence & remedy
Consequence: If the lower bearing separates, the vehicle may experience a loss of steering, increasing the risk of a crash.
Remedy: Ford will notify owners and dealers will replace the lower intermediate shaft, free of charge. The upper intermediate shaft and steering column lower bearing will be inspected to identify any damage that may have occurred as a result of lower intermediate shaft corrosion, and repaired or replaced as necessary. If the steering column lower bearing has separated, a retainer clip will be installed. The recall began on October 23, 2013. Owners may contact Ford at 1-866-436-7332. Ford's recall number is 13S08.
ON CERTAIN PASSENGER VEHICLES, THE BATTERY CABLE INCLUDES A FUSIBLE LINK THAT MAY CONTACT AND SUBSEQUENTLY CHAFE ON A #2 CROSS MEMBER ATTACHING BOLT.
Consequence & remedy
Consequence: THIS CONDITION MAY RESULT IN HEAT DAMAGE AND COULD LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE FUSIBLE LINK AND POSITION IT AWAY FROM THE CROSS MEMBER BOLT. IF THE FUSIBLE LINK HAS ALREADY CHAFED AND COPPER WIRES HAVE BEEN EXPOSED, THE FUSIBLE LINK WILL BE REPLACED. THE RECALL BEGAN ON NOVEMBER 18, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673, OR LINCOLN/MERCURY AT 1-800-521-4140.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
The Office of Defects Investigation (ODI) opened an investigation concerning the loss of headlights in model year (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The subject vehicles share the same architecture and major components.ODI has received 636 unique reports (for all submission dates) related to the alleged defect, with owners describing a loss of both low and/or high beam headlights occurring while driving.ODI identified 4 Vehicle Owner Questionnaire ( VOQ) reports alleging minor crash or loss of control incidents due to headlight failures.Drivers alleged running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 4173 unique reports related to the alleged problem.There were a total of 11 crashes reported within that group as well as one injury that occurred when the vehicle struck an unseen object on the side of the road when the headlights failed. Ford also submitted 49,843 warranty claims related to headlight failures.Most reports indicate that the headlights failed without warning leaving the driver with no forward lighting, however some noted the headlights flickered or dimmed prior to turning off.Consumers also noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is physically actuated.On December 21st, 2015 Ford notified ODI that it would conduct a safety recall (15V-861) to remedy headlight failures on (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.According to Ford, the headlights of the vehicle are controlled by the Lighting Control Module (LCM) located in the engine compartment of the vehicle.The LCM uses an internal relay, mounted to a circuit board, to control power to the headlights. The headlight relay is soldered to the circuit board at six different terminals. The original equipment LCMs were manufactured in a manner that resulted in the solder joints fatiguing and/or cracking as a result of repeated thermal cycling and/or vibration, a defect condition. The condition could be exacerbated by manufacturing quality issues such as an insufficient amount of solder, effecting the continuity between the circuit board and the relay terminal, and resulting in loss of headlights while driving.Other lighting functions are unaffected by this condition.The LCM manufacturing processes were revised to address the defect condition and Ford has been conducting a warranty extension program to cover defective LCMs since late 2013.Under the recall Ford will replace any remaining defective LCMs in recalled vehicles with remedy LCMs once they become available.See NHTSA recall 15V-861 for further details on the safety recall.The recall action initiated by Ford addresses the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the identification (ODI) numbers found in the attached list.
Additional source detail variants (2)
Exterior Lighting
The Office of Defects Investigation (ODI) opened an investigation concerning the loss of headlights in model year (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The subject vehicles share the same architecture and major components.ODI has received 636 unique reports (for all submission dates) related to the alleged defect, with owners describing a loss of both low and/or high beam headlights occurring while driving.ODI identified 4 Vehicle Owner Questionnaire ( VOQ) reports alleging minor crash or loss of control incidents due to headlight failures.Drivers alleged running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 4173 unique reports related to the alleged problem.There were a total of 11 crashes reported within that group as well as one injury that occurred when the vehicle struck an unseen object on the side of the road when the headlights failed. Ford also submitted 49,843 warranty claims related to headlight failures.Most reports indicate that the headlights failed without warning leaving the driver with no forward lighting, however some noted the headlights flickered or dimmed prior to turning off.Consumers also noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is physically actuated.On December 21st, 2015 Ford notified ODI that it would conduct a safety recall (15V-861) to remedy headlight failures on (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.According to Ford, the headlights of the vehicle are controlled by the Lighting Control Module (LCM) located in the engine compartment of the vehicle.The LCM uses an internal relay, mounted to a circuit board, to control power to the headlights. The headlight relay is soldered to the circuit board at six different terminals. The original equipment LCMs were manufactured in a manner that resulted in the solder joints fatiguing and/or cracking as a result of repeated thermal cycling and/or vibration, a defect condition. The condition could be exacerbated by manufacturing quality issues such as an insufficient amount of solder, effecting the continuity between the circuit board and the relay terminal, and resulting in loss of headlights while driving.Other lighting functions are unaffected by this condition.The LCM manufacturing processes were revised to address the defect condition and Ford has been conducting a warranty extension program to cover defective LCMs since late 2013.Under the recall Ford will replace any remaining defective LCMs in recalled vehicles with remedy LCMs once they become available.See NHTSA recall 15V-861 for further details on the safety recall.The recall action initiated by Ford addresses the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the identification (ODI) numbers found in the attached list.
Exterior Lighting:headlights
The Office of Defects Investigation (ODI) opened an investigation concerning the loss of headlights in model year (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles. The subject vehicles share the same architecture and major components.ODI has received 636 unique reports (for all submission dates) related to the alleged defect, with owners describing a loss of both low and/or high beam headlights occurring while driving.ODI identified 4 Vehicle Owner Questionnaire ( VOQ) reports alleging minor crash or loss of control incidents due to headlight failures.Drivers alleged running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 4173 unique reports related to the alleged problem.There were a total of 11 crashes reported within that group as well as one injury that occurred when the vehicle struck an unseen object on the side of the road when the headlights failed. Ford also submitted 49,843 warranty claims related to headlight failures.Most reports indicate that the headlights failed without warning leaving the driver with no forward lighting, however some noted the headlights flickered or dimmed prior to turning off.Consumers also noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is physically actuated.On December 21st, 2015 Ford notified ODI that it would conduct a safety recall (15V-861) to remedy headlight failures on (MY) 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.According to Ford, the headlights of the vehicle are controlled by the Lighting Control Module (LCM) located in the engine compartment of the vehicle.The LCM uses an internal relay, mounted to a circuit board, to control power to the headlights. The headlight relay is soldered to the circuit board at six different terminals. The original equipment LCMs were manufactured in a manner that resulted in the solder joints fatiguing and/or cracking as a result of repeated thermal cycling and/or vibration, a defect condition. The condition could be exacerbated by manufacturing quality issues such as an insufficient amount of solder, effecting the continuity between the circuit board and the relay terminal, and resulting in loss of headlights while driving.Other lighting functions are unaffected by this condition.The LCM manufacturing processes were revised to address the defect condition and Ford has been conducting a warranty extension program to cover defective LCMs since late 2013.Under the recall Ford will replace any remaining defective LCMs in recalled vehicles with remedy LCMs once they become available.See NHTSA recall 15V-861 for further details on the safety recall.The recall action initiated by Ford addresses the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the identification (ODI) numbers found in the attached list.
In a letter dated October 2, 2014 the Office of Defects Investigation (ODI) was initially petitioned by the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.ODI analyzed Vehicle Owner Questionnaire (VOQ) complaints received from consumers and identified a total of 605 reports (for all submission dates) alleging headlight failure.The complaints indicate failures of both low beam headlights typically while driving, a defect condition that was evaluated under a prior ODI investigation (PE08066).Most consumer VOQs indicate that the headlights failed suddenly and without warning leaving the driver with no forward lighting, however some report the headlights flickered or dimmed prior to turning off.In some cases drivers were able to turn the headlights back on after a period of time while others reported the headlights would not come back on at all.Consumers noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is actuated.ODI identified 4 VOQ reports alleging minor crash or loss of control incidents due to headlight failures.Drivers indicated running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's April 7, 2015 Information Request letter, Ford provided data indicating it has received 3,092 complaints of failed headlights related to the Lighting Control Module (LCM), a device that controls the headlights and other lighting functions.This number includes the complaints Ford reviewed and classified as headlight failure due specifically to the LCM.Within Ford's complaints, there are 11 reports alleging a crash occurred.These drivers reported hitting objects, including other vehicles after the headlights failed causing damage to the affected vehicles.One driver was injured when their car struck an unseen object in the road, jerking the steering wheel from their hands and injuring their shoulder.In total 15 crash allegations were identified, all of which have occurred since ODI's prior evaluation of this issue.This petition has been granted.Preliminary Evaluation PE15-028 has been opened to assess the scope, frequency, and safety-related consequences of the alleged defect.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SarchNHTSAID under the identification (ODI) numbers found in the attached list.
Additional source detail variants (2)
Exterior Lighting
In a letter dated October 2, 2014 the Office of Defects Investigation (ODI) was initially petitioned by the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.ODI analyzed Vehicle Owner Questionnaire (VOQ) complaints received from consumers and identified a total of 605 reports (for all submission dates) alleging headlight failure.The complaints indicate failures of both low beam headlights typically while driving, a defect condition that was evaluated under a prior ODI investigation (PE08066).Most consumer VOQs indicate that the headlights failed suddenly and without warning leaving the driver with no forward lighting, however some report the headlights flickered or dimmed prior to turning off.In some cases drivers were able to turn the headlights back on after a period of time while others reported the headlights would not come back on at all.Consumers noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is actuated.ODI identified 4 VOQ reports alleging minor crash or loss of control incidents due to headlight failures.Drivers indicated running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's April 7, 2015 Information Request letter, Ford provided data indicating it has received 3,092 complaints of failed headlights related to the Lighting Control Module (LCM), a device that controls the headlights and other lighting functions.This number includes the complaints Ford reviewed and classified as headlight failure due specifically to the LCM.Within Ford's complaints, there are 11 reports alleging a crash occurred.These drivers reported hitting objects, including other vehicles after the headlights failed causing damage to the affected vehicles.One driver was injured when their car struck an unseen object in the road, jerking the steering wheel from their hands and injuring their shoulder.In total 15 crash allegations were identified, all of which have occurred since ODI's prior evaluation of this issue.This petition has been granted.Preliminary Evaluation PE15-028 has been opened to assess the scope, frequency, and safety-related consequences of the alleged defect.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SarchNHTSAID under the identification (ODI) numbers found in the attached list.
Exterior Lighting:headlights
In a letter dated October 2, 2014 the Office of Defects Investigation (ODI) was initially petitioned by the North Carolina Consumers Council, Inc. requesting a defect investigation of an alleged defect condition resulting in headlight and/or exterior lighting failure on 2003-2005 Ford Crown Victoria and Mercury Grand Marquis vehicles.ODI analyzed Vehicle Owner Questionnaire (VOQ) complaints received from consumers and identified a total of 605 reports (for all submission dates) alleging headlight failure.The complaints indicate failures of both low beam headlights typically while driving, a defect condition that was evaluated under a prior ODI investigation (PE08066).Most consumer VOQs indicate that the headlights failed suddenly and without warning leaving the driver with no forward lighting, however some report the headlights flickered or dimmed prior to turning off.In some cases drivers were able to turn the headlights back on after a period of time while others reported the headlights would not come back on at all.Consumers noted they were able to hold the flash to pass lever on the steering column mounted stalk to activate the high beams however this is only effective as long as the lever is actuated.ODI identified 4 VOQ reports alleging minor crash or loss of control incidents due to headlight failures.Drivers indicated running off of the road due to a lack of headlights and one driver reportedly struck a deer.No injuries were indicated in the VOQ crashes.In response to ODI's April 7, 2015 Information Request letter, Ford provided data indicating it has received 3,092 complaints of failed headlights related to the Lighting Control Module (LCM), a device that controls the headlights and other lighting functions.This number includes the complaints Ford reviewed and classified as headlight failure due specifically to the LCM.Within Ford's complaints, there are 11 reports alleging a crash occurred.These drivers reported hitting objects, including other vehicles after the headlights failed causing damage to the affected vehicles.One driver was injured when their car struck an unseen object in the road, jerking the steering wheel from their hands and injuring their shoulder.In total 15 crash allegations were identified, all of which have occurred since ODI's prior evaluation of this issue.This petition has been granted.Preliminary Evaluation PE15-028 has been opened to assess the scope, frequency, and safety-related consequences of the alleged defect.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SarchNHTSAID under the identification (ODI) numbers found in the attached list.
PE14021 · Steering Column Shaft Obstruction
Opened Jul 7, 2014 · Closed Nov 21, 2014
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System; Steering
On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System
On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.
Steering
On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.
PE08066 · Loss Of Headlight Function
Opened Nov 26, 2008 · Closed Mar 24, 2009
Status: closed (inferred from source dates) · Exterior Lighting:headlights
THE AGENCY HAS CLOSED THIS INVESTIGATION BASED ON ITS REVIEW OF COMPLAINT REPORTS, FIELD AND TECHNICAL DATA PROVIDED BY FORD AND COMPLAINANT INTERVIEWS. FORD FOUND THAT SOME LIGHTING CONTROL MODULES (LCM) IN THE SUBJECT VEHICLES CONTAINED DEFECTIVE SOLDER JOINTS ON THE PRINTED CIRCUIT BOARD.THIS CONDITION CAN LEAD TO POOR HEADLIGHT PERFORMANCE RANGING FROM INTERMITTENT OUTAGE AND DIMMING TO EVENTUAL HEADLIGHTS FAILURE.THE FAILURE DOES NOT AFFECT OTHER LIGHTING FUNCTIONS (PARK, EMERGENCY FLASHER, BRAKE AND FLASH TO PASS LIGHTS).THE AGENCY IS AWARE OF A TOTAL OF 306 CONSUMERS COMPLAINTS AND NO REPORT OF CRASH, INJURY OR FATALITY.FORD REPORTS 2,074 WARRANTY CLAIMS RELATED TO HEADLIGHT FAILURE LINKED TO THE LCM DURING THE FIRST THREE YEARS OF OPERATION.ABOUT 12% (247) OF THESE CLAIMS ARE SPECIFIC TO HEADLIGHT FAILURE WHILE DRIVING.THE AVERAGE WARRANTY RATE FOR HEADLIGHT FAILING WHILE DRIVING IS LOW (0.05%).FORD REPORTS A SLIGHTLY HIGHER WARRANTY RATE EXPERIENCED FOR THE CROWN VICTORIA POLICE INTERCEPTOR VEHICLES AND THIS IS ATTRIBUTED TO THE HIGHER DUTY CYCLE OF THESE VEHICLES (HEADLIGHTS ON FOR LONGER PERIODS).A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2005 Mercury Grand Marquis Problems, Complaints & Recalls | Skip That Year
Illustration