IllustrationALL THE BRAKE LINES ON CAR FROM FRONT TO REAR ARE ROTTED. CAUSE BRAKE FAILURE WHILE DRIVING. *TR
1995 Mercury Grand Marquis
Owner reports · Recalls · Investigations
More warning signs than most Grand Marquis years
Owner complaints for the 1995 Mercury Grand Marquis are substantially higher than the model-year median of 78.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Marquis years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 38 of 179 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports5 fire reports8 injury reports
Service Brakes, Hydraulic complaints
29 reportsTL*THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. THE CONTACT RECEIVED A RECALL NOTICE REGARDING THE VEHICLE SPEED CONTROL. SEVERAL DEALERS HAVE INFORMED HIM THAT THE PARTS FOR THE REPAIR ARE UNAVAILABLE. HE HAS EXPERIENCED THE FOLLOWING FAILURES WITH HIS VEHICLE: THE SERPENTINE BELT, BRAKE ROTORS, FRONT PASSENGER SIDE STRUT…
Read full complaint
TL*THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. THE CONTACT RECEIVED A RECALL NOTICE REGARDING THE VEHICLE SPEED CONTROL. SEVERAL DEALERS HAVE INFORMED HIM THAT THE PARTS FOR THE REPAIR ARE UNAVAILABLE. HE HAS EXPERIENCED THE FOLLOWING FAILURES WITH HIS VEHICLE: THE SERPENTINE BELT, BRAKE ROTORS, FRONT PASSENGER SIDE STRUT, AND ODOMETER. THE MILEAGE INFORMATION AND RECALL NUMBER WERE UNKNOWN.
REAR BRAKE LINE HAD TO BE REPLACED DUE TO SPONGY BRAKES AND EXCESSIVE FLUID LEAKING OUT. PROBLEM CAUSED BY FLOOR PAN STIFFENING RIB CHAFING THE LINE. SECOND PROBLEM WHICH HAS NOT AS YET BEEN CORRECTED IS THAT THE HEADLAMPS ARE COMPLETELY DISCOLORED, YELLOWED MAKING IT DANGEROUS TO DRIVE AT NIGHT. TO REPLACE HEADLAMPS IS OVER …
Read full complaint
REAR BRAKE LINE HAD TO BE REPLACED DUE TO SPONGY BRAKES AND EXCESSIVE FLUID LEAKING OUT. PROBLEM CAUSED BY FLOOR PAN STIFFENING RIB CHAFING THE LINE. SECOND PROBLEM WHICH HAS NOT AS YET BEEN CORRECTED IS THAT THE HEADLAMPS ARE COMPLETELY DISCOLORED, YELLOWED MAKING IT DANGEROUS TO DRIVE AT NIGHT. TO REPLACE HEADLAMPS IS OVER $400.00. LAST PROBLEM IS THAT THE EXTERIOR CLEAR COAT IS PEELING. *JB
DT: THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT WHEN HE APPLIED THE BRAKES THE PEDAL WENT ALL THE WAY TO THE FLOOR. THE CONTACT STATED THAT THE BRAKE FLUID LEAKED FROM THE BRAKE LINE. A CERTIFIED MECHANIC REPLACED THE BRAKE LINES ON THE VEHICLE. THE CONTACT HAS NOT CONTACTED THE MANUFACTURER. TH…
Read full complaint
DT: THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT WHEN HE APPLIED THE BRAKES THE PEDAL WENT ALL THE WAY TO THE FLOOR. THE CONTACT STATED THAT THE BRAKE FLUID LEAKED FROM THE BRAKE LINE. A CERTIFIED MECHANIC REPLACED THE BRAKE LINES ON THE VEHICLE. THE CONTACT HAS NOT CONTACTED THE MANUFACTURER. THE CONTACT STATED AT ONLY 38,000 MILES, WHILE STOPPED AND MAKING A LEFT TURN, THE PITMAN ARM CAME OFF AND CAUSED LOSS OF STEERING CONTROL. A MECHANIC REPAIRED THE PITMAN ARM . *AK
CONSUMER COMPLAINED ABOUT A BRAKE PROBLEM. WHEN APPLYING THE BRAKES BRAKE PEDAL WOULD GO COMPLETELY TO THE FLOOR. OWNER HAD THE VEHICLE TOWED TO THE DEALER, AND WAS INFORMED THAT THE BRAKE LINE COMPLETELY RUSTED AND THERE WAS NO BRAKE FLUID IN THE LINES. *AK
ABS BRAKE SYSTEM: THE TWO FRONT ANTI-LOCK SENSOR INDICATORS-STEEL RING ATTACHED TO THE INSIDE OF THE HUBS-ROTTED OUT. THIS CREATED A LOW VOTAGE OUTPUT AND CYCLED THE ABS SYSTEM INCREASING STOPPING DISTANCE ON DRY PAYMENT. WHEN REMOVED, THE INDICATORS WERE ROTTED TO THE EXTEND THAT THERE WERE HOLES IN THE STEEL. UPON REPLACEMENT,…
Read full complaint
ABS BRAKE SYSTEM: THE TWO FRONT ANTI-LOCK SENSOR INDICATORS-STEEL RING ATTACHED TO THE INSIDE OF THE HUBS-ROTTED OUT. THIS CREATED A LOW VOTAGE OUTPUT AND CYCLED THE ABS SYSTEM INCREASING STOPPING DISTANCE ON DRY PAYMENT. WHEN REMOVED, THE INDICATORS WERE ROTTED TO THE EXTEND THAT THERE WERE HOLES IN THE STEEL. UPON REPLACEMENT, THE ABS SYSTEM WORKED AS DESIGNED. A BETTER MATERIAL MUST BE USED IF MANUFACTURERS ARE GOING TO SELL CARS IN AREAS WHERE ROAD SALT IS USED. MY 96 LINCOLN TOWN CAR USUALLY HAS THE SAME FAILURES.*AK
REAR BRAKE LINES FAILED LAST MONTH AND REPORTED. UPON INSPECTION OF THE FRONT BRAKE LINES, THE LINE TO THE RIGHT BRAKE CALIPER BROKE BY TOUCH. THERE APPEARS TO BE A MAJOR ISSUE WITH THE MATERIAL (STEEL) USED. HOW MANY OTHER CARS HAVE THE SAME ROTTED BRAKE LINES?*AK
REAR STEEL BRAKE LINES FAILED DURING A HARD STOP. BOTH STEEL LINES ARE RUST SO BAD THAT IT'S HARD TO TELL WHICH LINE FAILED. THE FAILED SECTION IS LOCATED ABOUT ONE FOOT IN FRONT OF RIGHT REAR TIRE. BUT THE REST OF THE LINES APPEARS VERY RUSTED. BOTH STEEL LINES WILL BE REPLACED. FORD HAD NO REPAIR PROGRAM FOR THIS ISSUE. MY 196…
Read full complaint
REAR STEEL BRAKE LINES FAILED DURING A HARD STOP. BOTH STEEL LINES ARE RUST SO BAD THAT IT'S HARD TO TELL WHICH LINE FAILED. THE FAILED SECTION IS LOCATED ABOUT ONE FOOT IN FRONT OF RIGHT REAR TIRE. BUT THE REST OF THE LINES APPEARS VERY RUSTED. BOTH STEEL LINES WILL BE REPLACED. FORD HAD NO REPAIR PROGRAM FOR THIS ISSUE. MY 1965 FORD STILL HAS THE FACTORY LINES WHICH ARE STILL IN GREAT CONDITION.! THIS 1995 MERCURY BRAKE SYSTEM WAS FLUSHED EVERY TWO YEARS. THE UNDERSIDE OF THE CAR WAS WASHED AFTER SNOW STORMS TO REMOVE SALT. EVERY SPRING A HEAVY WASH TO REMOVE SALT, DIRT ETC. LINES FAILED FROM THE OUTSIDE IN.*AK
I LEFT THE HOUSE AND AT THE END OF THE STREET THE BRAKE PEDAL WENT TO THE FLOOR. I RETURNED HOME AND CHECK THE CAR OVER AND OBSERVED A SUBSTANTIAL AMOUNT OF BRAKE FLUID LEAKING IN THE AREA IN FRONT OF THE DRIVER'S SIDE REAR WHEEL. UPON CLOSER INSPECTION,THE FLUID WAS COMING FROM THE WHEEL WELL WHERE THE BRAKE LINE GOES BETWEEN T…
Read full complaint
I LEFT THE HOUSE AND AT THE END OF THE STREET THE BRAKE PEDAL WENT TO THE FLOOR. I RETURNED HOME AND CHECK THE CAR OVER AND OBSERVED A SUBSTANTIAL AMOUNT OF BRAKE FLUID LEAKING IN THE AREA IN FRONT OF THE DRIVER'S SIDE REAR WHEEL. UPON CLOSER INSPECTION,THE FLUID WAS COMING FROM THE WHEEL WELL WHERE THE BRAKE LINE GOES BETWEEN THE FRAME AND THE BODY OF THE CAR. I COULD NOT SEE EXACTLY WHERE THE LEAK WAS COMING FROM OR THE CAUSE A LEAK. I MADE A TRIP TO THE DEALER TWICE (IN ANOTHER CAR). THEY ADVISED TO GET THE CAR TO THE DEALER AND THAT THE CHARGE WOULD BE $84.00 TO LOOK AT THE CAR AND AT THAT TIME I WOULD GET A ESTIMATE TO REPAIR. I WAS ADVISED THAT THERE WAS NO RECALL OR TECHNICAL SERVICE BULLETINS FOR THIS CAR. THE CAR REMAINS IN THE DRIVEWAY INOPERABLE AT THIS PRESENT TIME.
BRAKE PEDAL WENT TO THE FLOOR WITHOUT WARNING. RED BRAKE CAUTION LIGHT WAS OBSERVED ONLY AFTER THE FAILURE.THERE WAS NO BRAKING POWER. I HAD TO DRIVE HOME SLOWLY WITH USE OF PARKING BRAKE. I OBSERVED A LARGE AMOUNT OF BRAKE FLUID DRIPPING FROM THE AREA IN FRONT OF THE DRIVERS SIDE REAR WHEEL. WITH THE CAR JACKED UP, UPON CLOSER …
Read full complaint
BRAKE PEDAL WENT TO THE FLOOR WITHOUT WARNING. RED BRAKE CAUTION LIGHT WAS OBSERVED ONLY AFTER THE FAILURE.THERE WAS NO BRAKING POWER. I HAD TO DRIVE HOME SLOWLY WITH USE OF PARKING BRAKE. I OBSERVED A LARGE AMOUNT OF BRAKE FLUID DRIPPING FROM THE AREA IN FRONT OF THE DRIVERS SIDE REAR WHEEL. WITH THE CAR JACKED UP, UPON CLOSER INSPECTION, I OBSERVED THAT THERE WAS A SECTION OF THE BRAKE LINE RUSTED, CORRODED AND WET FROM BRAKE FLUID. THERE WAS A HOLE IN THE BRAKE LINE AS IT MAY HAVE RUBBED A HOLE IN THE BRAKE LINE DUE TO CLOSE CONTACT WITH THE FRAME. I FURTHER OBSERVED A SMALL PIECE OF BLACK CLOTH ELECTRICAL TAPE UNDER THE AFFECTED BRAKE LINE FAILURE. I ALSO OBSERVED THAT THAT THERE WAS A PINK COLOR PAINT ON THE RUBBER DONUT THAT IS USED BETWEEN THE FRAME AND BODY AND THAT THERE WAS A THE SAME COLOR PINK (DOT THE SIZE OF A QUARTER) PAINTED ON THE CENTER OF THE DRIVERS REAR SIDE BRAKE DISK. THIS POSSBILY DONOTES THAT THERE WAS A DEALER UPDATE IN THE PAST. THIS WAS DONE WITHOUT MY KNOWLEDGE AS I HAVE ALL THE REPAIR SLIPS SINCE. SERVICE DEALER DISAVOWS ANY KNOWLEDGE OF PAST PROBLEMS DESPITE THE DOCUMENTS THAT WERE PROVIDED TO THEM. I WAS ADVISED THAT I WOULD HAVE TO GET THE CAR TO THE DEALER AND PAY A $85.00 CHARGE BEFORE BEING PROVIDED A ESTIMATE TO REPAIR. I HAVE TAKE SEVERAL DIGITAL PHOTOS OF THE AFFECTED AREA AND ANOTHER AREA OF THE BRAKE LINE THAT HAD BEEN RUBBING AGAINST A SHARP EDGE OF THE FRAME BUT HAS NOT YET FAILED. I ALSO OBSERVED THAT THE COMPRESSION RUBBER DONUT THAT IS USED TO KEEP VIBRATION, NOISE AND COMFORT ON THE PASSENGER SIDE HAD BEEN PAINTED WITH THE SAME PINK COLOR AND THAT THE PAINT WAS COVERED WITH TWO PIECES OF BLACK CLOTH TAPE. FROM MY RESEARCH THE POLICE, TAXI VEHICLES OF THE SAME MY 95-97 HAD THE SAME PROBLEMS AND HAD BEEN BROUGHT BACK TO THE DEALER FOR CORRECTION HOWEVER THE CONSUMER VEHICLES HAVE NOT BEEN CORRECTED. *AK
Official recalls
508V051000 · Vehicle Speed Control:cruise Control
Feb 4, 2008
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
07V336000 · Vehicle Speed Control
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
96V045000 · Seat Belts:front:anchorage
Mar 5, 1996
THE RIVETS HOLDING THE REAR OUTBOARD BELT D-RINGS WERE NOT HEAT TREATED PROPERLY CAUSING THE HEADS OF THE RIVETS TO FRACTURE UNDER LOAD AND FAIL TO HOLD THE D-RINGS TO THE STRAPS. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THIS CONDITION CAN REDUCE THE RESTRAINING CAPABILITIES OF THE SAFETY BELT IN THE EVENT OF AN ACCIDENT.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT PLATE ON THE REAR OUTBOARD SEAT BELT ASSEMBLY ANCHORAGES INVOLVED IN THIS CAMPAIGN.
95V189000 · Electrical System:wiring:fuses And Circuit Breakers
Oct 2, 1995
THESE VEHICLES WERE BUILT WITH THE NON-CYCLING POWER WINDOW CIRCUIT BREAKER AND THE CYCLING HEADLAMP CIRCUIT BREAKER INTERCHANGED.
Consequence & remedy
Consequence: IN THE EVENT OF A SHORT OR OVERLOAD IN THE HEADLAMPCIRCUIT, BOTH HEADLAMPS CAN GO OUT WITHOUT WARNING, RATHER THAN FLASHING AS INTENDED WITH THE CYCLING CIRCUIT BREAKER. THIS COULD LEAD TO REDUCED NIGHT TIME DRIVER VISIBILITY, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THESE VEHICLES, REMOVE THE CIRCUIT BREAKER AND REINSTALL THE BREAKER IN THE CORRECT LOCATIONS.
95V063000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
Mar 27, 1995
THE SEAL MATERIAL BETWEEN THE FUEL FILLER PIPE AND FUEL TANK MAY NOT HAVE BEEN FULLY CURED DURING THE MOLDING PROCESS WHICH COULD ALLOW FOR FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE COULD RESULT IN A VEHICLE FIRE IF AN IGNITION SOURCE WERE PRESENT.
Remedy: DEALERS WILL REPLACE THE FUEL FILLER PIPE-TO-FUEL TANK SEAL WITH A NEW SEAL OF DIFFERENT MATERIAL.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA03012 · Rear Brake Line Failure
Opened Jul 25, 2003 · Closed Apr 11, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Service Brakes, Hydraulic:fluid
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Service Brakes, Hydraulic
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
RQ03004 · Rear Brake Line Failure
Opened Mar 11, 2003 · Closed Jul 25, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Additional source detail variants (4)
Service Brakes, Hydraulic:fluid
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic:foundation Components
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
RQ03002 · Ball Joint Separation
Opened Jan 3, 2003 · Closed Jun 3, 2003
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available