NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
20 reportsClear category filter76,000 miles · May 9, 2014
Electrical SystemExterior Lighting
TL* THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE HEADLIGHTS SUDDENLY MALFUNCTIONED AND BECAME INOPERABLE. THE CONTACT SWITCHED ON THE HIGH BEAMS THAT ALSO MALFUNCTIONED WITHIN A FEW MINUTES AND FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSE…
Read full complaint
TL* THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE HEADLIGHTS SUDDENLY MALFUNCTIONED AND BECAME INOPERABLE. THE CONTACT SWITCHED ON THE HIGH BEAMS THAT ALSO MALFUNCTIONED WITHIN A FEW MINUTES AND FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE HEAD LAMP CIRCUIT WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT BUT NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 76,000. UPDATED 07/28/14 MA THE CONSUMER REFERENCED RECALL # 95V189000. UPDATED 07/29/14
NHTSA ODI #10587441
90,000 miles · Apr 5, 2010
Electrical SystemVehicle Speed ControlFire
TL* THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. WHILE DRIVING AT SPEEDS OF 55 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD AND DROVE ONTO THE EMERGENCY LANE. THE CONTACT CONFIRMED THAT THE FIRE BEGAN INSIDE THE DASHBOARD AREA AND SPREAD TO THE COMPONENTS UNDER THE HOOD. THE VEHICLE WAS DESTROYED. THE POLICE WERE…
Read full complaint
TL* THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. WHILE DRIVING AT SPEEDS OF 55 MPH, THE CONTACT NOTICED SMOKE COMING FROM UNDER THE HOOD AND DROVE ONTO THE EMERGENCY LANE. THE CONTACT CONFIRMED THAT THE FIRE BEGAN INSIDE THE DASHBOARD AREA AND SPREAD TO THE COMPONENTS UNDER THE HOOD. THE VEHICLE WAS DESTROYED. THE POLICE WERE CALLED AND A REPORT WAS FILED; HOWEVER, THE FAILURE AND CURRENT MILEAGES WERE 90,000. UPDATED 6/1/10 *CN UPDATED 06/18/10.*JB
NHTSA ODI #10323769
82,000 miles · May 29, 2009
Electrical SystemExterior Lighting
TL*THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. THE CONTACT NOTICED THAT THE SPEEDOMETER AND HEADLIGHTS FAILED ON HIS VEHICLE. THE DEALER STATED THAT THE DIGITAL DISPLAY BOARD FAILED. THE REPAIR COST WAS ESTIMATED AT $1,000. THE MANUFACTURER STATED THAT THEY WOULD ONLY REPAIR THE VEHICLE ACCORDING TO NHTSA CAMPAIGN ID NUMB…
Read full complaint
TL*THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. THE CONTACT NOTICED THAT THE SPEEDOMETER AND HEADLIGHTS FAILED ON HIS VEHICLE. THE DEALER STATED THAT THE DIGITAL DISPLAY BOARD FAILED. THE REPAIR COST WAS ESTIMATED AT $1,000. THE MANUFACTURER STATED THAT THEY WOULD ONLY REPAIR THE VEHICLE ACCORDING TO NHTSA CAMPAIGN ID NUMBER 07V336000 (VEHICLE SPEED CONTROL). THE VEHICLE WILL BE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 82,000. UPDATED 06/27/09 *BF UPDATED 06/23/09.*JB
NHTSA ODI #10272363
Mileage unknown · Mar 19, 2008
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
TL*THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. THE CONTACT RECEIVED A RECALL NOTICE REGARDING THE VEHICLE SPEED CONTROL. SEVERAL DEALERS HAVE INFORMED HIM THAT THE PARTS FOR THE REPAIR ARE UNAVAILABLE. HE HAS EXPERIENCED THE FOLLOWING FAILURES WITH HIS VEHICLE: THE SERPENTINE BELT, BRAKE ROTORS, FRONT PASSENGER SIDE STRUT…
Read full complaint
TL*THE CONTACT OWNS A 1995 MERCURY GRAND MARQUIS. THE CONTACT RECEIVED A RECALL NOTICE REGARDING THE VEHICLE SPEED CONTROL. SEVERAL DEALERS HAVE INFORMED HIM THAT THE PARTS FOR THE REPAIR ARE UNAVAILABLE. HE HAS EXPERIENCED THE FOLLOWING FAILURES WITH HIS VEHICLE: THE SERPENTINE BELT, BRAKE ROTORS, FRONT PASSENGER SIDE STRUT, AND ODOMETER. THE MILEAGE INFORMATION AND RECALL NUMBER WERE UNKNOWN.
NHTSA ODI #10221748
110,000 miles · Aug 16, 2007
Electrical System
I PURCHASED MY 1995 MERCURY GRAND MARQUIS USED IN JUNE OF 2005. I'VE HAD INTERMITTENT PROBLEMS WITH THE HORN SINCE THEN. LAST SUMMER, I REPLACED THE HORN BECAUSE ONE OF THE 2 TONES HAD FAILED. UPON REMOVAL OF THE ORIGINAL HORNS, IT WAS DISCOVERED THAT THE HORNS HAD SEVERE CORROSION, AND COULD NOT BE REUSED. I PURCHASED 2 NEW…
Read full complaint
I PURCHASED MY 1995 MERCURY GRAND MARQUIS USED IN JUNE OF 2005. I'VE HAD INTERMITTENT PROBLEMS WITH THE HORN SINCE THEN. LAST SUMMER, I REPLACED THE HORN BECAUSE ONE OF THE 2 TONES HAD FAILED. UPON REMOVAL OF THE ORIGINAL HORNS, IT WAS DISCOVERED THAT THE HORNS HAD SEVERE CORROSION, AND COULD NOT BE REUSED. I PURCHASED 2 NEW HORNS, AND HAD THEM INSTALLED. IF I PRESS THE HORN BUTTON ON THE STEERING WHEEL FOR MORE THAN 5 SECONDS, THE HORN SHORTS OUT THE FUSE, AND I'M LEFT WITH NO HORN ON THE HIGHWAY. I DRIVE 23.5 MILES EACH WAY TO WORK, IN HEAVY HIGHWAY TRAFFIC, AND THE LOSS OF MY HORN IS EXTREMELY DANGEROUS WHEN YOU ARE AROUND DRIVERS WHO DON'T CHECK BEFORE CHANGING LANES. IN THE PAST YEAR, I HAVE REPLACED THE FUSE 6 TIMES. I AM AGAIN LEFT WITH ONLY 1 OF 2 TONES ON THE HORN, AND WILL NEED TO REPLACE THE HORNS AGAIN. IT APPEARS THAT THE LOCATION OF THE HORN UNDER THE ENGINE BEHIND THE FRONT BUMPER IS A CONTRIBUTING FACTOR TO THE CORROSION PROBLEM. IS THERE ANYTHING AVAILABLE TO RELOCATE THE HORN TO THE TOP OF THE FIREWALL? ALSO THERE APPEARS TO BE A FACTORY INSTALLED ALARM IN THIS VEHICLE, BUT WE HAVE BEEN UNABLE TO LOCATE THE MASTER CODE WITHIN THE VEHICLE TO RESET THE CODE TO BE ABLE TO USE THE ALARM. ANOTHER PROBLEM WE HAVE BEEN HAVING IS THAT THE WINDSHIELD WASHER SWITCH IS SENSITIVE, AND DOESN'T ALWAYS WORK. WE HAVE TO PLAY WITH THE SWITCH, ROCKING IT BACK AND FORTH TO GET THE WASHER FLUID TO PUMP. IN ADDITION, THE FLUID FREEZES IN THE WINTER, IF YOU DON'T USE THE SUPER DUTY ANTI FREEZE SOLUTION. WHEN THIS HAPPENS, THERE IS A MAJOR PROBLEM DRIVING TO WORK DURING OR AFTER A SNOW STORM, DUE TO ROAD SPLATTERED ON THE WINDSHIELD. I HAVE BEEN KNOWN TO PULL OVER ON THE SIDE OF THE ROAD TO THROW SNOW ON THE WINDSHIELD TO CLEAN THE SALT OFF OF THE WINDOWS. THIS IS DANGEROUS IN RUSH HOUR TRAFFIC, WHEN THE BREAK DOWN LANE IS TURNED INTO A TRAVEL LANE. *JB
NHTSA ODI #10199817
Mileage unknown · Feb 23, 2000
Electrical System
ELECTRICAL DASH GOES OUT WITHOUT WARNING, WHILE DRIVING VEHICLE. OWNER HAS REPLACED FUSES SEVERAL TIMES. DLR HAS SEEN 3 TO 4 TIMES. PROBLEM STILL EXISTS. *AK
NHTSA ODI #857392
Mileage unknown · Jan 31, 2000
Electrical System
VEHICLES BATTERY GOES DEAD AFTER VEHICLE HAS SAT FOR APPROXIMATELY 5 DAYS. BATTERY HAS BEEN REPLACED, ALTERNATOR CHECKED OUT . TOOK VEHICLE TO DEALER ADN DEALER COULD FIND NO CAUSE FOR FAILURE. THIS HAS BEEN AN ONGOING THING FOR THE PAST 16 MONTHS. THERE IS OBVIOUSLY A DRAIN ON THE BATTERY THAT THE DEALER CANNOT FIND. TOOK …
Read full complaint
VEHICLES BATTERY GOES DEAD AFTER VEHICLE HAS SAT FOR APPROXIMATELY 5 DAYS. BATTERY HAS BEEN REPLACED, ALTERNATOR CHECKED OUT . TOOK VEHICLE TO DEALER ADN DEALER COULD FIND NO CAUSE FOR FAILURE. THIS HAS BEEN AN ONGOING THING FOR THE PAST 16 MONTHS. THERE IS OBVIOUSLY A DRAIN ON THE BATTERY THAT THE DEALER CANNOT FIND. TOOK VEHICLE TO MERCURY DEALER FOR SERVICE. *AK
NHTSA ODI #718110
Mileage unknown · May 25, 1999
Air BagsElectrical System
FUSE THAT WORKS THE HORN AND CRUISE CONTROL KEEPS BLOWING OUT. FUSE HAS BEEN REPLACED 15 TIMES WITHIN A 2 MONTH PERIOD. THE DEALER IS AWARE OF THE SITUATION. PROBLEM HAS NOT BEEN CORRECTED. *AK POSSIBLE CLOCKSPRING FAILURE. *YH
NHTSA ODI #838408
Mileage unknown · Feb 18, 1999
Electrical SystemFire
WHEN VEHICLE WAS PARKED IT CAUGHT FIRE WHEN OWNER WAS AWAY. FIRE CAUSED BY FAULTY ELECTRICAL WIRE SHORTING OUT IN THE INTERIOR DOME LIGHT. INTERIOR ROOFING FELL ONTO SEATS AND MATS INSIDE OF VEHICLE. VEHICLE AT DEALER'S BEING REPAIRED. CAR HAD EXPERIENCED PREVIOUS ELECTRICAL PROBLEMS. INSURANCE COMPANY PAID FOR REPAIRS, PROBL…
Read full complaint
WHEN VEHICLE WAS PARKED IT CAUGHT FIRE WHEN OWNER WAS AWAY. FIRE CAUSED BY FAULTY ELECTRICAL WIRE SHORTING OUT IN THE INTERIOR DOME LIGHT. INTERIOR ROOFING FELL ONTO SEATS AND MATS INSIDE OF VEHICLE. VEHICLE AT DEALER'S BEING REPAIRED. CAR HAD EXPERIENCED PREVIOUS ELECTRICAL PROBLEMS. INSURANCE COMPANY PAID FOR REPAIRS, PROBLEM HAS NOT REOCCURRED SINCE. *AK *ML
NHTSA ODI #834959
Mileage unknown · Nov 18, 1998
Electrical SystemPower Train
CONSUMER EXPERIENCING ONGOING PROBLEM WITH TRANSMISSION. AT TIMES COMES TO A COMPLETE STOP. VEHICLE WOULD ESITATE BEFORE IT TAKES OFF. TOOK VEHICLE TO DEALER FOR REPAIRS. DEALER REPLACED TORQUE CONVERTER AND REPROGRAMMED PCM. *AK
NHTSA ODI #829765
Official recalls
5Feb 4, 2008
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Mar 5, 1996
THE RIVETS HOLDING THE REAR OUTBOARD BELT D-RINGS WERE NOT HEAT TREATED PROPERLY CAUSING THE HEADS OF THE RIVETS TO FRACTURE UNDER LOAD AND FAIL TO HOLD THE D-RINGS TO THE STRAPS. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THIS CONDITION CAN REDUCE THE RESTRAINING CAPABILITIES OF THE SAFETY BELT IN THE EVENT OF AN ACCIDENT.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT PLATE ON THE REAR OUTBOARD SEAT BELT ASSEMBLY ANCHORAGES INVOLVED IN THIS CAMPAIGN.
Oct 2, 1995
THESE VEHICLES WERE BUILT WITH THE NON-CYCLING POWER WINDOW CIRCUIT BREAKER AND THE CYCLING HEADLAMP CIRCUIT BREAKER INTERCHANGED.
Consequence & remedy
Consequence: IN THE EVENT OF A SHORT OR OVERLOAD IN THE HEADLAMPCIRCUIT, BOTH HEADLAMPS CAN GO OUT WITHOUT WARNING, RATHER THAN FLASHING AS INTENDED WITH THE CYCLING CIRCUIT BREAKER. THIS COULD LEAD TO REDUCED NIGHT TIME DRIVER VISIBILITY, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THESE VEHICLES, REMOVE THE CIRCUIT BREAKER AND REINSTALL THE BREAKER IN THE CORRECT LOCATIONS.
Mar 27, 1995
THE SEAL MATERIAL BETWEEN THE FUEL FILLER PIPE AND FUEL TANK MAY NOT HAVE BEEN FULLY CURED DURING THE MOLDING PROCESS WHICH COULD ALLOW FOR FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE COULD RESULT IN A VEHICLE FIRE IF AN IGNITION SOURCE WERE PRESENT.
Remedy: DEALERS WILL REPLACE THE FUEL FILLER PIPE-TO-FUEL TANK SEAL WITH A NEW SEAL OF DIFFERENT MATERIAL.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA03012 · Rear Brake Line Failure
Opened Jul 25, 2003 · Closed Apr 11, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Service Brakes, Hydraulic:fluid
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Service Brakes, Hydraulic
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
RQ03004 · Rear Brake Line Failure
Opened Mar 11, 2003 · Closed Jul 25, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Additional source detail variants (4)
Service Brakes, Hydraulic:fluid
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic:foundation Components
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
RQ03002 · Ball Joint Separation
Opened Jan 3, 2003 · Closed Jun 3, 2003
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available
Illustration