I HAVE PICTURES OF THE FUEL PUMP I TOOK OUT OF MY 1992 MERCURY GRAND MARQUIS. THE CAR HAD COUGHED TO A STOP AND I SUSPECTED THE FUEL PUMP. THERE WAS NO PRESSURE IN THE FUEL RAIL SO I PULLED THE PUMP OUT OF THE TANK. I CHECKED THE PUMP WITH A BATTERY AND IT RAN FINE. THEN I STARTED LOOKING AT THE FUSES AND FOUND THE 20A PUMP …
Read full complaint
I HAVE PICTURES OF THE FUEL PUMP I TOOK OUT OF MY 1992 MERCURY GRAND MARQUIS. THE CAR HAD COUGHED TO A STOP AND I SUSPECTED THE FUEL PUMP. THERE WAS NO PRESSURE IN THE FUEL RAIL SO I PULLED THE PUMP OUT OF THE TANK. I CHECKED THE PUMP WITH A BATTERY AND IT RAN FINE. THEN I STARTED LOOKING AT THE FUSES AND FOUND THE 20A PUMP FUSE BLOWN. OBVIOUSLY THERE WAS A SHORT SOMEWHERE. AS YOU CAN SEE BY PIC 2 THE SHORT OCCURRED WHEN THE "HOT" WIRE INSULATION WAS WORN THROUGH ON THE FLOAT BRACKET. IN ORDER TO BLOW A 20A FUSE THERE MUST HAVE BEEN A SPARK. FORTUNATELY, IT APPEARS THAT THE CONTACT POINT WAS UNDER THE LEVEL OF THE GASOLINE WHEN THE SHORT OCCURRED AND NOTHING ELSE HAPPENED. IF THE POINT HAD BEEN ABOVE THE GASOLINE IN THE VAPOR AREA THE RESULTS COULD HAVE BEEN MUCH DIFFERENT. PIC 3 IS HOW I ROUTED THE WIRE BEFORE REPLACING THE ASSEMBLY BACK IN THE TANK. BTW YOU CAN SEE THAT I DID USE A NEW FUEL PUMP. I STILL HAVE THE OLD ONE. I SENT A MESSAGE TO THE FORD MOTOR COMPANY THROUGH THEIR WEB SITE BUT HAVE NOT HEARD ANYTHING. AS OF NOW I AM AFRAID TO DRIVE MY 1997 GRAND MARQUIS SINCE THE DESIGN IS IDENTICAL. I GUESS MY NEXT STOP IS THE DOT OR BETTER YET YOUTUBE. I NEVER DID UNDERSTAND PUTTING AN ELECTRIC MOTOR IN THE FUEL TANK. JERRY HOLLAND *TR
NHTSA ODI #10227239
91,000 miles · Aug 7, 2003
Fuel System, Gasoline
THE CONSUMER WAS CONCERNED THAT IF SHE WAS INVOLVED IN A REAR END COLLISION, THE VEHICLE WOULD CATCH ON FIRE. THE DEALER STATED A RECALL HAD BEEN ISSUED, BUT ONLY FOR POLICE VEHICLES. *AK THE CONSUMER IS AFRAID TO RIDE IN THE VEHICLE. (DAUGHTER MINNIE ORMEROD ON BEHALF OF MOTHER ROSALYN ORMEROD). *PH *JB
NHTSA ODI #10024367
Mileage unknown · Jan 3, 2001
Fuel System, GasolineCrash
AFTER FILLING OR PUTTING GAS IN TANK GAS FUMES FILL TRUNK AND INSIDE CAR.
NHTSA ODI #738689
Mileage unknown · Jul 11, 2000
Fuel System, Gasoline
FUEL LEAKAGE OCCURRED DUE TO THE BRAKE LINE RUBBING AGAINST THE FUEL TANK WHICH ALSO CAUSED THE GAS TANK TO CORRODE. *AK DEALER INSTALLED THE NEW BRAKE LINE IT ALSO HIT THE GAS TANK. *YH
NHTSA ODI #865186
Mileage unknown · Dec 23, 1997
Fuel System, Gasoline
FUEL LINES RUSTED, LEAKED HEAVILY, SMELLED GAS. DEALER REPLACED ALL THE GAS LINES AND PUMP. *AK
NHTSA ODI #819427
Mileage unknown · Feb 25, 1997
Fuel System, Gasoline
AS OF A RESULT OF FUEL PUMP BLOWING, VEHICLE WOULDN'T START. *AK
NHTSA ODI #809321
Mileage unknown · Dec 3, 1996
Fuel System, Gasoline
FUEL PUMP SHORTED OUT, CAUSING WIRING TO BURN. *AK
NHTSA ODI #511727
Mileage unknown · Aug 21, 1996
Fuel System, Gasoline
THERE'S A HOLE IN THE GAS TANK WHICH WAS CAUSED BY THE GAS TANK RUSTING THROUGH. PLEASE EXPLAIN. *AK
NHTSA ODI #801137
Mileage unknown · May 21, 1996
Fuel System, Gasoline
ROUTING OF FUEL CABLE CAUSED STEERING COLUMN TO RUB HOLE IN FUEL LINE. *DH
NHTSA ODI #504998
Mileage unknown · Nov 21, 1995
Fuel System, Gasoline
FUEL SYSTEM MALFUNCTION, FUEL INJECTORS DO NOT PROVIDE CONSTANT FUEL TO ENGINE, CAUSING ENGINE TO STALL. TT
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SPEED CONTROL DEACTIVATION SWITCH CAN DEVELOP A RESISTIVE SHORT IN THE ELECTRICAL CIRCUIT THAT COULD POTENTIALLY RESULT IN AN UNDERHOOD FIRE. A FIRE IS POSSIBLE BOTH WHEN THE VEHICLE IS RUNNING AND WHEN THE VEHICLE ENGINE IS OFF. ALSO, THE SHORT COULD DISABLE THE SPEED CONTROL SYSTEM OR CAUSE THE BRAKE LIGHT FUSE TO OPEN.
Consequence & remedy
Consequence: A FIRE CAN ORIGINATE IN THE LEFT FRONT UNDERHOOD AREA.
Remedy: DEALERS WILL INSTALL A NEW SPEED CONTROL DEACTIVATION SWITCH AND CONNECTOR SHELL. OWNER NOTIFICATION BEGAN MAY 20, 1999.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available
RQ01002 · Engine Compartment Fires
Opened Sep 20, 2001 · Closed Sep 6, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA95011 · Undercarriage Fuel Line Interference
Opened Mar 29, 1995 · Closed Jan 30, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE94077 · Fuel Line Interference
Opened Nov 4, 1994 · Closed Mar 29, 1995
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93086 · Hood FLY-UP While Driving
Opened Oct 1, 1993 · Closed Feb 28, 1994
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1992 Mercury Grand Marquis Problems, Complaints & Recalls | Skip That Year
Illustration