NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
41 reportsClear category filter46,777 miles · Jul 21, 2016
Electrical SystemExterior Lighting
FOR THE SECOND TIME IN APPROXIMATELY 1 YEAR, THE HEADLIGHTS STARTED TURNING OFF AN ON WHEN DRIVING HOME ON THE FREEWAY 4 NIGHTS AGO. THE FIRST TIME THIS HAPPENED A YEAR AGO, THE HEADLIGHT SWITCH , BURNED WIRE AND BURNED CONNECTOR WERE REPLACED. THE CAR IS CURRENTLY PARKED AS I FEEL IT IS UNSAFE TO DRIVE WITH THE OVERHEATING WIR…
Read full complaint
FOR THE SECOND TIME IN APPROXIMATELY 1 YEAR, THE HEADLIGHTS STARTED TURNING OFF AN ON WHEN DRIVING HOME ON THE FREEWAY 4 NIGHTS AGO. THE FIRST TIME THIS HAPPENED A YEAR AGO, THE HEADLIGHT SWITCH , BURNED WIRE AND BURNED CONNECTOR WERE REPLACED. THE CAR IS CURRENTLY PARKED AS I FEEL IT IS UNSAFE TO DRIVE WITH THE OVERHEATING WIRING.
NHTSA ODI #10886295
200,000 miles · Nov 2, 2015
Electrical SystemExterior Lighting
TL* THE CONTACT OWNS A 1992 MERCURY GRAND MARQUIS. WHILE DRIVING AT APPROXIMATELY 50 MPH, THE HEADLIGHTS, TAIL LIGHTS, AND INSTRUMENT PANEL LIGHTING FAILED TO ILLUMINATE. IN ADDITION, THE CONTACT STATED THAT THE DASHBOARD WAS HOT. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WA…
Read full complaint
TL* THE CONTACT OWNS A 1992 MERCURY GRAND MARQUIS. WHILE DRIVING AT APPROXIMATELY 50 MPH, THE HEADLIGHTS, TAIL LIGHTS, AND INSTRUMENT PANEL LIGHTING FAILED TO ILLUMINATE. IN ADDITION, THE CONTACT STATED THAT THE DASHBOARD WAS HOT. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
NHTSA ODI #10787722
114,000 miles · Jun 17, 2005
Electrical SystemFire
NO WARNING BEFOREHAND, CAR WAS DESTROYED BY A FIRE THAT STARTED IN THE LEFT FRONT ENGINE AREA.
NHTSA ODI #10125693
135,297 miles · Jul 27, 2004
Electrical System
MY 1992 GRAND MARQUIS WAS TAKEN IN FOR WHAT WAS A MINOR MISS IN THE ENGINE. THE MACHANIC SAID THE COMPUTER SHOWED A CODE 214. HE REPLACED THE COOLANT TEMPERATURE SENSOR/SWITCH (FOR COMPUTER) PER THE CODE IN THE CAR'S COMPUTER. THE CAR WAS RETURNED TO ME AND I DROVE IT TO WORK, ABOUT FIVE MINUTES AWAY FROM THE REPAIR SHOP. A…
Read full complaint
MY 1992 GRAND MARQUIS WAS TAKEN IN FOR WHAT WAS A MINOR MISS IN THE ENGINE. THE MACHANIC SAID THE COMPUTER SHOWED A CODE 214. HE REPLACED THE COOLANT TEMPERATURE SENSOR/SWITCH (FOR COMPUTER) PER THE CODE IN THE CAR'S COMPUTER. THE CAR WAS RETURNED TO ME AND I DROVE IT TO WORK, ABOUT FIVE MINUTES AWAY FROM THE REPAIR SHOP. ABOUT 4 HOURS LATER I GOT IN THE CAR TO DRIVE HOME AND IT STARTED MISSING REAL BAD, LIKE IT WAS NOT GETTING ENOUGH GAS AND ABOUT TO SHUT OFF. MY CAR HAS BEEN TO A FORD DEALRSHIP WHO WANTED $1,700 IN VEHICALE PREPARATION COST BEFORE DEALING WITH WHAT MAY BE THE PROBLEM. ANOTHER MACHANIC WHO USE TO WORK FOR A FORD DEALERSHIP CHECK THE CAR AND COULD NOT REMOVE THE COD 214. THE MACHANIC REPLACED THE CAM SENSOR, THE CRANK SENSOR, THE COOLANT SENSOR, THE AIR FLOW DUCT AND INSTALLED A NEW SET OF PLUG WIRES. IT IS NOW JULY AND I HAVE NOT BEEN ABLE TO DRIVE MY CAR SINCE MARCH 17TH. WHAT WAS A PERFECTLY GOOD CAR IN MARCH IS NOW A PEACE OF JUNK. OTHER THAN THIS PROBLEM THE CAR IS IN OUTSTANDING CONDITION. IT IS SUSPECT THAT THIS PROBLEM MAY BE ELECTICAL IN NATURE AND I BELIEVE THAT LINCOLN/MERCURY SHOULD AT LEAST ASSIST IN CORRECTING THIS PROBLEM BECAUSE IT APPEARS TO BE BASED ON A LIMITING FACTOR OF THE MANUFACTURING OF THE VEHICLE'S COMPONENTS. *AK
NHTSA ODI #10082724
Mileage unknown · Jul 22, 2002
Electrical System
THE DIGITAL DASH DISPLAY DOES NOT LIGHT UP AND FORD SAYS THEY DO NOT MAKE THE PART TO REPAIR IT, ANYMORE. THEY SAY THEY ARE UNABLE TO REPAIR IT AND THEY CAN GIVE US NOTHING FOR THE CAR ON TRADE IN AS THEY CANNOT RESELL IT. WELL THEY SOLD IT TO US. ANYWAY, WE CAN'T DRIVE A CAR WITHOUT THE DISPLAY...NO SPEEDOMETER, NO FUEL IND…
Read full complaint
THE DIGITAL DASH DISPLAY DOES NOT LIGHT UP AND FORD SAYS THEY DO NOT MAKE THE PART TO REPAIR IT, ANYMORE. THEY SAY THEY ARE UNABLE TO REPAIR IT AND THEY CAN GIVE US NOTHING FOR THE CAR ON TRADE IN AS THEY CANNOT RESELL IT. WELL THEY SOLD IT TO US. ANYWAY, WE CAN'T DRIVE A CAR WITHOUT THE DISPLAY...NO SPEEDOMETER, NO FUEL INDICATOR, NO NOTHING..*AK
NHTSA ODI #764580
Mileage unknown · Apr 26, 2002
Electrical SystemEngine And Engine CoolingFire
WHILE DRIVING, ANOTHER DRIVER SIGNALED CONSUMER INDICATING THERE WAS A FIRE COMING FROM UNDER VEHICLE. CONSUMER IMMEDIATELY PULLED OVER, GOT OUT OF VEHICLE AND SECONDS LATER VEHICLE EXPLODED.*AK *YH
NHTSA ODI #8008683
Mileage unknown · Apr 17, 2002
Electrical SystemFire
I HAVE NOT EXPIERENCED A FAILURE TO MY CAR (EXCEPT THAT THE DRIVE TRAIN HAD TO BE REPLACED BEFORE 50,000 MILES). I AM SENDING THIS INFO. BECAUSE I DISCOVERED THAT THERE HAD BEEN A RECALL(NHTSA CAMPAIGN #99V124000). I WANT TO FIND A DEALER IN OR NEAR MY AREA TO REPLACE AND INSTALL A "NEW SPEED CONTROL DEACTIVATION SWITCH AND CON…
Read full complaint
I HAVE NOT EXPIERENCED A FAILURE TO MY CAR (EXCEPT THAT THE DRIVE TRAIN HAD TO BE REPLACED BEFORE 50,000 MILES). I AM SENDING THIS INFO. BECAUSE I DISCOVERED THAT THERE HAD BEEN A RECALL(NHTSA CAMPAIGN #99V124000). I WANT TO FIND A DEALER IN OR NEAR MY AREA TO REPLACE AND INSTALL A "NEW SPEED CONTROL DEACTIVATION SWITCH AND CONNECTOR SHELL) MY CAR WAS BOUGHT FROM A USED CAR AUTO SALES PLACE.,NOT AN ACTUAL MERCURY DEALER. CAN YOU PLEASE ADVISE ME ON HOW TO PROCEED IN HAVING THIS DEFECT TO MY CAR REPAIRED? YOUR HELP AND GUIDENCE IS APPRECIATED. SINCERELY, MRS. [XXX]. NLM PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #760801
Mileage unknown · Jul 13, 2001
Electrical SystemExterior Lighting
HEADLIGHTS WOULD ONLY WORK INTERMITTENTLY. REPAIR SHOP REPLACED DEFECTIVE HEADLIGHT SWITCH, HAD CAUSED WIRES TO BE HOT.*AK *JB
NHTSA ODI #892716
Mileage unknown · Jun 22, 2001
Air BagsElectrical SystemVehicle Speed Control
HORN AND CRUISE CONTROL WORK INTERMITTENTLY, AIR BAG LIGHT READS CODE 13 + 34. SHORT IN AIR BAG MODULE, CAUSES LIGHT TO BLINK. DEALER STATED WIRE HARNESS NEEDEED TO BE REPLACED. *AK
NHTSA ODI #890997
Mileage unknown · Nov 9, 1999
Electrical SystemExterior LightingFire
WHILE CONSUMER WAS DRIVING AT 45 MPH THE HEADLIGHTS WENT OUT WITHOUT PRIOR WARNING. ALSO, CONSUMER NOTICED SOME SMOKE COMING FROM UNDER THE HOOD. PULLED OVER AND POPPED THE HOOD UP, AND WAS ABLE TO PUT THE FIRE OUT. *AK
NHTSA ODI #849753
Official recalls
3Feb 4, 2008
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
May 19, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SPEED CONTROL DEACTIVATION SWITCH CAN DEVELOP A RESISTIVE SHORT IN THE ELECTRICAL CIRCUIT THAT COULD POTENTIALLY RESULT IN AN UNDERHOOD FIRE. A FIRE IS POSSIBLE BOTH WHEN THE VEHICLE IS RUNNING AND WHEN THE VEHICLE ENGINE IS OFF. ALSO, THE SHORT COULD DISABLE THE SPEED CONTROL SYSTEM OR CAUSE THE BRAKE LIGHT FUSE TO OPEN.
Consequence & remedy
Consequence: A FIRE CAN ORIGINATE IN THE LEFT FRONT UNDERHOOD AREA.
Remedy: DEALERS WILL INSTALL A NEW SPEED CONTROL DEACTIVATION SWITCH AND CONNECTOR SHELL. OWNER NOTIFICATION BEGAN MAY 20, 1999.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available
RQ01002 · Engine Compartment Fires
Opened Sep 20, 2001 · Closed Sep 6, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA95011 · Undercarriage Fuel Line Interference
Opened Mar 29, 1995 · Closed Jan 30, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE94077 · Fuel Line Interference
Opened Nov 4, 1994 · Closed Mar 29, 1995
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE93086 · Hood FLY-UP While Driving
Opened Oct 1, 1993 · Closed Feb 28, 1994
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Illustration