THE CAR IN QUESTION WAS MY FIRST COUGAR. IT WAS BOUGHT BACK BY FORD. I WAS TOLD IT WOULD BE SENT BACK TO THE PLANT TO BE TAKEN APART AND CHECKED OUT. INSTEAD IT WAS SOLD TO NORTHTOWN AND THEY IN TURN SOLD IT TO AN UNSPECTING BUYER. I WAS CALLED ABOUT THE CAR BY AL THE CAR SALESMAN AND HE IN TURN TOLD THE PEOPLE I WAS A PICKY…
Read full complaint
THE CAR IN QUESTION WAS MY FIRST COUGAR. IT WAS BOUGHT BACK BY FORD. I WAS TOLD IT WOULD BE SENT BACK TO THE PLANT TO BE TAKEN APART AND CHECKED OUT. INSTEAD IT WAS SOLD TO NORTHTOWN AND THEY IN TURN SOLD IT TO AN UNSPECTING BUYER. I WAS CALLED ABOUT THE CAR BY AL THE CAR SALESMAN AND HE IN TURN TOLD THE PEOPLE I WAS A PICKY PERSON! THE PERSON THAT BOUGHT THE CAR CALLED ME TONIGHT AND THEY ARE STILL HAVING TROUBLE WITH THE CAR AND I THINK THEY GOT A RAW DEAL! I TOLD THE CUSTOMER I WOULD HELP HER OUT IN ANY WAY I CAN.
NHTSA ODI #729132
Mileage unknown · Jul 14, 2000
Unknown Or Other
THE DRIVERS SIDE DOOR WEATHER STRIP RIPES AT THE TOP REAR OF THE WINDOW, IT HAS BEEN REPLACED 3 TIMES ALREADY. NO SAFETY DEFECT MENTIONED IN SUMMARY. *AK
NHTSA ODI #725420
Mileage unknown · Jun 12, 2000
Air BagsEngine And Engine CoolingStructure
DRIVER'S DOOR WILL NOT CLOSE COMPLETELY. *SLC
NHTSA ODI #784693
Mileage unknown · May 21, 2000
Power TrainUnknown Or Other
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #722972
Mileage unknown · Aug 16, 1999
Engine And Engine CoolingUnknown Or Other
ENGINECHECK LIGHT CAME ON AFTER BEING REPAIRED FOR THE TIMING BELT LEAK. VEHICLE WAS LEAKING DAY AFTER BEING PICKED UP FROM DEALER. THE REPAIRS, DONE BETWEEN JUNE 9-JUL 9, 1999, WERE NOT SATISFACTORY. *AK
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. THE CAMPAIGN BEGAN ON APRIL 16, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Consequence & remedy
Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 2.5L V6 ENGINES. THE BATTERY CABLE WAS MISROUTED AND ITS ATTACHMENT TO THE ALTERNATOR CABLE WAS UNDER-TORQUED. IF MISROUTED, THE CABLE COULD CONTACT THE POWER STEERING LINE AND THE INSULATION COULD WEAR, RESULTING IN AN ELECTRICAL SHORT.
Consequence & remedy
Consequence: THE SHORT COULD POTENTIALLY RESULT IN A FIRE, STALLING, OR A NO-START CONDITION.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLE TO THE ALTERNATOR FOR DAMAGE AND, IF IT IS DAMAGED, WILL REPLACE THE CABLE. ADDITIONALLY, THE ROUTING OF THE CABLE WILL BE CORRECTED, AS NECESSARY, AND A ROUTING CLIP WILL BE ADDED. ALSO THE TORQUE ON THE ALTERNATOR ATTACHMENT OF THE CABLE WILL BE CHECKED AND, AS REQUIRED, WILL BE TIGHTENED TO SPECIFICATION. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BRAKE LAMP SWITCH TERMINALS COULD OVERHEAT.
Consequence & remedy
Consequence: THIS COULD CAUSE EITHER A LOSS OF BRAKE LAMP FUNCTION OR CONTINUOUSLY ILLUMINATED BRAKE LAMPS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A NEW STOP LAMP EXTENSION HARNESS WITH BRONZE TERMINALS AT THE BRAKE LAMP SWITCH CONNECTOR, AND ALSO INSPECT THE BRAKE LAMP SWITCH FOR SIGNS OF OVERHEATING AND REPLACE, AS REQUIRED. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.
Consequence & remedy
Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DOOR LATCH MAY HAVE BEEN MANUFACTURED WITH A LATCH PAWL THAT HAS A COATING WHICH WILL SWELL IN HIGH HUMIDITY CONDITIONS. THE LATCH PAWL MAY THEN STICK IN THE OPEN OR UNLATCHED POSITION.
Consequence & remedy
Consequence: THE DOOR WOULD NOT LATCH WHEN CLOSED. IF THE VEHICLE IS DRIVEN IN THIS CONDITION, IT COULD POTENTIALLY RESULT IN THE DOOR OPENING WHILE THE VEHICLE IS IN MOTION.
Remedy: DEALERS WILL INSTALL A REVISED SIDE DOOR LATCH.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.
Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
1999 Mercury Cougar Problems, Complaints & Recalls | Skip That Year
Illustration