Electrical SystemEngine And Engine CoolingExterior Lighting
MY CAR IS A LEMON. HAVE HAD A NEW ENGINE PUT IN IT 2 TIMES BECAUSE THE RODS SPUN. I HAVE HAD THE BRAKE LIGHTS "FIXED" 3 TIMES, THE ALTERNATOR REPLACED 3 TIMES, NEW CATALYTIC CONVERTERS TWICE. NEW POWER STEERING. TRANSMISSION DONE 3 TIMES. THERES DEFINANTLY MORE I JUST CANT THINK OF ALLLLLLL MY REPAIRS ON THIS 1999 COUGAR. I BOU…
Read full complaint
MY CAR IS A LEMON. HAVE HAD A NEW ENGINE PUT IN IT 2 TIMES BECAUSE THE RODS SPUN. I HAVE HAD THE BRAKE LIGHTS "FIXED" 3 TIMES, THE ALTERNATOR REPLACED 3 TIMES, NEW CATALYTIC CONVERTERS TWICE. NEW POWER STEERING. TRANSMISSION DONE 3 TIMES. THERES DEFINANTLY MORE I JUST CANT THINK OF ALLLLLLL MY REPAIRS ON THIS 1999 COUGAR. I BOUGHT IT USED AND IT HAS NOW 98000 MILES CAUSE I DRIVE OUT OF STATE. *AK
NHTSA ODI #10037305
Mileage unknown · Dec 13, 2002
Air BagsElectrical SystemPower Train
I HAVE HAD NUMEROUS PROBLEMS WITH MY '99 COUGAR SUCH AS, FAILURE OF MY PAT SYSTEM AND COMPUTER SYSTEM. I HAVE HAD PROBLEMS WITH MY BRAKES WHICH THEY CAN'T SEEM TO FIGURE OUT THE PROBLEM. I HAVE HAD MY STARTER REPLACED TWICE. I HAVE HAD DEFECTS IN SEVERAL SENSORS, WHICH IS NOT UNDER WARRANTY THAT I HAD TO PAY A GOOD AMOUNT OF …
Read full complaint
I HAVE HAD NUMEROUS PROBLEMS WITH MY '99 COUGAR SUCH AS, FAILURE OF MY PAT SYSTEM AND COMPUTER SYSTEM. I HAVE HAD PROBLEMS WITH MY BRAKES WHICH THEY CAN'T SEEM TO FIGURE OUT THE PROBLEM. I HAVE HAD MY STARTER REPLACED TWICE. I HAVE HAD DEFECTS IN SEVERAL SENSORS, WHICH IS NOT UNDER WARRANTY THAT I HAD TO PAY A GOOD AMOUNT OF MONEY FOR THEM TO REPAIR. MY FAN HAS EVEN BLOWN OUT. THERE IS A BURNING SMELL WHENEVER I TURN ON MY HEATER THAT NONE OF THE DEALERS CAN'T SEEM TO SMELL. I ALSO HAD TO PURCHASE A NEW RADIATOR. WHEN MY COMPUTER WENT OUT MY CAR WAS STILL UNDER WARRANTY BUT THEY MADE ME PAY FOR THE REPAIRS, PARTS, AND LABOR OUT OF MY POCKET. THIS IS NOT ALL. THE LIST GOES ON AND ON. I HAVE COMPLAINED TO THE DEALERSHIP, FORD MOTOR CO. AND EVEN HAD SOMEONE FROM FORD TO INVESTIGATE ALL OF THE PROBLEMS I'VE HAD WITH MY VEHICLE. THEY HAVE BEEN RUDE TO ME ON SEVERAL OCCASIONS, ESPECIALLY WHEN I HAD QUESTIONS ABOUT THE REPAIRS OF MY VEHICLE. SOMETHING NEEDS TO BE DONE ABOUT THIS. I WOULD NOT RECOMMEND THE PURCHASE OF A MERCURY COUGAR TO ANYONE.
NHTSA ODI #10000023
Mileage unknown · Aug 11, 2000
Service Brakes, Air
I HAVE REPLACED A SET OF BRAKE PADS ON THE FRONT, THE CALIPERS WERE LOOSE WHEN REPLACED & I HAD TO REPLACE THE ROTOR ON THE RIGHT & THE ROTOR ON THE LEFT NOW NEEDS REPLACED. THIS DOES NOT SEEM LIKE NORMAL WEAR/TEAR. THIS CAR HAS BEEN USED MOSTLY FOR HIGHWAY TRAVEL. THANKS!
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. THE CAMPAIGN BEGAN ON APRIL 16, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Consequence & remedy
Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 2.5L V6 ENGINES. THE BATTERY CABLE WAS MISROUTED AND ITS ATTACHMENT TO THE ALTERNATOR CABLE WAS UNDER-TORQUED. IF MISROUTED, THE CABLE COULD CONTACT THE POWER STEERING LINE AND THE INSULATION COULD WEAR, RESULTING IN AN ELECTRICAL SHORT.
Consequence & remedy
Consequence: THE SHORT COULD POTENTIALLY RESULT IN A FIRE, STALLING, OR A NO-START CONDITION.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLE TO THE ALTERNATOR FOR DAMAGE AND, IF IT IS DAMAGED, WILL REPLACE THE CABLE. ADDITIONALLY, THE ROUTING OF THE CABLE WILL BE CORRECTED, AS NECESSARY, AND A ROUTING CLIP WILL BE ADDED. ALSO THE TORQUE ON THE ALTERNATOR ATTACHMENT OF THE CABLE WILL BE CHECKED AND, AS REQUIRED, WILL BE TIGHTENED TO SPECIFICATION. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BRAKE LAMP SWITCH TERMINALS COULD OVERHEAT.
Consequence & remedy
Consequence: THIS COULD CAUSE EITHER A LOSS OF BRAKE LAMP FUNCTION OR CONTINUOUSLY ILLUMINATED BRAKE LAMPS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A NEW STOP LAMP EXTENSION HARNESS WITH BRONZE TERMINALS AT THE BRAKE LAMP SWITCH CONNECTOR, AND ALSO INSPECT THE BRAKE LAMP SWITCH FOR SIGNS OF OVERHEATING AND REPLACE, AS REQUIRED. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.
Consequence & remedy
Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DOOR LATCH MAY HAVE BEEN MANUFACTURED WITH A LATCH PAWL THAT HAS A COATING WHICH WILL SWELL IN HIGH HUMIDITY CONDITIONS. THE LATCH PAWL MAY THEN STICK IN THE OPEN OR UNLATCHED POSITION.
Consequence & remedy
Consequence: THE DOOR WOULD NOT LATCH WHEN CLOSED. IF THE VEHICLE IS DRIVEN IN THIS CONDITION, IT COULD POTENTIALLY RESULT IN THE DOOR OPENING WHILE THE VEHICLE IS IN MOTION.
Remedy: DEALERS WILL INSTALL A REVISED SIDE DOOR LATCH.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.
Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
1999 Mercury Cougar Problems, Complaints & Recalls | Skip That Year
Illustration