GAS GAUGE HAS ERRATIC OPERATION (SOMETIMES STICKS ON E OR F AND NEVER ACCURATE). CAR HAS HESITATION. DEALER INDICATED IT WAS THE FUEL DELIVERY MODULE. FORD/MERCURY ISSUED RECALL IN MAY 2004 ON FUEL DELIVERY MODULE FOR THIS REASON. MY CAR WAS NOT IN THE RECALL AND FORD WILL NOT OFFER ANY ASSISTANCE TO HAVE IT REPAIRED (APPRO…
Read full complaint
GAS GAUGE HAS ERRATIC OPERATION (SOMETIMES STICKS ON E OR F AND NEVER ACCURATE). CAR HAS HESITATION. DEALER INDICATED IT WAS THE FUEL DELIVERY MODULE. FORD/MERCURY ISSUED RECALL IN MAY 2004 ON FUEL DELIVERY MODULE FOR THIS REASON. MY CAR WAS NOT IN THE RECALL AND FORD WILL NOT OFFER ANY ASSISTANCE TO HAVE IT REPAIRED (APPROX $480 REPAIR). *NM
NHTSA ODI #10080433
40,000 miles · Jun 4, 2003
Fuel System, Other
THERE IS A RECALL ON THE GAS TANK AS BEING LOOSE. THIS IS CAUSING THE NOZZLE NOT TO GO IN SMOOTHLY, AND THE PUMP KEEPS SHUTTING OFF. *AK
NHTSA ODI #10022335
Mileage unknown · Jan 15, 2001
Air BagsEngine And Engine CoolingEquipment
OIL FILTER COMBUSTED DUE TO PRESSURE. ENGINE HAS BEEN DESTROYED!!! CAR IS A YEAR AND A HALF OLD WITH 24,500 MILES. I HAVE A NUMBER OF PROBLEMS THAT HAVE OCCURRED WITH THIS CAR. I HAVE IGNORED DUE TO THEY COME AND GO. SUCH AS RATTLING NOISES FROM THE TRUNK, CIGARRETTE LIGHTER IS DEAD, GAS GAUGE DOESN'T READ PROPERLY ALL THE …
Read full complaint
OIL FILTER COMBUSTED DUE TO PRESSURE. ENGINE HAS BEEN DESTROYED!!! CAR IS A YEAR AND A HALF OLD WITH 24,500 MILES. I HAVE A NUMBER OF PROBLEMS THAT HAVE OCCURRED WITH THIS CAR. I HAVE IGNORED DUE TO THEY COME AND GO. SUCH AS RATTLING NOISES FROM THE TRUNK, CIGARRETTE LIGHTER IS DEAD, GAS GAUGE DOESN'T READ PROPERLY ALL THE TIME, LIGHTS ILLUMINATE FOR REAR LIGHT OUT, AIRBAGS, COOLANT, NEXT TIME START UP CAR THEY ARE OUT??? I HAD A SATURN FOR 5 YEARS NEVER HAD A PROBLEM. I HAVE THIS COUGAR FOR A YEAR AND A HALF AND LOOK AT ALL THESE PROBLEMS. I AM SORRY A CAR THAT IS A YEAR AND A HALF SHOULD NOT BE GETTING A NEW ENGINE!!!! I AM EXTREMELY DISAPPOINTED WITH MERCURY. I WILL NEVER GET ANOTHER ONE AGAIN.*AK
NHTSA ODI #739379
Mileage unknown · Jan 21, 2000
Engine And Engine CoolingExterior LightingFuel System, Other
BRAKES CONTINUALLY MAKE GRINDING NOISE SINCE OWNERSHIP, SEVERAL REPAIRS AND INSPECTIONS TO VEHICLE WITH NO REMEDY, CONSUMER ALMOST IN VEHICLE ACCIDENT DUE TO LOSS OF BRAKE ABILITY, HOWEVER NO REMEDY AT THIS TIME FOR BRAKE FAILURE AND NOISE. *MJS
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. THE CAMPAIGN BEGAN ON APRIL 16, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Consequence & remedy
Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 2.5L V6 ENGINES. THE BATTERY CABLE WAS MISROUTED AND ITS ATTACHMENT TO THE ALTERNATOR CABLE WAS UNDER-TORQUED. IF MISROUTED, THE CABLE COULD CONTACT THE POWER STEERING LINE AND THE INSULATION COULD WEAR, RESULTING IN AN ELECTRICAL SHORT.
Consequence & remedy
Consequence: THE SHORT COULD POTENTIALLY RESULT IN A FIRE, STALLING, OR A NO-START CONDITION.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLE TO THE ALTERNATOR FOR DAMAGE AND, IF IT IS DAMAGED, WILL REPLACE THE CABLE. ADDITIONALLY, THE ROUTING OF THE CABLE WILL BE CORRECTED, AS NECESSARY, AND A ROUTING CLIP WILL BE ADDED. ALSO THE TORQUE ON THE ALTERNATOR ATTACHMENT OF THE CABLE WILL BE CHECKED AND, AS REQUIRED, WILL BE TIGHTENED TO SPECIFICATION. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BRAKE LAMP SWITCH TERMINALS COULD OVERHEAT.
Consequence & remedy
Consequence: THIS COULD CAUSE EITHER A LOSS OF BRAKE LAMP FUNCTION OR CONTINUOUSLY ILLUMINATED BRAKE LAMPS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A NEW STOP LAMP EXTENSION HARNESS WITH BRONZE TERMINALS AT THE BRAKE LAMP SWITCH CONNECTOR, AND ALSO INSPECT THE BRAKE LAMP SWITCH FOR SIGNS OF OVERHEATING AND REPLACE, AS REQUIRED. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.
Consequence & remedy
Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DOOR LATCH MAY HAVE BEEN MANUFACTURED WITH A LATCH PAWL THAT HAS A COATING WHICH WILL SWELL IN HIGH HUMIDITY CONDITIONS. THE LATCH PAWL MAY THEN STICK IN THE OPEN OR UNLATCHED POSITION.
Consequence & remedy
Consequence: THE DOOR WOULD NOT LATCH WHEN CLOSED. IF THE VEHICLE IS DRIVEN IN THIS CONDITION, IT COULD POTENTIALLY RESULT IN THE DOOR OPENING WHILE THE VEHICLE IS IN MOTION.
Remedy: DEALERS WILL INSTALL A REVISED SIDE DOOR LATCH.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.
Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
1999 Mercury Cougar Problems, Complaints & Recalls | Skip That Year
Illustration