2024 MERCEDES-BENZ Sprinter 2500

2024 Mercedes-Benz Sprinter 2500 experienced unusually rapid brake, tire, and battery wear at low mileage. Front brakes required replacement at approximately 29,000 miles. Rear brakes were already worn low by approximately 37,000 miles. Rear tires required replacement by approximately 37,000 miles. Vehicle battery also failed and required replacement before approximately 37,000 miles. Vehicle had earlier emissions/sensor related repairs as well. This creates safety concerns because premature brake wear can reduce stopping ability and increase stopping distance. Premature tire wear can reduce traction, especially in rain, and increase risk of tire failure or blowout. Unexpected battery failure can disable the vehicle without warning in traffic or roadside conditions. Vehicle is used in normal commercial delivery service and is generally not heavily loaded. I have owned and operated multiple prior Sprinter vans over many years, and previous model years achieved substantially longer brake, tire, and battery life under similar or heavier use. A newer comparable fleet vehicle with similar mileage has not required these repairs. The issue appears abnormal compared with prior ownership experience and may indicate brake system drag, an alignment issue, defective components, battery charging issue, or another unresolved defect. Vehicle has been serviced by dealer and components were replaced, but premature wear remains the concern. In addition, rear brake wear occurring this early suggests possible imbalance or excessive brake application that should be investigated. Rapid tire wear combined with brake wear may indicate alignment or braking system issues affecting vehicle control and safety. I am submitting this complaint so the condition can be reviewed for potential defect trends affecting other similar vehicles. Defective parts may be available from prior repairs depending on service center retention.

Vehicle: 2024 Mercedes-Benz Sprinter VIN: [XXX] Mileage: 148,000 The vehicle is experiencing a serious safety-related defect where the starter motor remains engaged even after the engine is turned off. This results in the starter continuing to run and stay powered, which can cause severe mechanical damage, overheating, and presents a potential fire risk. The starter has already been replaced, but the issue persists, indicating the problem is within the vehicle’s electrical control system (such as wiring harness, relay, or control module). Additionally, I was informed that this same vehicle had a prior wire harness-related issue in 2024 under the previous owner, suggesting a recurring or unresolved electrical defect. This condition can lead to unexpected vehicle behavior and poses a safety hazard due to the risk of electrical failure or fire. The vehicle is currently at a Mercedes-Benz dealership for diagnosis, and a case has been opened with Mercedes-Benz USA under case #XXX. I am submitting this complaint to report a potential safety defect and request investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)