2023 MERCEDES-BENZ Sprinter 2500

I was facing west in the left turning lane to turn south into my community. The vehicle lost power when I was cutting across oncoming, east bound traffic. The vehicle lost power two more time after that once I was in my community. No warning light or any other indicators. The vehicle just went limp. I almost didn't make it clear of oncoming traffic.

Noticed the driveshaft to my front differential is very close to falling out. Also rusting & flinging grease everywhere as it pulls out of its seating. This is an issue other owners have seen, with severe consequences when the driveshaft becomes complete unseated including sudden severe vibrations, loss of drive power, and potentially damaging steering components, brake lines/components, and electrical harnesses.

The front driveshaft for the vehicle referenced has a safety design flaw that makes it too short. There is a risk of the front driveshaft separating from the front differential splines completely and wrecking havoc to the vehicles essential driving components like steering rack, wiring harness, and potentially causing an accident. Mercedes Benz has increased wait times at their shops and are currently 5-6 weeks out to even look at the vehicles issue. Currently my vehicle is experiencing major vibrations due to the front driveshaft barely hanging on to the front differential splines as the manufactures design is not robust enough for simply driving on the road and allows the front driveshaft to simply slip off what is designed to retain the shaft to the front differential. Before every drive I have to push the drive shaft further onto the splines and am hoping it doesn't fully come off while driving. This issue began around 6k miles and now have 12k miles on the vehicle. Just now finding the main cause of the issue when discussing with other owners. MB needs to do something about this ASAP. As of right now MB has no solution.

At 3,000 miles, my 2023 Van (purchased new) developed significant reduction in power and acceleration. The transmission also shifts incorrectly (too late, resulting in higher then normal RPM's) and then abruptly downshifts upon stopping. When going uphill, the van obtains a max speed of about 35-40MPH, forcing me to travel on the local Interstates on the shoulder with my hazards flashing so other vehicles know to pass me. Van was left at Mercedes Dealership for 1 month. Van was not repaired, no plan or remedy was communicated. Van has only been inspected by the dealership where it was purchased. A check engine light came on about 1 week after van lost power.

The contact owns a 2023 Mercedes-Benz Sprinter 2500. The contact stated that while driving approximately 55-65 MPH, the Crosswind Assist inadvertently activated, causing the front and rear driver's side brakes to activate. The vehicle started swerving. The Crosswind Assist warning light was illuminated. The failure occurred on four separate occasions. The vehicle was taken to the dealer; however, no error codes were retrieved. The dealer determined that the vehicle had recalibrated while driving. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 2,100.

The crosswind assist on my vehicle causes me to momentarily loose control of my Sprinter. When passing a tractor-trailer or when I experience any crosswind, the result is a forceful jerking of the vehicle so severe that I almost crashed into the tractor-trailer. I have researched this and found no way to turn this off or any way to make this less reactive. I have also found online others who are experiencing this same problem. Mercedes does not respond to my inquiries, saying that this is standard and no way to regulate the severity of the response. Please help me to get this resolved BEFORE I become a statistic. Thank you!

So I bought a brand new 2023 Mercedes Sprinter Build by Airstream Interstate 19. The front windshield visibility is very bad at night driving. The whole front of windshield has zig zag lines all over the glass for defrosting but those lines make on coming traffic lights very blurry. Driving during day time is normal. Driving during night time all lights look blurry, its kind of like driving with -2 or -3 prescription when looking out the windshield. I called airstream and they said windshield is part of mercedes item. I called mercedes knoxville and they said they have not heard anything like this before.