NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
10 reportsClear category filterMileage unknown · Dec 7, 2025
Service Brakes
I had 5 recalls completed at the MB Sprinter dealership in Pleasanton CA on 11/06/2025. Had hardly driven it 100 miles or 5 times since then when I noticed it was not always going into park. One recall had to do with not going in park when you push park button while foot on brake. I was not having that problem until the MB Sprin…
Read full complaint
I had 5 recalls completed at the MB Sprinter dealership in Pleasanton CA on 11/06/2025. Had hardly driven it 100 miles or 5 times since then when I noticed it was not always going into park. One recall had to do with not going in park when you push park button while foot on brake. I was not having that problem until the MB Sprinter dealership did the recall work. Now every 5th time or so it does not go in park when I push park button while foot on brake. Dealership insists I must pay to have this fixed even though their recall work caused it. This is a severe safety hazard that could result in death!
NHTSA ODI #11703605
Mileage unknown · Jul 13, 2023
Forward Collision AvoidanceService Brakes
Driving at speed (70-75 mph) in the HOV lane of the I-5 Freeway south of Los Angeles, a warning signal would occasionally light up and sound when the van passed under HOV signage indicating HOV exits. Then, with a completely clear lane ahead – no vehicles, no obstacles – the van's braking system activated just before the van rea…
Read full complaint
Driving at speed (70-75 mph) in the HOV lane of the I-5 Freeway south of Los Angeles, a warning signal would occasionally light up and sound when the van passed under HOV signage indicating HOV exits. Then, with a completely clear lane ahead – no vehicles, no obstacles – the van's braking system activated just before the van reached one of these overhead signs. The brakes fully locked, the van skidded briefly before the brakes released. The driver of the car following behind slammed on his/her brakes to avoid rear-ending the van. A very dangerous situation and major accident was only avoided because the traffic was relatively light in that particular section of the freeway at that time of day.
NHTSA ODI #11532181
Mileage unknown · Dec 19, 2022
Service BrakesCrash
On 10-27-22 the van was parked in my home driveway where it had been parked overnight. The engine was running for approximately 10 minutes while loading things into the vehicle. The vehicle was in park and the hand parking brake was not engaged. Prior to leaving I noticed the dash icon showing the rear door was not fully shut an…
Read full complaint
On 10-27-22 the van was parked in my home driveway where it had been parked overnight. The engine was running for approximately 10 minutes while loading things into the vehicle. The vehicle was in park and the hand parking brake was not engaged. Prior to leaving I noticed the dash icon showing the rear door was not fully shut and went back to close it. Once I closed the rear door it then appeared that the transmission shifted itself into neutral and the van rolled back into the garage while I was standing outside of it. I have home surveillance camera footage showing the incident as it happened. I have tried to convey this information to Mercedes Benz but interactions with them have been less than helpful.
NHTSA ODI #11498070
Mileage unknown · Nov 10, 2022
Forward Collision AvoidanceService Brakes
Adaptive Cruise Control as well as Forward Collison warning fail to work properly when in use. Both unexpectedly malfunction for no apparent reason and vehicle will not cruise control will not function at all. The vehicle was taken back to the dealership where it was supposedly addressed and fixed, however, the issue has not…
Read full complaint
Adaptive Cruise Control as well as Forward Collison warning fail to work properly when in use. Both unexpectedly malfunction for no apparent reason and vehicle will not cruise control will not function at all. The vehicle was taken back to the dealership where it was supposedly addressed and fixed, however, the issue has not been fixed. The vehicle presents the same issues as prior to the inspection and "repair" from the dealership. While driving with Adaptive Cruise Control/Forward Collison Warning, the system will malfunction. A light on the dash will indicate that it has been disabled, simultaneously, the vehicle will lose cruise control, foward collision warning immediately. Vehicle will not regain any form of cruise control or forward collison warning for an unspecified amount of time. Could be minutes, hours, or even days. Dash warnings also include cleaning sensors and cameras. Doing so does not correct the problem.
NHTSA ODI #11493007
Mileage unknown · Oct 13, 2022
Parking BrakePower TrainService BrakesCrash
The vehicle was put into parked and somehow disengage itself from parked and rolled into a house.
NHTSA ODI #11489157
Mileage unknown · Feb 25, 2022
Service Brakes
I have called the Mercedes dealer in Collierville Tennessee a dozen times and left messages to get the vehicle in for the recall. i cant get a return call from the Sprinter service manager there. very very frustrating and made me loose faith in the brand for customer service and a blatant disregard for my safety.
NHTSA ODI #11454048
Mileage unknown · Sep 22, 2021
Electrical SystemPower TrainService Brakes
My husband was stopped at a stop light on Sept. 9th when the van randomly (and without provocation) shifted itself from drive into park. We called the dealership to explain the problem and ask that they look into it. We made an appointment and dropped off the vehicle yesterday. Service Department called and verbally stated that …
Read full complaint
My husband was stopped at a stop light on Sept. 9th when the van randomly (and without provocation) shifted itself from drive into park. We called the dealership to explain the problem and ask that they look into it. We made an appointment and dropped off the vehicle yesterday. Service Department called and verbally stated that they had taken a van on a test drive and that the van had acted "normally" and that they anticipated returning the van to us with the instruction that if we experienced the problem again to contact them. I was not happy with this response as I felt that the problem was a severe safety issue and not enough had been done to investigate it. I quickly googled "mercedes going into park on its own" and found an article detailing reports of 2010 mercedes sedans going into park on their own while the driver was slowing to stop (exactly as we experienced). An accompanying official mercedes benz service department memo in the article confirmed the problem, mentioned the "auto p" feature and blamed the problem on a faulty ignition switch. I called the service department back, referenced the memo and asked if a faulty ignition switch could be to blame. The service department stated that it would be impossible because the ignition switch has changed. They stated that my husband must have taken off his seat belt and engaged the auto p feature. My husband did not unbuckle his seat belt that day. The dealership returned the van noting that they were able to duplicate the issue and engage the auto p feature by unbuckling the driver's seat belt at low speed. My husband and I tried to duplicate and engage the auto p feature ourselves by unbuckling the driver's seat belt after it was returned but were unable to do so. Interestingly, mercedes benz has recently issued a recall for driver's manuals because they acknowledge that the directions for how to engage the feature as explained in the manual are incorrect. Unbuckling will not engage auto p.
NHTSA ODI #11433961
18 miles · Jul 1, 2021
Service Brakes
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated while driving at various speeds, the brakes applied independently. The contact stated that the brake warning light was illuminated. The local dealer was made aware of the failure. The vehicle was not diagnosed and continued to experience failure. The manufac…
Read full complaint
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated while driving at various speeds, the brakes applied independently. The contact stated that the brake warning light was illuminated. The local dealer was made aware of the failure. The vehicle was not diagnosed and continued to experience failure. The manufacturer had been informed of the failure. The failure mileage was approximately 18.
NHTSA ODI #11423116
3,400 miles · Feb 21, 2021
Forward Collision AvoidanceService BrakesVehicle Speed Control
WHILE DRIVING ON A HIGHWAY AND PASSING UNDER A ROAD SIGN DESCRIBING THE NEXT EXIT, THE SPRINTER VAN AUTOMATIC CRASH AVOIDANCE KICKED IN, CAUSING THE VAN TO AUTOMATICALLY JAM ON THE BRAKES AND LOSE APPROXIMATELY 20 MPH WHILE CAUSING THE WHEEL TO PULL DECIDEDLY TO THE LEFT. THERE WERE NO VEHICLES IN FRONT OR BEHIND, AND THANKFULLY…
Read full complaint
WHILE DRIVING ON A HIGHWAY AND PASSING UNDER A ROAD SIGN DESCRIBING THE NEXT EXIT, THE SPRINTER VAN AUTOMATIC CRASH AVOIDANCE KICKED IN, CAUSING THE VAN TO AUTOMATICALLY JAM ON THE BRAKES AND LOSE APPROXIMATELY 20 MPH WHILE CAUSING THE WHEEL TO PULL DECIDEDLY TO THE LEFT. THERE WERE NO VEHICLES IN FRONT OR BEHIND, AND THANKFULLY ENOUGH NONE CLOSE ENOUGH TO CAUSE AN ACCIDENT. THIS IS A FAIRLY COMMON OCCURRENCE, AND EVEN IF THE BRAKES DO NOT ENGAGE, THE CRASH AVOIDANCE ALERT SOUND WILL OFTEN TIMES CHIME AND STARTLE THE DRIVER FOR OTHER OVERHEAD OBSTACLES LIKE TRAFFIC SIGNS AND TUNNEL ENTRIES. THIS FEATURE, ALONG WITH LANE DEPARTURE ASSIST (WHICH ALSO IS BUGGY) AUTOMATICALLY TURNS ON AFTER EVERY RESTART, EVEN AFTER BEING TURNED OFF MANUALLY. IT IS UNSAFE.
NHTSA ODI #11397255
450 miles · Aug 30, 2020
Electronic Stability Control (esc)Service BrakesSteering
THE ACTIVE LANE KEEPING ASSIST IS HIGHLY DANGEROUS AND NEEDS TO BE PERMANENTLY DISABLED OR REMOVED FROM THE VEHICLE. I NARROWLY AVOIDED GETTING INTO A ACCIDENT. I WAS DRIVING ON THE HIGHWAY IN THE LEFT LANE AND HAD TO SERVE AROUND SOME DUMP ITEMS THAT FELL OF THE BACK OF THE TRUCK AHEAD. THE ACTIVE LANE KEEPING ASSIST FORCED THE…
Read full complaint
THE ACTIVE LANE KEEPING ASSIST IS HIGHLY DANGEROUS AND NEEDS TO BE PERMANENTLY DISABLED OR REMOVED FROM THE VEHICLE. I NARROWLY AVOIDED GETTING INTO A ACCIDENT. I WAS DRIVING ON THE HIGHWAY IN THE LEFT LANE AND HAD TO SERVE AROUND SOME DUMP ITEMS THAT FELL OF THE BACK OF THE TRUCK AHEAD. THE ACTIVE LANE KEEPING ASSIST FORCED THE VAN BACK INTO THE LANE AND TOWARDS THE JUNK IN THE ROAD AND ENDED UP RUNNING OVER IT. IT COULD OF BEEN A LOT WORSE IF THE OBJECT WAS BIGGER, A CAR, PERSON OR ANIMAL. I SHOULD BE ABLE TO TURN IT OFF ONCE! NOT EVERY TIME I HAVE TO RESTART THE VEHICLE. THIS WORRIES ME ESPECIALLY. WITH ALL THE SPRINTER VANS I SEE OUT THERE ON THE ROAD EVERYDAY
NHTSA ODI #11352167
Official recalls
22Dec 13, 2024
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter vehicles. The instrument cluster illumination may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Consequence & remedy
Consequence: A display that is too bright can make it difficult for the driver to see critical safety information, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed January 31, 2025. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BELKOM.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The connection between the propeller shaft bearing and crossmember may loosen, reducing vehicle control.
Consequence & remedy
Consequence: Reduced vehicle control increases the risk of a crash. Additionally, the propeller shaft may damage the fuel tank during a crash, causing a leak and increasing the risk of a fire.
Remedy: Dealers will inspect and replace the crossmember as necessary, free of charge. Owner notification letters were mailed April 19, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3QUERTR.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The longitudinal frame members may be missing reinforcement fasteners, reducing vehicle stability and decreasing the structural integrity of the third-row seats.
Consequence & remedy
Consequence: Reduced stability increases the risk of a crash. Additionally, the third-row seat mountings can fail, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and repair the frame members as necessary, free of charge. Owner notification letters were mailed March 4, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ROHRAH.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2023 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The partition wall may be missing bolts, allowing the wall to detach during a crash.
Consequence & remedy
Consequence: A detached partition wall can increase the risk of injury.
Remedy: Dealers will inspect and secure the partition wall as necessary, free of charge. Owner notification letters are expected to be mailed February 16, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TREWAN.
Mar 24, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The instrument cluster may fail to display any information when the vehicle is started.
Consequence & remedy
Consequence: A blank instrument panel will not show critical information, such as vehicle speed, fuel gauge, warning messages, and warning lights, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software on the affected vehicles, free of charge. Owner notification letters were mailed May 5, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMBAUS.
Oct 21, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with a manual parking brake and 7-speed automatic transmission. The guide bushing on the parking pawl may fatigue, which can cause the parking pawl not to engage and result in vehicle rollaway.
Consequence & remedy
Consequence: Vehicle rollaway increases the risk of a crash.
Remedy: Dealers will update the software of the electronic stability, transmission control, direct select module, and electronic ignition switch control units, free of charge. Owner notification letters were mailed February 10, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's numbers for this recall are 22V2790611, 22V2790612, and 22V2790613.
May 20, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence & remedy
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Additional source detail variants (2)
Communication: Auto Crash Notification
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Apr 27, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rearview camera may not display the rearview image due to a software error. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperable rearview camera display reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed July 20, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMRUE.
Dec 15, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. A software error in the park lock system may allow the vehicle to move after the gear selector has been placed in the Park 'P' position without the parking brake applied.
Consequence & remedy
Consequence: Unintentional vehicle movement can increase the risk of a crash.
Remedy: Dealers will update the electronic stability program control unit software, free of charge. Owner notification letters were mailed February 11, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3PA27 ERI/ERO.
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence & remedy
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Additional source detail variants (2)
Air Bags:passenger Side Frontal:cushion
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Electrical System
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Additional source detail variants (2)
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Back Over Prevention:display Function
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
May 17, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020 Mercedes-Benz Sprinter vehicles. The screws for the front door hinges may not have been tightened properly.
Consequence & remedy
Consequence: Loose door hinge screws could change the gap between the door and vehicle body, increasing the risk of injury in the event of a crash.
Remedy: Dealers will check the screws and tighten them as necessary, free of charge. Owner notification letters were mailed June 18, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TURSCHA.
Apr 6, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach and cause hydraulic fluid to leak.
Consequence & remedy
Consequence: A hydraulic fluid leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will install a screw-type clamp, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NV3LETULPX.
Apr 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The multifunctional display in the instrument cluster may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."
Consequence & remedy
Consequence: A display that is too bright can hinder the driver's vision, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DISPKI.
Mar 10, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The retaining washer and bolt that connect the brake pedal to the bearing block, may come loose and detach. This could cause the brake lights to stay illuminated, even when the brake pedal is not pressed.
Consequence & remedy
Consequence: Malfunctioning brake lights can fail to alert other motorists of the driver's intention, increasing the risk of a crash.
Remedy: DVUSA will notify owners and dealers will secure a bearing bracket to brake pedal by retrofitting an additional retaining ring (with PNR A 907 994 01 00) at the bearing bracket of brake pedal, free of charge. DVUSA issued owners an interim notification on May 3, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREBOL.
Mar 10, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter vehicles equipped with an optional electric sliding door. The auxiliary lock on the sliding door may be the incorrect type for an electric sliding door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: In the event of a crash, the sliding door could dislocate more than intended, and increase the risk of injury to vehicle occupants.
Remedy: DVUSA will notify owners, and dealers will convert the sliding door from electric to manual function, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHIEBT.
Feb 17, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with the multimedia system "Connect 5" and a rearview camera. The rearview image may not display within 2 seconds from the start of the backing event. In addition, the rearview image may be obscured or covered by the visual display of the Emergency Call (eCall) pop-up window if the eCall system is activated while the reverse gear is engaged. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A delayed or obstructed rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will perform a software update on the vehicles, free of charge. The recall began March 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3RUECON.
Feb 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2020 Mercedes-Benz Metris and 2019-2020 Mercedes-Benz Sprinter vehicles. The software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the event of a crash.
Consequence & remedy
Consequence: Failure of the eCall system may result in emergency responders being dispatched to the wrong location, increasing the risk of injury following a crash.
Remedy: DVUSA will notify owners, and dealers will update the software communication module for the automatic emergency call system, free of charge. The recall began on May 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSXHERMPOS.
Dec 21, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with electric parking brakes. The rear brake calipers may leak brake fluid into the housing of the electric parking brake connected to the rear axle service brake system, allowing air to enter the hydraulic brake system.
Consequence & remedy
Consequence: Air in the brake system can result in extended brake pedal travel, increasing the risk of a crash.
Remedy: DVUSA will replace the rear brake calipers, free of charge. Owners notification letters were mailed on January 4, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREPB.
Oct 28, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.
Consequence & remedy
Consequence: The sudden loss of power steering assist and hydraulic steering fluid leaking onto the roadway may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.
Oct 14, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020 Mercedes-Benz Sprinter vehicles. The outer area of the brake hoses on the front and rear axles may have been damaged during production.
Consequence & remedy
Consequence: Over time, the hose could begin to leak brake fluid, affecting the braking performance of the vehicle, including the potential loss of directional stability when braking, thereby increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will check the condition of the brake hoses on the front and rear axles and replace them as needed, free of charge. The recall began November 24, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3MONTLAU.
Sep 29, 2020
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2020 Mercedes Benz and Freightliner Sprinters. The fuel line clamps may loosen and result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak can increase the risk of a fire.
Remedy: DVUSA will notify owners, and dealers will check the fuel hose clamp connections and tighten or replace the components as needed, free of charge. DVUSA issued owners an interim notification on November 9, 2020. The recall began January 19, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHELLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration