NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
67 reportsMileage unknown · Dec 6, 2021
Electrical System
2019 MERCEDES BENZ SPRINTER 2500. CONSUMER WRITES IN REGARDS TO DEFECTIVE ELECTRONIC MODULES. THE CONSUMER STATED THE EIS AND EZS MODULES ARE EXPOSED TO WET AND DAMP CONDITIONS. OVERTIME THEY CORRODE AND NEED TO BE REPLACED. THE CONSUMER STATED THE MODULES WERE IN A POOR LOCATION. THE CONSUMER STATED THE VEHICLE EXPERIENCED A …
Read full complaint
2019 MERCEDES BENZ SPRINTER 2500. CONSUMER WRITES IN REGARDS TO DEFECTIVE ELECTRONIC MODULES. THE CONSUMER STATED THE EIS AND EZS MODULES ARE EXPOSED TO WET AND DAMP CONDITIONS. OVERTIME THEY CORRODE AND NEED TO BE REPLACED. THE CONSUMER STATED THE MODULES WERE IN A POOR LOCATION. THE CONSUMER STATED THE VEHICLE EXPERIENCED A FAILURE WHILE THE VEHICLE WAS NOT IN MOTION.
NHTSA ODI #11442814
Mileage unknown · Oct 2, 2021
Steering
I brought my 2019 4x4 Sprinter Van in for a campaign recall for the power steering hoses and clamps. The dealership said they made the repairs as necessary and sent me on my way. A few weeks later the power steering hoses blew while driving and almost caused an accident. I was stuck on the side of the road and lost all steering…
Read full complaint
I brought my 2019 4x4 Sprinter Van in for a campaign recall for the power steering hoses and clamps. The dealership said they made the repairs as necessary and sent me on my way. A few weeks later the power steering hoses blew while driving and almost caused an accident. I was stuck on the side of the road and lost all steering capabilities. Come to find out the dealership lied and never made the repairs as necessary as far as replacing the faulty clamps. After getting the vehicle towed back to the dealership they replace the clamps with cheap hardware store clamps and I have had problems with my power steering ever Since then. I’ve taken my vehicle back multiple times for them to make the repairs and they replace the power steering pump once with a remanufactured one unfortunately I continue to have power steering issues. This is all due to the faulty hose clamps on the power steering unit for the 2019 4x4 Sprinter Van. If they would’ve replace the hoses with longer hoses and the proper fittings this would’ve all been prevented and could potentially prevent a serious accident while driving.
NHTSA ODI #11435232
Mileage unknown · Sep 15, 2021
Electrical SystemUnknown Or OtherVisibility/wiper
The main display screen in the unit has failed, which means the following is no longer functional: Reverse camera (rearview camera image) ; Traction control settings ; Lane Departure system settings ; Door lock settings ; Vehicle lighting settings
NHTSA ODI #11433096
Mileage unknown · Sep 14, 2021
Unknown Or Other
The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any h…
Read full complaint
The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _ The EIS module retails at $1800+ from Mercedes _ Had Mercedes installed the EIS module with the connector facing DOWNWARD - this moisture related issue would not exist. _ There is no drip loop provisions in the wiring. _ Mercedes is aware of the issue as they have created a plastic bag with part number A 638 546 00 35 and they are charging $20 for it. As of right now, Mercedes refuses to fix this issue preventatively. They will only repair it AFTER the EIS module has shorted out. They are refusing to treat this as a warranty claim even though it is clearly a manufacturer defect. Please help? Thank you
NHTSA ODI #11432851
Mileage unknown · Aug 30, 2021
Steering
I took my vehicle in for a recall on power steering hose 12/20. They said it was fixed. Last week I was driving down a 9000 foot mountain with my family when the power steering hose disconnected and I lost power steering while coming down an 8% grade. We almost went over the edge but luckily I was able to engage my brake fast en…
Read full complaint
I took my vehicle in for a recall on power steering hose 12/20. They said it was fixed. Last week I was driving down a 9000 foot mountain with my family when the power steering hose disconnected and I lost power steering while coming down an 8% grade. We almost went over the edge but luckily I was able to engage my brake fast enough to stop us just before the guard rail. We nearly died. This recall was supposedly fixed and it wasn't. I contacted the MB dealer where I bought the van and was given a non-reassuring answer that they'll take a look at it but no real concrete reasoning as to why this happened even after having it fixed.
NHTSA ODI #11431125
Mileage unknown · Aug 20, 2021
Power Train
The contact owns a 2019 Mercedes Benz Sprinter 2500. The contact state that while in PARK, the vehicle moved and rolled away. Additionally, while in park the vehicle moved when the seat belt was released. There were no warning lights illuminated. The vehicle was taken to the local dealer where they were unable to duplicate the f…
Read full complaint
The contact owns a 2019 Mercedes Benz Sprinter 2500. The contact state that while in PARK, the vehicle moved and rolled away. Additionally, while in park the vehicle moved when the seat belt was released. There were no warning lights illuminated. The vehicle was taken to the local dealer where they were unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was unknown. The VIN was not available.
NHTSA ODI #11429905
965 miles · Aug 11, 2021
Power TrainCrashInjury
The contact's client was utilizing a 2019 Mercedes- Benz Sprinter 2500 for work. The contact stated while the vehicle was in park, the driver exited the vehicle however, it rolled backward, flipped over, and crushed the driver's legs. There were no warning lights illuminated. The driver sustained road and chemical burns and medi…
Read full complaint
The contact's client was utilizing a 2019 Mercedes- Benz Sprinter 2500 for work. The contact stated while the vehicle was in park, the driver exited the vehicle however, it rolled backward, flipped over, and crushed the driver's legs. There were no warning lights illuminated. The driver sustained road and chemical burns and medical attention was provided. A police report was filed. There was no report of a fire or airbag deployment. The vehicle was towed to an independent lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and inspected the vehicle where the black box was retrieved. The contact mentioned referenced NHTSA Action Number PE21019 (Power train). The failure mileage was 965.
NHTSA ODI #11428683
Mileage unknown · Aug 9, 2021
Service BrakesCrash
DRIVER STATED HE PUT THE VAN IN PARK ON BUT DIDN'T ENGAGE THE EMERGENCY BRAKE. ON HIS WAY TO MAKE HIS DELIVERY, THE VAN STARTED ROLLING BACKWARDS WITH THE DRIVER SIDE DOOR OPEN AND ROLLED BACKED INTO PILE OF SNOW.
NHTSA ODI #11428353
24,000 miles · Jul 29, 2021
Back Over PreventionElectrical System
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated while driving at various speeds, the MBUX multimedia system became inoperable resulting in the rear-view camera not functioning as designed. Upon investigation, the contact associated the failure with NHTSA campaign number: 21V411000 (Electrical System, Back…
Read full complaint
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated while driving at various speeds, the MBUX multimedia system became inoperable resulting in the rear-view camera not functioning as designed. Upon investigation, the contact associated the failure with NHTSA campaign number: 21V411000 (Electrical System, Back Over Prevention). The vehicle was diagnosed and repaired; however, the failure persisted. The manufacturer was not informed of the failure. The failure mileage was approximately 24,000.
NHTSA ODI #11427071
24,000 miles · Jul 29, 2021
Wheels
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated that while the vehicle was stopping, the contact heard a humming sound coming from the driver’s side of the vehicle. There was no warning light illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was not informed of the failure. The fai…
Read full complaint
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated that while the vehicle was stopping, the contact heard a humming sound coming from the driver’s side of the vehicle. There was no warning light illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 24,000
NHTSA ODI #11427070
Official recalls
42Dec 13, 2024
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter vehicles. The instrument cluster illumination may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Consequence & remedy
Consequence: A display that is too bright can make it difficult for the driver to see critical safety information, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed January 31, 2025. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BELKOM.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The longitudinal frame members may be missing reinforcement fasteners, reducing vehicle stability and decreasing the structural integrity of the third-row seats.
Consequence & remedy
Consequence: Reduced stability increases the risk of a crash. Additionally, the third-row seat mountings can fail, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and repair the frame members as necessary, free of charge. Owner notification letters were mailed March 4, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ROHRAH.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2023 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The partition wall may be missing bolts, allowing the wall to detach during a crash.
Consequence & remedy
Consequence: A detached partition wall can increase the risk of injury.
Remedy: Dealers will inspect and secure the partition wall as necessary, free of charge. Owner notification letters are expected to be mailed February 16, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TREWAN.
Mar 24, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The instrument cluster may fail to display any information when the vehicle is started.
Consequence & remedy
Consequence: A blank instrument panel will not show critical information, such as vehicle speed, fuel gauge, warning messages, and warning lights, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software on the affected vehicles, free of charge. Owner notification letters were mailed May 5, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMBAUS.
Oct 21, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with a manual parking brake and 7-speed automatic transmission. The guide bushing on the parking pawl may fatigue, which can cause the parking pawl not to engage and result in vehicle rollaway.
Consequence & remedy
Consequence: Vehicle rollaway increases the risk of a crash.
Remedy: Dealers will update the software of the electronic stability, transmission control, direct select module, and electronic ignition switch control units, free of charge. Owner notification letters were mailed February 10, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's numbers for this recall are 22V2790611, 22V2790612, and 22V2790613.
May 20, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence & remedy
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Additional source detail variants (2)
Communication: Auto Crash Notification
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Apr 27, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rearview camera may not display the rearview image due to a software error. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperable rearview camera display reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed July 20, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMRUE.
Dec 15, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. A software error in the park lock system may allow the vehicle to move after the gear selector has been placed in the Park 'P' position without the parking brake applied.
Consequence & remedy
Consequence: Unintentional vehicle movement can increase the risk of a crash.
Remedy: Dealers will update the electronic stability program control unit software, free of charge. Owner notification letters were mailed February 11, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3PA27 ERI/ERO.
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence & remedy
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Additional source detail variants (2)
Air Bags:passenger Side Frontal:cushion
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Electrical System
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Additional source detail variants (2)
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Back Over Prevention:display Function
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Apr 6, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach and cause hydraulic fluid to leak.
Consequence & remedy
Consequence: A hydraulic fluid leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will install a screw-type clamp, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NV3LETULPX.
Apr 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The multifunctional display in the instrument cluster may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."
Consequence & remedy
Consequence: A display that is too bright can hinder the driver's vision, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DISPKI.
Mar 10, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The retaining washer and bolt that connect the brake pedal to the bearing block, may come loose and detach. This could cause the brake lights to stay illuminated, even when the brake pedal is not pressed.
Consequence & remedy
Consequence: Malfunctioning brake lights can fail to alert other motorists of the driver's intention, increasing the risk of a crash.
Remedy: DVUSA will notify owners and dealers will secure a bearing bracket to brake pedal by retrofitting an additional retaining ring (with PNR A 907 994 01 00) at the bearing bracket of brake pedal, free of charge. DVUSA issued owners an interim notification on May 3, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREBOL.
Mar 10, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter vehicles equipped with an optional electric sliding door. The auxiliary lock on the sliding door may be the incorrect type for an electric sliding door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: In the event of a crash, the sliding door could dislocate more than intended, and increase the risk of injury to vehicle occupants.
Remedy: DVUSA will notify owners, and dealers will convert the sliding door from electric to manual function, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHIEBT.
Feb 17, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with the multimedia system "Connect 5" and a rearview camera. The rearview image may not display within 2 seconds from the start of the backing event. In addition, the rearview image may be obscured or covered by the visual display of the Emergency Call (eCall) pop-up window if the eCall system is activated while the reverse gear is engaged. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A delayed or obstructed rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will perform a software update on the vehicles, free of charge. The recall began March 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3RUECON.
Feb 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2020 Mercedes-Benz Metris and 2019-2020 Mercedes-Benz Sprinter vehicles. The software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the event of a crash.
Consequence & remedy
Consequence: Failure of the eCall system may result in emergency responders being dispatched to the wrong location, increasing the risk of injury following a crash.
Remedy: DVUSA will notify owners, and dealers will update the software communication module for the automatic emergency call system, free of charge. The recall began on May 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSXHERMPOS.
Dec 21, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with electric parking brakes. The rear brake calipers may leak brake fluid into the housing of the electric parking brake connected to the rear axle service brake system, allowing air to enter the hydraulic brake system.
Consequence & remedy
Consequence: Air in the brake system can result in extended brake pedal travel, increasing the risk of a crash.
Remedy: DVUSA will replace the rear brake calipers, free of charge. Owners notification letters were mailed on January 4, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREPB.
Dec 11, 2020
Daimler Vans USA, LLC (DVUSA) is recalling one 2019 Mercedes-Benz Sprinter 2500 vehicle. The engine hood may not have been installed properly.
Consequence & remedy
Consequence: In the event of a crash, the hood could make contact with the windshield, entering the passenger compartment and increasing the risk of an injury.
Remedy: DVUSA will notify the owner, and a dealer will replace the engine hood, free of charge. The recall is expected to begin January 18, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHAUBE.
Dec 8, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter vehicles. These vehicles may have been delivered with a version of the printed and digital operator's manual that may be inaccurate and/or incomplete.
Consequence & remedy
Consequence: If the operator relies on the provided owner's manual, the information about vehicle functions and other safety relevant information may be inaccurate and/or incomplete, which could lead to improper operation of the vehicle and potentially increase the risk of a crash or injury.
Remedy: DVUSA will notify owners, and dealers will replace the printed version of the operator's manual with the latest version and update the software of the digital version, free of charge. DVUSA distributed owners an interim notification on January 22, 2021. The recall began March 17, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3PRIDIBA.
Oct 28, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.
Consequence & remedy
Consequence: The sudden loss of power steering assist and hydraulic steering fluid leaking onto the roadway may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.
Sep 29, 2020
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2020 Mercedes Benz and Freightliner Sprinters. The fuel line clamps may loosen and result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak can increase the risk of a fire.
Remedy: DVUSA will notify owners, and dealers will check the fuel hose clamp connections and tighten or replace the components as needed, free of charge. DVUSA issued owners an interim notification on November 9, 2020. The recall began January 19, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHELLE.
Mar 26, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The Operator's Manual may not contain the correct information about how the automatic parking function ("Auto-P") operates.
Consequence & remedy
Consequence: If the driver relies on the Auto-P function as described in the Operator's Manual, vehicle rollaway or movement may occur, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will provide the correct description of the Auto-P function for the Operator's Manual, free of charge. The recall began May 18, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BAUTOP.
Mar 25, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.
Consequence & remedy
Consequence: Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect and replace the brake hoses, as necessary. Additionally, the fender liners will be modified. All services will be performed free of charge. The recall began May 8, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BRADVER.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.
Consequence: Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect and replace the brake hoses, as necessary. Additionally, the fender liners will be modified. All services will be performed free of charge. The recall began May 8, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BRADVER.
Service Brakes, Air:supply:hoses, Lines/piping, And Fittings
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.
Consequence: Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect and replace the brake hoses, as necessary. Additionally, the fender liners will be modified. All services will be performed free of charge. The recall began May 8, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BRADVER.
Mar 18, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The spare tire label may indicate the maximum speed at 55 kilometers per hour (kph) rather than as 34 miles per hour (mph).
Consequence & remedy
Consequence: With only the metric speed listed on the spare tire label, the driver could misinterpret the kph as mph and operate the vehicle with the spare tire installed at higher speeds than the tire can withstand, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will replace it with the label with the correct maximum speed information indicated in miles per hour, free of charge. The recall began May 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BEGRESS.
Mar 18, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The spare tire label indicating the maximum speed may have not been affixed to the spare tire.
Consequence & remedy
Consequence: Without the label, an operator may be unaware of the maximum speed limit of the spare tire and operate the vehicle at a excessive speed, increasing the risk of tire failure and a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will attach the speed limitation label on the spare wheel, free of charge. The recall began May 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BEGREPP.
Mar 18, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with winter tires. The tires may not have been correctly installed, possibly resulting in reduced traction in wet or snowy conditions.
Consequence & remedy
Consequence: A reduction in traction may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect the running direction of the tires, correcting them as necessary. If the thread wear is uneven, the tires will be replaced. All services will be performed free of charge. The recall began May 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LAUFRI.
Feb 25, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The screws that secure the intermediate bearing of the steering spindle may not have been properly tightened, potentially causing the screws to loosen and detach.
Consequence & remedy
Consequence: If the screws detach, the driver may have difficulty steering the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace and properly tighten the steering spindle intermediate bearing screws, free of charge. The recall began April 13, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHLENK.
Feb 25, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The steering column casing cover may have not been installed, allowing the steering column area to be exposed.
Consequence & remedy
Consequence: If small vehicle components, such as nuts and screws, enter the steering column area, the steering operation can be affected, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will replace the steering column with one that has a cover, free of charge. The recall is expected to begin April 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3VERKLE.
Feb 12, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The connecting screws on the exhaust gas recirculation (EGR) pipe may not have been correctly tightened.
Consequence & remedy
Consequence: If the connecting screws are not properly tightened, hot exhaust gases may leak from the EGR pipe, increasing the risk of a fire.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will renew the screw connection and the flange seals on the exhaust gas recirculation pipe, free of charge. DVUSA issued owners an interim notification on April 6, 2020. The recall began May 4, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3AGROHR.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The connecting screws on the exhaust gas recirculation (EGR) pipe may not have been correctly tightened.
Consequence: If the connecting screws are not properly tightened, hot exhaust gases may leak from the EGR pipe, increasing the risk of a fire.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will renew the screw connection and the flange seals on the exhaust gas recirculation pipe, free of charge. DVUSA issued owners an interim notification on April 6, 2020. The recall began May 4, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3AGROHR.
Engine And Engine Cooling:exhaust System
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The connecting screws on the exhaust gas recirculation (EGR) pipe may not have been correctly tightened.
Consequence: If the connecting screws are not properly tightened, hot exhaust gases may leak from the EGR pipe, increasing the risk of a fire.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will renew the screw connection and the flange seals on the exhaust gas recirculation pipe, free of charge. DVUSA issued owners an interim notification on April 6, 2020. The recall began May 4, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3AGROHR.
Feb 12, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The flange connection between the exhaust gas turbocharger and the exit to the diesel particulate filter may not be attached properly, potentially causing an exhaust gas leak.
Consequence & remedy
Consequence: An exhaust gas leak in the engine compartment increases the risk of a fire.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will replace the flange seals and properly tighten the connection, free of charge. The recall began April 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FLABIND.
Dec 19, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The lashing rails on the side walls may not have been properly installed, possibly resulting in the lashing rails detaching.
Consequence & remedy
Consequence: If the lashing rails disconnect, the cargo could become unsecured, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will correctly affix the lashing rails to the side walls, free of charge. DVUSA issued owners an interim notification on February 7, 2020. The recall began April 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ZUSCHI.
Nov 7, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter vehicles equipped with diesel fuel systems. The bayonet lock between the fuel pump and the fuel tank may not have been closed and locked during manufacturing. As a result, a leak between the fuel pump and the fuel tank could occur. In addition, a gas station fuel pump may not automatically stop once the tank fill level is reached, potentially causing the fuel to overflow.
Consequence & remedy
Consequence: A diesel fuel leak can create slippery road conditions, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will inspect the bayonet lock on the fuel pump, locking it as necessary, free of charge. The recall began January 3, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KRAFMOD.
Nov 6, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner vehicles. A seam on the height adjuster for the front seats may have been insufficiently welded.
Consequence & remedy
Consequence: In the event of a crash, the weld seam may break and cause the seat cushion to shift forward, increasing the risk of injury.
Remedy: DVUSA will notify owners, and dealers will replace the tilt adjuster for the front seats, free of charge. DVUSA issued owners an interim notification on December 19, 2019. The recall began March 9, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SITZVER.
Oct 8, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter vehicles. In the affected vehicles, the abutting wedge, a component attached to the door jamb to make opening the door easier after a severe frontal impact, may have been installed incorrectly.
Consequence & remedy
Consequence: If a vehicle that has an incorrectly installed abutting wedge is involved in a severe frontal accident, a greater force may be necessary to open the doors, increasing the risk of injury.
Remedy: DVUSA will notify owners, and dealers will inspect the installation of the abutting wedge on the driver and front passenger side, correcting it, as necessary, free of charge. DVUSA issued owners an interim notification on November 22, 2019. The recall began February 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KEIL.
Oct 2, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Sprinter and Metris vehicles. The vehicles left the reassembly plant without the final quality inspection of safety-relevant parts or bolt connections, resulting in possible unknown safety risks.
Consequence & remedy
Consequence: Failure to identify loose safety related parts can increase the risk of crash and injury.
Remedy: DVUSA will notify owners, and vehicles will be returned to the reassembly plant for comprehensive inspection and, if necessary, corrective action, free of charge. The recall began November 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSX566ZP25.
Oct 2, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter vehicles. The airbag systems may not have been activated after vehicle production. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An inactive airbag system can increase the risk of injury in the event of a crash.
Remedy: DVUSA will notify owners, and dealers will inspect the vehicles to determine if the airbag systems have been activated, correcting them as necessary, free of charge. DVUSA issued owners an interim notification on November 22, 2019. The recall began February 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3AIRIGEL.
Sep 18, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter vehicles. The screw connection on the upper hood catch may have been improperly tightened. As a result, factors such as the vehicle's speed, wind resistance and road conditions may cause the hood to open while the vehicle is being driven.
Consequence & remedy
Consequence: A hood that opens while driving can reduce the driver's visibility, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will inspect the screw connection, tightening it as necessary, free of charge. The recall began November 1, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3HAUBOSS.
Aug 12, 2019
Daimler Vans USA, LLC. (MBUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter 1500, 2500, 3500, and 4500 vehicles. If the manual turn-switch that activates the vehicle lights is turned quickly from one lighting position to another, the brightness of the taillights can be significantly reduced or could switch off completely.
Consequence & remedy
Consequence: Reduced taillight visibility increases the risk of a crash.
Remedy: MBUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will update the body control unit software, free of charge. The recall began September 30, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is VS3HELI.
Additional source detail variants (2)
Exterior Lighting:tail Lights:switch
Daimler Vans USA, LLC. (MBUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter 1500, 2500, 3500, and 4500 vehicles. If the manual turn-switch that activates the vehicle lights is turned quickly from one lighting position to another, the brightness of the taillights can be significantly reduced or could switch off completely.
Consequence: Reduced taillight visibility increases the risk of a crash.
Remedy: MBUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will update the body control unit software, free of charge. The recall began September 30, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is VS3HELI.
Exterior Lighting:tail Lights
Daimler Vans USA, LLC. (MBUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter 1500, 2500, 3500, and 4500 vehicles. If the manual turn-switch that activates the vehicle lights is turned quickly from one lighting position to another, the brightness of the taillights can be significantly reduced or could switch off completely.
Consequence: Reduced taillight visibility increases the risk of a crash.
Remedy: MBUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will update the body control unit software, free of charge. The recall began September 30, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is VS3HELI.
Jul 2, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter 1500, 2500, 3500 and 4500 vehicles. The rear side windows may be single-pane safety glass instead of laminated safety glass.
Consequence & remedy
Consequence: In the event of a side impact crash or vehicle rollover, the fitted side windows may not adequately protect the rear occupants from being ejected, increasing their risk of injury.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner dealers will replace the single-pane safety glass with laminated safety glass., free of charge. DVUSA issued owners an interim notification on August 16, 2019. The recall began January 21, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3VERGLAS.
Apr 18, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter (Platform 907) vehicles equipped with high-beam assist. A software error in the control unit may prevent the driver from being able to switch off the high beams when intended.
Consequence & remedy
Consequence: Being unable to turn off the high beams may result in oncoming traffic being blinded by the vehicle's lights, increasing the risk of crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will update the control unit software, free of charge. The recall began June 14, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FERNLI.
Apr 9, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles equipped with LED high performance headlights. The sensor for the headlamp range adjustment may not have been mounted or calibrated, possibly causing unexpected changes in the headlamp lighting angle.
Consequence & remedy
Consequence: Unexpected changes in the headlamp lighting angle may affect the drivers visibility, increasing the risk of crash.
Remedy: DVUSA will notify owners, and dealers will inspect and retrofit the sensor and correctly calibrate the rotation angle sensor, free of charge. The recall began June 11, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LEDSENS.
Mar 20, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz Sprinter and Metris vehicles. The affected vehicles left the reassembly plant without the final quality inspection of safety-relevant parts or bolt connections, resulting in possible unknown safety risks.
Consequence & remedy
Consequence: Failure to identify loose safety related parts can increase the risk of crash and injury.
Remedy: DVUSA will notify owners, and dealers will complete the final quality inspection, free of charge. The recall began May 17, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSX566ZP25.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration