IllustrationWhile taking off from a traffic light the rear end came apart on the inside of the differential. Has someone been in a dangerous area or remote areas like where I have to work it could have been a serious issue
2019 MERCEDES-BENZ Sprinter 2500
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sprinter 2500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
240–25K
825–50K
250–75K
275–100K
0100–150K
0150K+
36 reports with mileage · 31 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports4 fire reports4 injury reports
Power Train complaints
14 reportsMy EIS module rendered my vehicle inoperable and left me stranded in the winter and left me stranded 54 miles away from the closest repair shop. Only because this is a know issue (see below) AND I had cell phone service enough to research this problem AND I had an air compressor to blow the wet/corroded connector out AND I was …
Read full complaint
My EIS module rendered my vehicle inoperable and left me stranded in the winter and left me stranded 54 miles away from the closest repair shop. Only because this is a know issue (see below) AND I had cell phone service enough to research this problem AND I had an air compressor to blow the wet/corroded connector out AND I was lucky enough it worked was I not left in a potentially life threatening situation. The weather was below freezing and this situation could have ended up requiring rescue, or worse. The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _ The EIS module retails at $1800+ from Mercedes _ Had Mercedes installed the EIS module with the connector facing DOWNWARD - this moisture related issue would not exist. _ There is no drip loop provisions in the wiring. _ Mercedes is aware of the issue as they have created a plastic bag with part number A 638 546 00 35 and they are charging $20 for it. As of right now, Mercedes refuses to fix this issue preventatively. They will only repair it AFTER the EIS module has shorted out. They are refusing to treat this as a warranty claim even though it is clearly a manufacturer defect.
When switching gears from park into drive or reverse. There is a large knock coming from the Differential area. The knock was getting louder, and the vehicle did not drive as smooth kept getting worse with time. I took it to differential specialist. He diagnosed the problem as loose axle shafts and replace left and right side co…
Read full complaint
When switching gears from park into drive or reverse. There is a large knock coming from the Differential area. The knock was getting louder, and the vehicle did not drive as smooth kept getting worse with time. I took it to differential specialist. He diagnosed the problem as loose axle shafts and replace left and right side costing me close to $3000.
Park feature on automatic transmission. Unit is available for inspection upon request. Unit was idling on the street for approximately 10 minutes, vehicle was in park. Vehicle began rolling down the incline while in park. Crew was in vehicle applied the brakes to stop the vehicle from rolling. Vehicle was sent to dealer. Deal…
Read full complaint
Park feature on automatic transmission. Unit is available for inspection upon request. Unit was idling on the street for approximately 10 minutes, vehicle was in park. Vehicle began rolling down the incline while in park. Crew was in vehicle applied the brakes to stop the vehicle from rolling. Vehicle was sent to dealer. Dealer advised that a vehicle parked with the transmission in park position and the parking brake not engaged, The vehicle may roll away. They attached pages from the owners manual stating if you park the vehicle with the transmission in park position and the parking brake is not engaged the vehicle may roll away. Engaging park position is not a fully adequate replacement for the parking brake. No warning lights were on inthe vehicle.
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated while an employee was moving the vehicle out of the garage into the parking lot, the employee shifted the vehicle into PARK with the engine running. The contact exited the vehicle and while walking to the rear of the vehicle, the vehicle inadvertently shifte…
Read full complaint
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated while an employee was moving the vehicle out of the garage into the parking lot, the employee shifted the vehicle into PARK with the engine running. The contact exited the vehicle and while walking to the rear of the vehicle, the vehicle inadvertently shifted into REVERSE and started rolling backward almost pinning the employee up against the front wall of the garage. The contact stated that the vehicle was reversing at approximately 2 MPH. The vehicle rolled backward into the front wall of the garage. There was damage to the driver’s side door and front fender. The vehicle was taken to be diagnosed but was not repaired. The contact referenced NHTSA Campaign Number: 21V972000 (Electrical System). The manufacturer had been informed of the failure and informed the contact that the issue was not a defect but an operator’s error. The failure mileage was approximately 50,925.
The contact owns a 2019 Mercedes Benz Sprinter 2500. The contact state that while in PARK, the vehicle moved and rolled away. Additionally, while in park the vehicle moved when the seat belt was released. There were no warning lights illuminated. The vehicle was taken to the local dealer where they were unable to duplicate the f…
Read full complaint
The contact owns a 2019 Mercedes Benz Sprinter 2500. The contact state that while in PARK, the vehicle moved and rolled away. Additionally, while in park the vehicle moved when the seat belt was released. There were no warning lights illuminated. The vehicle was taken to the local dealer where they were unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was unknown. The VIN was not available.
The contact's client was utilizing a 2019 Mercedes- Benz Sprinter 2500 for work. The contact stated while the vehicle was in park, the driver exited the vehicle however, it rolled backward, flipped over, and crushed the driver's legs. There were no warning lights illuminated. The driver sustained road and chemical burns and medi…
Read full complaint
The contact's client was utilizing a 2019 Mercedes- Benz Sprinter 2500 for work. The contact stated while the vehicle was in park, the driver exited the vehicle however, it rolled backward, flipped over, and crushed the driver's legs. There were no warning lights illuminated. The driver sustained road and chemical burns and medical attention was provided. A police report was filed. There was no report of a fire or airbag deployment. The vehicle was towed to an independent lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and inspected the vehicle where the black box was retrieved. The contact mentioned referenced NHTSA Action Number PE21019 (Power train). The failure mileage was 965.
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated while the vehicle was parked, the vehicle started rolling backward without warning. The contact stated that the TPMS warning light was illuminated. The vehicle was diagnosed but was not repaired. The manufacturer was not informed of the failure. The failure …
Read full complaint
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated while the vehicle was parked, the vehicle started rolling backward without warning. The contact stated that the TPMS warning light was illuminated. The vehicle was diagnosed but was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 24,000.
WE ARE EXPERIENCING AN ISSUE WITH OUR 2019 MERCEDES SPRINTERS FREELY ROLLING IN PARK AFTER 10 MINUTES OF IDLE TIME. WE HAVE 20 SPRINTERS AND OUT OF THE 20 WE WERE ABLE TO DUPLICATE THIS ISSUE ON 4 SO FAR. ONE UNIT SPENT ABOUT TWO MONTHS AT THE DEALER AND THEY REPLACED THE TRANSMISSION ON IT. THAT SEEMED TO HAVE FIX THE ISSUE. WE…
Read full complaint
WE ARE EXPERIENCING AN ISSUE WITH OUR 2019 MERCEDES SPRINTERS FREELY ROLLING IN PARK AFTER 10 MINUTES OF IDLE TIME. WE HAVE 20 SPRINTERS AND OUT OF THE 20 WE WERE ABLE TO DUPLICATE THIS ISSUE ON 4 SO FAR. ONE UNIT SPENT ABOUT TWO MONTHS AT THE DEALER AND THEY REPLACED THE TRANSMISSION ON IT. THAT SEEMED TO HAVE FIX THE ISSUE. WE HAVE A SECOND UNIT AT THE DEALER THAT HAS BEEN THERE FOR ABOUT A MONTH NOW. THEY HAVE NOT DONE ANY WORK TO IT AS OF THIS WRITING. THEY HAVE ADVISED US THAT MERCEDES IS INVESTIGATING AND WORKING ON A SOLUTION. THIS UNIT HAS NOT BEEN TO THE DEALER DUE TO THE EXCESSIVE DOWN TIME THAT WE ARE EXPERIENCING DUE TO THIS ISSUE. WE HAVE PROVIDED THE DEALER WITH ALL OF THE VINS THAT ARE IN QUESTION AND VIDEO EVIDENCE SHOWING THE PROBLEM. WE FEEL THAT THIS COULD BE POTENTIALLY AN EXTREMELY DANGEROUS SITUATION WITH TRUCKS THAT KEEP ROLLING AWAY. IN OUR OPINION MERCEDES HASN'T PUT ENOUGH EMPHASIS ON HELPING THE DEALER DEAL WITH THIS ISSUE. WE ALSO FEEL THAT THE DURATION THAT THESE TRUCKS ARE OUT OF SERVICE IS UNACCEPTABLE TO THE CUSTOMER THAT USES THE VEHICLE AS A TOOL TO OPERATE THEIR BUSINESS. HERE ARE A COUPLE MORE VIDEOS SHOWING THE ISSUE ACROSS THE 4 UNITS. HTTPS://YOUTU.BE/LY7WQLXBHFE HTTPS://YOUTU.BE/D-SRVHCCFM0 HTTPS://YOUTU.BE/K9BOWLIAM94
WE ARE EXPERIENCING AN ISSUE WITH OUR 2019 MERCEDES SPRINTERS FREELY ROLLING IN PARK AFTER 10 MINUTES OF IDLE TIME. WE HAVE 20 SPRINTERS AND OUT OF THE 20 WE WERE ABLE TO DUPLICATE THIS ISSUE ON 4 SO FAR. ONE UNIT SPENT ABOUT TWO MONTHS AT THE DEALER AND THEY REPLACED THE TRANSMISSION ON IT. THAT SEEMED TO HAVE FIX THE ISSUE. WE…
Read full complaint
WE ARE EXPERIENCING AN ISSUE WITH OUR 2019 MERCEDES SPRINTERS FREELY ROLLING IN PARK AFTER 10 MINUTES OF IDLE TIME. WE HAVE 20 SPRINTERS AND OUT OF THE 20 WE WERE ABLE TO DUPLICATE THIS ISSUE ON 4 SO FAR. ONE UNIT SPENT ABOUT TWO MONTHS AT THE DEALER AND THEY REPLACED THE TRANSMISSION ON IT. THAT SEEMED TO HAVE FIX THE ISSUE. WE HAVE A SECOND UNIT AT THE DEALER THAT HAS BEEN THERE FOR ABOUT A MONTH NOW. THEY HAVE NOT DONE ANY WORK TO IT AS OF THIS WRITING. THEY HAVE ADVISED US THAT MERCEDES IS INVESTIGATING AND WORKING ON A SOLUTION. THIS UNIT HAS NOT BEEN TO THE DEALER DUE TO THE EXCESSIVE DOWN TIME THAT WE ARE EXPERIENCING DUE TO THIS ISSUE. WE HAVE PROVIDED THE DEALER WITH ALL OF THE VINS THAT ARE IN QUESTION AND VIDEO EVIDENCE SHOWING THE PROBLEM. WE FEEL THAT THIS COULD BE POTENTIALLY AN EXTREMELY DANGEROUS SITUATION WITH TRUCKS THAT KEEP ROLLING AWAY. IN OUR OPINION MERCEDES HASN'T PUT ENOUGH EMPHASIS ON HELPING THE DEALER DEAL WITH THIS ISSUE. WE ALSO FEEL THAT THE DURATION THAT THESE TRUCKS ARE OUT OF SERVICE IS UNACCEPTABLE TO THE CUSTOMER THAT USES THE VEHICLE AS A TOOL TO OPERATE THEIR BUSINESS. HERE ARE A COUPLE MORE VIDEOS SHOWING THE ISSUE ACROSS THE 4 UNITS. 1) HTTPS://WWW.YOUTUBE.COM/WATCH?V=NLPPZSZ7G20 2) HTTPS://YOUTU.BE/HWPCJ4BEJE8 3) HTTPS://YOUTU.BE/LY7WQLXBHFE
Official recalls
4224V930000 · Electrical System: Instrument Cluster/panel
Dec 13, 2024
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter vehicles. The instrument cluster illumination may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Consequence & remedy
Consequence: A display that is too bright can make it difficult for the driver to see critical safety information, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed January 31, 2025. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BELKOM.
23V875000 · Structure:critical Fasteners
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The longitudinal frame members may be missing reinforcement fasteners, reducing vehicle stability and decreasing the structural integrity of the third-row seats.
Consequence & remedy
Consequence: Reduced stability increases the risk of a crash. Additionally, the third-row seat mountings can fail, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and repair the frame members as necessary, free of charge. Owner notification letters were mailed March 4, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ROHRAH.
23V876000 · Structure:critical Fasteners
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2023 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The partition wall may be missing bolts, allowing the wall to detach during a crash.
Consequence & remedy
Consequence: A detached partition wall can increase the risk of injury.
Remedy: Dealers will inspect and secure the partition wall as necessary, free of charge. Owner notification letters are expected to be mailed February 16, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TREWAN.
23V204000 · Electrical System: Instrument Cluster/panel
Mar 24, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The instrument cluster may fail to display any information when the vehicle is started.
Consequence & remedy
Consequence: A blank instrument panel will not show critical information, such as vehicle speed, fuel gauge, warning messages, and warning lights, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software on the affected vehicles, free of charge. Owner notification letters were mailed May 5, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMBAUS.
22V796000 · Power Train:automatic Transmission:internal:park Pawl
Oct 21, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with a manual parking brake and 7-speed automatic transmission. The guide bushing on the parking pawl may fatigue, which can cause the parking pawl not to engage and result in vehicle rollaway.
Consequence & remedy
Consequence: Vehicle rollaway increases the risk of a crash.
Remedy: Dealers will update the software of the electronic stability, transmission control, direct select module, and electronic ignition switch control units, free of charge. Owner notification letters were mailed February 10, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's numbers for this recall are 22V2790611, 22V2790612, and 22V2790613.
22V360000 · Communication: Auto Crash Notification; Electrical System:software
May 20, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence & remedy
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Additional source detail variants (2)
Communication: Auto Crash Notification
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
22V281000 · Back Over Prevention:display Function
Apr 27, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rearview camera may not display the rearview image due to a software error. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperable rearview camera display reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed July 20, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMRUE.
21V972000 · Electrical System:software
Dec 15, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. A software error in the park lock system may allow the vehicle to move after the gear selector has been placed in the Park 'P' position without the parking brake applied.
Consequence & remedy
Consequence: Unintentional vehicle movement can increase the risk of a crash.
Remedy: Dealers will update the electronic stability program control unit software, free of charge. Owner notification letters were mailed February 11, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3PA27 ERI/ERO.
21V410000 · Air Bags:passenger Side Frontal:cushion; Electrical System
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence & remedy
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Additional source detail variants (2)
Air Bags:passenger Side Frontal:cushion
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Electrical System
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
21V411000 · Back Over Prevention:display Function; Electrical System:software
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Additional source detail variants (2)
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Back Over Prevention:display Function
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
21V241000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Apr 6, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach and cause hydraulic fluid to leak.
Consequence & remedy
Consequence: A hydraulic fluid leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will install a screw-type clamp, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NV3LETULPX.
21V235000 · Electrical System: Instrument Cluster/panel
Apr 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The multifunctional display in the instrument cluster may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."
Consequence & remedy
Consequence: A display that is too bright can hinder the driver's vision, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DISPKI.
21V152000 · Service Brakes, Hydraulic:pedals And Linkages
Mar 10, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The retaining washer and bolt that connect the brake pedal to the bearing block, may come loose and detach. This could cause the brake lights to stay illuminated, even when the brake pedal is not pressed.
Consequence & remedy
Consequence: Malfunctioning brake lights can fail to alert other motorists of the driver's intention, increasing the risk of a crash.
Remedy: DVUSA will notify owners and dealers will secure a bearing bracket to brake pedal by retrofitting an additional retaining ring (with PNR A 907 994 01 00) at the bearing bracket of brake pedal, free of charge. DVUSA issued owners an interim notification on May 3, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREBOL.
21V153000 · Latches/locks/linkages:doors:lock
Mar 10, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter vehicles equipped with an optional electric sliding door. The auxiliary lock on the sliding door may be the incorrect type for an electric sliding door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: In the event of a crash, the sliding door could dislocate more than intended, and increase the risk of injury to vehicle occupants.
Remedy: DVUSA will notify owners, and dealers will convert the sliding door from electric to manual function, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHIEBT.
21V077000 · Back Over Prevention: Sensing System: Camera
Feb 17, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with the multimedia system "Connect 5" and a rearview camera. The rearview image may not display within 2 seconds from the start of the backing event. In addition, the rearview image may be obscured or covered by the visual display of the Emergency Call (eCall) pop-up window if the eCall system is activated while the reverse gear is engaged. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A delayed or obstructed rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will perform a software update on the vehicles, free of charge. The recall began March 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3RUECON.
21V055000 · Electrical System:software
Feb 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2020 Mercedes-Benz Metris and 2019-2020 Mercedes-Benz Sprinter vehicles. The software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the event of a crash.
Consequence & remedy
Consequence: Failure of the eCall system may result in emergency responders being dispatched to the wrong location, increasing the risk of injury following a crash.
Remedy: DVUSA will notify owners, and dealers will update the software communication module for the automatic emergency call system, free of charge. The recall began on May 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSXHERMPOS.
20V802000 · Service Brakes, Hydraulic:foundation Components:disc:caliper
Dec 21, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with electric parking brakes. The rear brake calipers may leak brake fluid into the housing of the electric parking brake connected to the rear axle service brake system, allowing air to enter the hydraulic brake system.
Consequence & remedy
Consequence: Air in the brake system can result in extended brake pedal travel, increasing the risk of a crash.
Remedy: DVUSA will replace the rear brake calipers, free of charge. Owners notification letters were mailed on January 4, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREPB.
20V772000 · Structure:body:hood
Dec 11, 2020
Daimler Vans USA, LLC (DVUSA) is recalling one 2019 Mercedes-Benz Sprinter 2500 vehicle. The engine hood may not have been installed properly.
Consequence & remedy
Consequence: In the event of a crash, the hood could make contact with the windshield, entering the passenger compartment and increasing the risk of an injury.
Remedy: DVUSA will notify the owner, and a dealer will replace the engine hood, free of charge. The recall is expected to begin January 18, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHAUBE.
20V756000 · Equipment:other:owners/service/other Manual
Dec 8, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter vehicles. These vehicles may have been delivered with a version of the printed and digital operator's manual that may be inaccurate and/or incomplete.
Consequence & remedy
Consequence: If the operator relies on the provided owner's manual, the information about vehicle functions and other safety relevant information may be inaccurate and/or incomplete, which could lead to improper operation of the vehicle and potentially increase the risk of a crash or injury.
Remedy: DVUSA will notify owners, and dealers will replace the printed version of the operator's manual with the latest version and update the software of the digital version, free of charge. DVUSA distributed owners an interim notification on January 22, 2021. The recall began March 17, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3PRIDIBA.
20V663000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Oct 28, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.
Consequence & remedy
Consequence: The sudden loss of power steering assist and hydraulic steering fluid leaking onto the roadway may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.
20V595000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Sep 29, 2020
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2020 Mercedes Benz and Freightliner Sprinters. The fuel line clamps may loosen and result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak can increase the risk of a fire.
Remedy: DVUSA will notify owners, and dealers will check the fuel hose clamp connections and tighten or replace the components as needed, free of charge. DVUSA issued owners an interim notification on November 9, 2020. The recall began January 19, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHELLE.
20V180000 · Equipment:other:owners/service/other Manual
Mar 26, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The Operator's Manual may not contain the correct information about how the automatic parking function ("Auto-P") operates.
Consequence & remedy
Consequence: If the driver relies on the Auto-P function as described in the Operator's Manual, vehicle rollaway or movement may occur, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will provide the correct description of the Auto-P function for the Operator's Manual, free of charge. The recall began May 18, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BAUTOP.
20V181000 · Service Brakes, Air:supply:hoses, Lines/piping, And Fittings; Structure:frame And Members:underbody Shields
Mar 25, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.
Consequence & remedy
Consequence: Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect and replace the brake hoses, as necessary. Additionally, the fender liners will be modified. All services will be performed free of charge. The recall began May 8, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BRADVER.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.
Consequence: Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect and replace the brake hoses, as necessary. Additionally, the fender liners will be modified. All services will be performed free of charge. The recall began May 8, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BRADVER.
Service Brakes, Air:supply:hoses, Lines/piping, And Fittings
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.
Consequence: Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect and replace the brake hoses, as necessary. Additionally, the fender liners will be modified. All services will be performed free of charge. The recall began May 8, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BRADVER.
20V155000 · Equipment:other:labels
Mar 18, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The spare tire label may indicate the maximum speed at 55 kilometers per hour (kph) rather than as 34 miles per hour (mph).
Consequence & remedy
Consequence: With only the metric speed listed on the spare tire label, the driver could misinterpret the kph as mph and operate the vehicle with the spare tire installed at higher speeds than the tire can withstand, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will replace it with the label with the correct maximum speed information indicated in miles per hour, free of charge. The recall began May 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BEGRESS.
20V156000 · Equipment:other:labels
Mar 18, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The spare tire label indicating the maximum speed may have not been affixed to the spare tire.
Consequence & remedy
Consequence: Without the label, an operator may be unaware of the maximum speed limit of the spare tire and operate the vehicle at a excessive speed, increasing the risk of tire failure and a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will attach the speed limitation label on the spare wheel, free of charge. The recall began May 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BEGREPP.
20V157000 · Tires
Mar 18, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with winter tires. The tires may not have been correctly installed, possibly resulting in reduced traction in wet or snowy conditions.
Consequence & remedy
Consequence: A reduction in traction may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect the running direction of the tires, correcting them as necessary. If the thread wear is uneven, the tires will be replaced. All services will be performed free of charge. The recall began May 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LAUFRI.
20V109000 · Steering
Feb 25, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The screws that secure the intermediate bearing of the steering spindle may not have been properly tightened, potentially causing the screws to loosen and detach.
Consequence & remedy
Consequence: If the screws detach, the driver may have difficulty steering the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace and properly tighten the steering spindle intermediate bearing screws, free of charge. The recall began April 13, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHLENK.
20V110000 · Steering:column
Feb 25, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The steering column casing cover may have not been installed, allowing the steering column area to be exposed.
Consequence & remedy
Consequence: If small vehicle components, such as nuts and screws, enter the steering column area, the steering operation can be affected, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will replace the steering column with one that has a cover, free of charge. The recall is expected to begin April 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3VERKLE.
20V078000 · Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)
Feb 12, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The connecting screws on the exhaust gas recirculation (EGR) pipe may not have been correctly tightened.
Consequence & remedy
Consequence: If the connecting screws are not properly tightened, hot exhaust gases may leak from the EGR pipe, increasing the risk of a fire.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will renew the screw connection and the flange seals on the exhaust gas recirculation pipe, free of charge. DVUSA issued owners an interim notification on April 6, 2020. The recall began May 4, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3AGROHR.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The connecting screws on the exhaust gas recirculation (EGR) pipe may not have been correctly tightened.
Consequence: If the connecting screws are not properly tightened, hot exhaust gases may leak from the EGR pipe, increasing the risk of a fire.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will renew the screw connection and the flange seals on the exhaust gas recirculation pipe, free of charge. DVUSA issued owners an interim notification on April 6, 2020. The recall began May 4, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3AGROHR.
Engine And Engine Cooling:exhaust System
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The connecting screws on the exhaust gas recirculation (EGR) pipe may not have been correctly tightened.
Consequence: If the connecting screws are not properly tightened, hot exhaust gases may leak from the EGR pipe, increasing the risk of a fire.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will renew the screw connection and the flange seals on the exhaust gas recirculation pipe, free of charge. DVUSA issued owners an interim notification on April 6, 2020. The recall began May 4, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3AGROHR.
20V079000 · Engine And Engine Cooling:exhaust System
Feb 12, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The flange connection between the exhaust gas turbocharger and the exit to the diesel particulate filter may not be attached properly, potentially causing an exhaust gas leak.
Consequence & remedy
Consequence: An exhaust gas leak in the engine compartment increases the risk of a fire.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will replace the flange seals and properly tighten the connection, free of charge. The recall began April 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FLABIND.
19V908000 · Equipment
Dec 19, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The lashing rails on the side walls may not have been properly installed, possibly resulting in the lashing rails detaching.
Consequence & remedy
Consequence: If the lashing rails disconnect, the cargo could become unsecured, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will correctly affix the lashing rails to the side walls, free of charge. DVUSA issued owners an interim notification on February 7, 2020. The recall began April 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ZUSCHI.
19V798000 · Fuel System, Diesel
Nov 7, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter vehicles equipped with diesel fuel systems. The bayonet lock between the fuel pump and the fuel tank may not have been closed and locked during manufacturing. As a result, a leak between the fuel pump and the fuel tank could occur. In addition, a gas station fuel pump may not automatically stop once the tank fill level is reached, potentially causing the fuel to overflow.
Consequence & remedy
Consequence: A diesel fuel leak can create slippery road conditions, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will inspect the bayonet lock on the fuel pump, locking it as necessary, free of charge. The recall began January 3, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KRAFMOD.
19V800000 · Seats
Nov 6, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner vehicles. A seam on the height adjuster for the front seats may have been insufficiently welded.
Consequence & remedy
Consequence: In the event of a crash, the weld seam may break and cause the seat cushion to shift forward, increasing the risk of injury.
Remedy: DVUSA will notify owners, and dealers will replace the tilt adjuster for the front seats, free of charge. DVUSA issued owners an interim notification on December 19, 2019. The recall began March 9, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SITZVER.
19V716000 · Structure:body:door
Oct 8, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter vehicles. In the affected vehicles, the abutting wedge, a component attached to the door jamb to make opening the door easier after a severe frontal impact, may have been installed incorrectly.
Consequence & remedy
Consequence: If a vehicle that has an incorrectly installed abutting wedge is involved in a severe frontal accident, a greater force may be necessary to open the doors, increasing the risk of injury.
Remedy: DVUSA will notify owners, and dealers will inspect the installation of the abutting wedge on the driver and front passenger side, correcting it, as necessary, free of charge. DVUSA issued owners an interim notification on November 22, 2019. The recall began February 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KEIL.
19V693000 · Unknown Or Other
Oct 2, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Sprinter and Metris vehicles. The vehicles left the reassembly plant without the final quality inspection of safety-relevant parts or bolt connections, resulting in possible unknown safety risks.
Consequence & remedy
Consequence: Failure to identify loose safety related parts can increase the risk of crash and injury.
Remedy: DVUSA will notify owners, and vehicles will be returned to the reassembly plant for comprehensive inspection and, if necessary, corrective action, free of charge. The recall began November 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSX566ZP25.
19V695000 · Air Bags: Air Bag/restraint Control Module
Oct 2, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter vehicles. The airbag systems may not have been activated after vehicle production. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An inactive airbag system can increase the risk of injury in the event of a crash.
Remedy: DVUSA will notify owners, and dealers will inspect the vehicles to determine if the airbag systems have been activated, correcting them as necessary, free of charge. DVUSA issued owners an interim notification on November 22, 2019. The recall began February 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3AIRIGEL.
19V665000 · Latches/locks/linkages:hood:latch
Sep 18, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter vehicles. The screw connection on the upper hood catch may have been improperly tightened. As a result, factors such as the vehicle's speed, wind resistance and road conditions may cause the hood to open while the vehicle is being driven.
Consequence & remedy
Consequence: A hood that opens while driving can reduce the driver's visibility, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will inspect the screw connection, tightening it as necessary, free of charge. The recall began November 1, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3HAUBOSS.
19V591000 · Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch
Aug 12, 2019
Daimler Vans USA, LLC. (MBUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter 1500, 2500, 3500, and 4500 vehicles. If the manual turn-switch that activates the vehicle lights is turned quickly from one lighting position to another, the brightness of the taillights can be significantly reduced or could switch off completely.
Consequence & remedy
Consequence: Reduced taillight visibility increases the risk of a crash.
Remedy: MBUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will update the body control unit software, free of charge. The recall began September 30, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is VS3HELI.
Additional source detail variants (2)
Exterior Lighting:tail Lights:switch
Daimler Vans USA, LLC. (MBUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter 1500, 2500, 3500, and 4500 vehicles. If the manual turn-switch that activates the vehicle lights is turned quickly from one lighting position to another, the brightness of the taillights can be significantly reduced or could switch off completely.
Consequence: Reduced taillight visibility increases the risk of a crash.
Remedy: MBUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will update the body control unit software, free of charge. The recall began September 30, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is VS3HELI.
Exterior Lighting:tail Lights
Daimler Vans USA, LLC. (MBUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter 1500, 2500, 3500, and 4500 vehicles. If the manual turn-switch that activates the vehicle lights is turned quickly from one lighting position to another, the brightness of the taillights can be significantly reduced or could switch off completely.
Consequence: Reduced taillight visibility increases the risk of a crash.
Remedy: MBUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will update the body control unit software, free of charge. The recall began September 30, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is VS3HELI.
19V507000 · Visibility:glass, Side/rear
Jul 2, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter 1500, 2500, 3500 and 4500 vehicles. The rear side windows may be single-pane safety glass instead of laminated safety glass.
Consequence & remedy
Consequence: In the event of a side impact crash or vehicle rollover, the fitted side windows may not adequately protect the rear occupants from being ejected, increasing their risk of injury.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner dealers will replace the single-pane safety glass with laminated safety glass., free of charge. DVUSA issued owners an interim notification on August 16, 2019. The recall began January 21, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3VERGLAS.
19V309000 · Exterior Lighting:headlights:high/low Beam Dimmer Switch
Apr 18, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter (Platform 907) vehicles equipped with high-beam assist. A software error in the control unit may prevent the driver from being able to switch off the high beams when intended.
Consequence & remedy
Consequence: Being unable to turn off the high beams may result in oncoming traffic being blinded by the vehicle's lights, increasing the risk of crash.
Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will update the control unit software, free of charge. The recall began June 14, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FERNLI.
19V284000 · Exterior Lighting:headlights
Apr 9, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles equipped with LED high performance headlights. The sensor for the headlamp range adjustment may not have been mounted or calibrated, possibly causing unexpected changes in the headlamp lighting angle.
Consequence & remedy
Consequence: Unexpected changes in the headlamp lighting angle may affect the drivers visibility, increasing the risk of crash.
Remedy: DVUSA will notify owners, and dealers will inspect and retrofit the sensor and correctly calibrate the rotation angle sensor, free of charge. The recall began June 11, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LEDSENS.
19V222000 · Unknown Or Other
Mar 20, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz Sprinter and Metris vehicles. The affected vehicles left the reassembly plant without the final quality inspection of safety-relevant parts or bolt connections, resulting in possible unknown safety risks.
Consequence & remedy
Consequence: Failure to identify loose safety related parts can increase the risk of crash and injury.
Remedy: DVUSA will notify owners, and dealers will complete the final quality inspection, free of charge. The recall began May 17, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSX566ZP25.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.