IllustrationTRANSMISSION DOES NOT DOWNSHIFT WHEN YOU TRY TO STOP, IT CHOKES AND DIES. TRANSMISSION IS STUCK ON THE 3 GEAR AND DOES NOT DOWNSHIFT. *TR
2007 MERCEDES-BENZ E350
Owner reports · Recalls · Investigations
More warning signs than most E350 years
Owner complaints for the 2007 MERCEDES-BENZ E350 are substantially higher than the model-year median of 161.
About this comparison →How this year compares
Owner complaints by model year
Compare all E350 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
4925–50K
7550–75K
7275–100K
68100–150K
13150K+
296 reports with mileage · 53 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 177 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports10 fire reports7 injury reports
Power Train complaints
21 reportsCHECK ENGINE LIGHT CAME ON. TOOK THE VEHICLE TO THE LOCAL DEALER AND THEY FOUND CODES 1200, 1208, P0016 AND P0017. WORN BALANCE SHAFT SPROCKET. DOING RESEARCH ONLINE TURNS OUT THERE ARE HUNDREDS AND HUNDREDS OF AFFECTED MB CUSTOMERS. MERCEDES KNEW OF THIS PROBLEM AS EARLY AS 2007 BUT HAS NOT PUBLICLY ADDRESSED THIS ISSUE OR ISSU…
Read full complaint
CHECK ENGINE LIGHT CAME ON. TOOK THE VEHICLE TO THE LOCAL DEALER AND THEY FOUND CODES 1200, 1208, P0016 AND P0017. WORN BALANCE SHAFT SPROCKET. DOING RESEARCH ONLINE TURNS OUT THERE ARE HUNDREDS AND HUNDREDS OF AFFECTED MB CUSTOMERS. MERCEDES KNEW OF THIS PROBLEM AS EARLY AS 2007 BUT HAS NOT PUBLICLY ADDRESSED THIS ISSUE OR ISSUED A RECALL. THE BILL TO FIX THIS ISSUE IS OVER $4,000, SOME PEOPLE REPORT THE DEALER QUOTING THEM OVER $10,000. MY PRICE TO FIX THIS IS $5,995. MY COMPLAINT IS THAT THIS IS A KNOWN ISSUE BY MERCEDES. KNOWINGLY THEY INSTALLED, AND KEPT INSTALLING, PARTS THAT WEAR OUT PREMATURELY LEAVING CUSTOMERS WITH AN UNFAIRLY LARGE BILL TO CORRECT THEIR MISTAKE. *TR
THE ABOVE DATE IS AN ESTIMATE: TRANSMISSION SLIPS CAUSING CAR TO STALL AND ALMOST GOT REAR-ENDED. TOOK CAR THAT WAS UNDER WARRANTY TO DEALERSHIP AND THEY COULD NOT FIND AN ISSUE WITH TRANSMISSION. PROBLEM HAVE GOTTEN WORST. GOOGLED ISSUE AND FOUND A LOT OF COMPLAINTS ABOUT THE SAME ISSUE. THE MORE SERIOUS PROBLEM IS MY CAR …
Read full complaint
THE ABOVE DATE IS AN ESTIMATE: TRANSMISSION SLIPS CAUSING CAR TO STALL AND ALMOST GOT REAR-ENDED. TOOK CAR THAT WAS UNDER WARRANTY TO DEALERSHIP AND THEY COULD NOT FIND AN ISSUE WITH TRANSMISSION. PROBLEM HAVE GOTTEN WORST. GOOGLED ISSUE AND FOUND A LOT OF COMPLAINTS ABOUT THE SAME ISSUE. THE MORE SERIOUS PROBLEM IS MY CAR REEKS WITH THE SMELL OF GASOLINE. TOOK CAR TO SAME DEALER AND THEY SAID THEY FIXED THE PROBLEM BUT MY CAR STILL SMELL OF GASOLINE. I ACTUALLY GET NAUSEA WHEN DRIVING AND EYES BEGAN TO BURN. IF I WAS A SMOKER, I WOULD BE AFRAID TO LIGHT A CIGARETTE IN MY CAR. MY GARAGE ALSO SMELL OF GASOLINE WHEN I PARK. WSBTV IN ATLANTA DID A SERIES ON THIS ISSUE LAST MONTH BECAUSE OF THE MANY COMPLAINTS. SOMEONE WILL BE INJURED OR KILLED IF THESE ISSUES IS NOT ADDRESS. DEALER IS MERCEDES BENZ OF SOUTH ATLANTA. *TR
WHILE ENTERING THE FREEWAY, THE TRANSMISSION DISENGAGED AND FAILED. THE VEHICLE WAS STEERED TO THE SHOULDER. THE DASH LIGHTS ALL CHANGED TO RED AND THE TRANSMISSION WOULD NOT ENGAGE. AFTER SHUTTING OFF THE ENGINE AND RESTARTING THE VEHICLE, IT PERFORMED NORMALLY UNTIL LAST WEEK. THE SAME FAILURE OCCURRED THREE TIMES LAST WEEK. A…
Read full complaint
WHILE ENTERING THE FREEWAY, THE TRANSMISSION DISENGAGED AND FAILED. THE VEHICLE WAS STEERED TO THE SHOULDER. THE DASH LIGHTS ALL CHANGED TO RED AND THE TRANSMISSION WOULD NOT ENGAGE. AFTER SHUTTING OFF THE ENGINE AND RESTARTING THE VEHICLE, IT PERFORMED NORMALLY UNTIL LAST WEEK. THE SAME FAILURE OCCURRED THREE TIMES LAST WEEK. AFTER RESTARTING THE ENGINE THE CAR WAS TAKEN TO THE CLOSEST NON-DEALER SERVICE CENTER AND A RESET OF THE TRANSMISSION SPEED SENSOR WAS PERFORMED ELECTRONICALLY. I WAS ADVISED THAT THIS IS A COMMON PROBLEM WITH MODEL AND THAT I WOULD NEED A NEW SET OF VALVES, SENSORS, SEALS ETC. *TR
TL* THE CONTACT OWNS A 2007 MERCEDES BENZ E350. THE CONTACT STATED THAT THE VEHICLE WOULD JERK VIOLENTLY WHEN SHIFTING GEARS. ALSO, WHILE DRIVING 20 MPH THE VEHICLE WOULD NOT SHIFT INTO SECOND GEAR AND STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT THEY PROVIDED NOT ASSISTANCE. THE VEHICLE WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2007 MERCEDES BENZ E350. THE CONTACT STATED THAT THE VEHICLE WOULD JERK VIOLENTLY WHEN SHIFTING GEARS. ALSO, WHILE DRIVING 20 MPH THE VEHICLE WOULD NOT SHIFT INTO SECOND GEAR AND STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT THEY PROVIDED NOT ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND FILED A COMPLAINT AND STATING THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE FAILURE MILEAGE WAS 113,000.
I BOUGHT THIS CAR ABOUT 4 MONTHS AGO. THIS CAR HAS BEEN SERVICED RELIGIOUSLY AT THE LOCAL MERCEDES DEALER AND THERE HAS BEEN "NO KNOW PROBLEMS". ON A THURSDAY I NOTICED THE CAR SHIFTING A LITTLE FUNNY SO I HAD MY HUSBAND DRIVE IT JUST TO BE SURE. HE NOTICED THE SAME ERRATIC SHIFTING. ON SATURDAY I DROPPED THE CAR OFF AT THE …
Read full complaint
I BOUGHT THIS CAR ABOUT 4 MONTHS AGO. THIS CAR HAS BEEN SERVICED RELIGIOUSLY AT THE LOCAL MERCEDES DEALER AND THERE HAS BEEN "NO KNOW PROBLEMS". ON A THURSDAY I NOTICED THE CAR SHIFTING A LITTLE FUNNY SO I HAD MY HUSBAND DRIVE IT JUST TO BE SURE. HE NOTICED THE SAME ERRATIC SHIFTING. ON SATURDAY I DROPPED THE CAR OFF AT THE MERCEDES DEALER (SAME DEALER IT HAS ALWAYS BEEN SERVICED AT). WHEN I PARKED THE CAR I WANTED TO CHECK EACH GEAR JUST TO MAKE SURE AND WHAT DO YOU KNOW...IT WOULD NOT SHIFT INTO REVERSE. LATER THAT DAY I HAD TO CALL MERCEDES TO FIND OUT WHAT WAS GOING ON WITH THE CAR AND THEY PROCEEDED TO TELL ME THE CAR HAD METAL SHAVINGS IN THE TRANSMISSION PAN AND WOULD NEED A NEW TRANSMISSION. THE QUOTE FOR A NEW TRANSMISSION IS $5800!!! I DON'T UNDERSTAND HOW THE CAR DID NOT GIVE ME ANY WARNING NOR AN INDICATOR LIGHT. THE CAR ONLY HAS 60K MILES ON IT AND IN NO WAY SHOULD NEED A NEW TRANSMISSION. ALSO, KEEP IN MIND THE TRANSMISSION WAS SERVICED AT THIS SAME MERCEDES DEALER AT 39K MILES. SOMETHING IS NOT RIGHT AND I WANT ANSWERS. I AM COMPLETELY SHOCKED AND SO UPSET. *TR
WHEN ACCELERATING FROM A STOP LIGHT, THE CAR WOULD NOT SHIFT GEARS AUTOMATICALLY. THE CAR SEEMS TO BE STUCK IN 1ST GEAR OR NEUTRAL AS I COULD NOT GET PAST 20MPH WITHOUT MAXING OUT MY RPM'S. I HAD TO DRIVE 3 MILES GOING 20MPH TO GET SOMEWHERE SO I COULD GET TOWED. AFTER TOWED TO THE DEALERSHIP, THEY COULD NOT REPLICATE THE SIT…
Read full complaint
WHEN ACCELERATING FROM A STOP LIGHT, THE CAR WOULD NOT SHIFT GEARS AUTOMATICALLY. THE CAR SEEMS TO BE STUCK IN 1ST GEAR OR NEUTRAL AS I COULD NOT GET PAST 20MPH WITHOUT MAXING OUT MY RPM'S. I HAD TO DRIVE 3 MILES GOING 20MPH TO GET SOMEWHERE SO I COULD GET TOWED. AFTER TOWED TO THE DEALERSHIP, THEY COULD NOT REPLICATE THE SITUATION. THIS HAS HAPPENED TWICE WITHIN A WEEK'S TIME. THIS IS A MERCEDES 2007 E350. I HAVE SEEN OTHER POSTS ABOUT THIS EXACT SAME THING WITH NO SOLUTION. THE DEALERSHIP SAID TO PULL OVER AND RESTART THE CAR. WHAT!!! WHAT KIND OF FIX IS THAT? I DO THAT TO MY HOME PC...I SHOULDN'T HAVE TO DO THAT FOR MY CAR! I BOUGHT THIS CAR LESS THAN 30 DAYS AGO...AND THE DEALERSHIP DOESN'T SEEM TO WANT ANY PART OF IT. I HAVEN'T EVEN MADE THE FIRST PAYMENT OR RECEIVED MY PERMANENT TAGS YET. *TR
THE CHECK ENGINE LIGHT CAME ON AND THE ENGINE STARTED MAKING A "CLICKING" NOISE. I TOOK THE CAR TO THE MERCEDES DEALERSHIP AND THEY SAID THAT THE BALANCE SHAFT GEAR WAS COMPLETELY DETERIORATED. THEY DESCRIBED THE GEAR AS "CHEWED UP"! I HAD NO CHOICE BUT TO PAY $4,000.00 TO GET THE ENGINE REMOVED FROM MY CAR AND HAVE THE BALAN…
Read full complaint
THE CHECK ENGINE LIGHT CAME ON AND THE ENGINE STARTED MAKING A "CLICKING" NOISE. I TOOK THE CAR TO THE MERCEDES DEALERSHIP AND THEY SAID THAT THE BALANCE SHAFT GEAR WAS COMPLETELY DETERIORATED. THEY DESCRIBED THE GEAR AS "CHEWED UP"! I HAD NO CHOICE BUT TO PAY $4,000.00 TO GET THE ENGINE REMOVED FROM MY CAR AND HAVE THE BALANCE SHAFT REPLACED. *TR
TL*THE CONTACT OWNS A 2007 MERCEDES BENZ E350. WHILE DRIVING 20 MPH WITH THE GEAR INDICATOR IN DRIVE, THE VEHICLE WAS MOVING AS IF IT WAS IN LOW GEAR. THE CONTACT SHUT OFF ENGINE IN ORDER TO RESET THE GEARS. THE DEALER REPAIRED THE ELECTRIC HYDRAULIC CONTROL UNIT AND 10 MINOR PARTS IN THE TRANSMISSION. WHEN THE FAILURE RECURRED,…
Read full complaint
TL*THE CONTACT OWNS A 2007 MERCEDES BENZ E350. WHILE DRIVING 20 MPH WITH THE GEAR INDICATOR IN DRIVE, THE VEHICLE WAS MOVING AS IF IT WAS IN LOW GEAR. THE CONTACT SHUT OFF ENGINE IN ORDER TO RESET THE GEARS. THE DEALER REPAIRED THE ELECTRIC HYDRAULIC CONTROL UNIT AND 10 MINOR PARTS IN THE TRANSMISSION. WHEN THE FAILURE RECURRED, THE DEALER WAS UNABLE TO DIAGNOSE OR DUPLICATE THE FAILURE. THE FAILURE HAS OCCURRED 2 TIMES. THE MANUFACTURER WAS CONTACTED AND DIDN'T PROVIDE A SOLUTION TO THE FAILURE. THE FAILURE MILEAGE WAS 29,700 AND THE CURRENT MILEAGE WAS 30,100.
NO WARNING OF ANY KIND, NOR ANY EVENT OF ANY KIND. ONE MINUTE, EVERYTHING IS FINE. THE NEXT, THE TRANSMISSION FAILS. TRANSMISSION FAILURE HAS HAPPENED 3 TIMES IN THE PAST 10 MONTHS. CAR IS A 2007 MERCEDES. ON ALL 3 OCCASIONS, I WAS DRIVING ON MULTIPLE LANE INTERSTATE. ONE 2 OF THE INCIDENTS, THE CAR SUDDENLY WENT OUT OF T…
Read full complaint
NO WARNING OF ANY KIND, NOR ANY EVENT OF ANY KIND. ONE MINUTE, EVERYTHING IS FINE. THE NEXT, THE TRANSMISSION FAILS. TRANSMISSION FAILURE HAS HAPPENED 3 TIMES IN THE PAST 10 MONTHS. CAR IS A 2007 MERCEDES. ON ALL 3 OCCASIONS, I WAS DRIVING ON MULTIPLE LANE INTERSTATE. ONE 2 OF THE INCIDENTS, THE CAR SUDDENLY WENT OUT OF THE DRIVE GEAR INTO WHAT FELT LIKE NEUTRAL. IT STAYED THERE FOR 10 OR 15 SECONDS AND THEN RESUMED IN DRIVE ON IT'S OWN. POSSIBLE CONSEQUENCES OF VERY SERIOUS ACCIDENT. ON THE 3RD INCIDENT, I WAS AT A STOPLIGHT AND WHEN STARTING ON THE GREEN LIGHT, THE CAR WOULD NOT COME OUT OF 1ST GEAR. JUST DROPPED CAR OFF TODAY FOR THIS AND DON'T KNOW RESULTS YET. WHAT WAS DONE TO CORRECT: ON BOTH OF THE FIRST 2 OCCASIONS, SOFTWARE WAS UPDATED. THERE WERE OTHER THINGS DONE WHICH BIZARRELY SOMEHOW RELATE TO THE TRANSMISSION. I HAVE NO PARTS. I BELIEVE I DO HAVE THE SERVICE SHEET FROM BOTH OF THE EARLIER INCIDENTS. *TR
Official recalls
524V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
22V954000 · Visibility:sun/moon Roof Assembly
Dec 23, 2022
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please refer to MBUSA's recall report for specific vehicle model details. The glass sunroof panel may not be properly secured and may detach.
Consequence & remedy
Consequence: A detached sunroof panel may become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary free of charge. Owner notification letters were mailed February 3, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall expands NHTSA recall number 19V-918. MBUSA's numbers for this recall are 2023010004, 2023010005, and 2023010006.
21V196000 · Visibility:sun/moon Roof Assembly
Mar 19, 2021
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2006-2007 C350, C230, C280, CLK350, E320CDI, E350 Wagon, E350, 2006 C55 AMG, CLK500, CLS500, CLS55 AMG, E500 Wagon, E500, E55 AMG, 2007 CLK550, CLS550, CLS63 AMG, E550, E63 AMG, and E63 Wagon AMG vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly causing the glass panel to detach from the vehicle.
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. Owner letters were mailed May 7, 2021. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of recall number 19V-918. MBUSA's number for this recall is 2021040012.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
12V264000 · Suspension:rear
Jun 12, 2012
MERCEDES-BENZ IS RECALLING CERTAIN MODEL YEAR 2007-2009 E350 4MATIC WAGON VEHICLES MANUFACTURED FROM JULY 1, 2006, THROUGH APRIL 30, 2009. A CONNECTING ROD FOR THE LOAD LEVELING REAR SUSPENSION SYSTEM MAY FAIL.
Consequence & remedy
Consequence: IF THIS OCCURS, THE DRIVER MAY HAVE REDUCED VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: MERCEDES-BENZ WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE ALL THE CONNECTING RODS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 7, 2012. OWNERS MAY CONTACT MERCEDES-BENZ AT 1-800-367-6372.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un