NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
54 reportsClear category filter138,000 miles · Jun 2, 2022
StructureSuspension
The contact owns a 2012 Mercedes-Benz C300. The contact stated while driving 70 MPH, there was an abnormally loud sound from the rear of the vehicle. The contact lost control of the vehicle. There was no warning light illuminated. The contact was able to continue normal driving once he regained control of the vehicle. The contac…
Read full complaint
The contact owns a 2012 Mercedes-Benz C300. The contact stated while driving 70 MPH, there was an abnormally loud sound from the rear of the vehicle. The contact lost control of the vehicle. There was no warning light illuminated. The contact was able to continue normal driving once he regained control of the vehicle. The contact scheduled an appointment with an independent mechanic for the vehicle to be inspected. The contact was informed that the rear subframe had detached from the passenger’s side of the vehicle due to severe corrosion. The dealer was notified of the failure and informed him that there were no recalls related to the failure on his vehicle. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 138,000.
NHTSA ODI #11467139
88,000 miles · May 10, 2022
Power TrainStructure
The contact owns a 2012 Mercedes-Benz C300. The contact stated that while the vehicle was receiving a routine maintenance, she was informed that the rear sub frame was rusted and had two holes. The vehicle was diagnosed that there was a transmission leak and the rear sub frame needed to be replaced. The vehicle was not repaired.…
Read full complaint
The contact owns a 2012 Mercedes-Benz C300. The contact stated that while the vehicle was receiving a routine maintenance, she was informed that the rear sub frame was rusted and had two holes. The vehicle was diagnosed that there was a transmission leak and the rear sub frame needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but no additional assistance was provided. The failure mileage was approximately 88,000.
NHTSA ODI #11464082
75,000 miles · May 2, 2022
StructureSuspension
The contact owns a 2012 Mercedes-Benz C300. The contact stated while driving approximately 65-70 MPH, he heard abnormal clicking sounds coming from the rear of the vehicle. Additionally, the contact stated that while driving and depressing the brake pedal to come to a complete stop, the vehicle swerved while stopping. The vehicl…
Read full complaint
The contact owns a 2012 Mercedes-Benz C300. The contact stated while driving approximately 65-70 MPH, he heard abnormal clicking sounds coming from the rear of the vehicle. Additionally, the contact stated that while driving and depressing the brake pedal to come to a complete stop, the vehicle swerved while stopping. The vehicle was taken to an independent mechanic where it was diagnosed that the rear driver's side subframe was severely corroded and fractured and needed to be replaced. The dealer was notified of the failure and informed the contact that the vehicle would be repaired at his own expense. The vehicle was not repaired. The manufacturer was notified of the failure but did not provide any assistance. The failure mileage was approximately 75,000.
NHTSA ODI #11463118
100,000 miles · Mar 15, 2022
Structure
The contact owns a 2012 Mercedes-Benz C300. The contact stated that while driving at an undisclosed speed, he depressed the brake pedal and the vehicle swerved. Upon inspection, the contact noticed that the rear passenger's side sub-frame was corroded and the stabilizer arm had detached from the sub-frame due to corrosion. The v…
Read full complaint
The contact owns a 2012 Mercedes-Benz C300. The contact stated that while driving at an undisclosed speed, he depressed the brake pedal and the vehicle swerved. Upon inspection, the contact noticed that the rear passenger's side sub-frame was corroded and the stabilizer arm had detached from the sub-frame due to corrosion. The vehicle was taken to an independent mechanic who diagnosed that the sub-frame needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.
NHTSA ODI #11456741
Mileage unknown · Mar 14, 2022
StructureUnknown Or Other
Vehicle was in for state inspection at an authorized inspection station. It failed inspection due to severely rusted and deteriorated rear K-Frame which had to be replaced to pass inspection. This is a major defect I feel caused by manufacture negligence. There were no warnings, messages or any signals indicating a problem. This…
Read full complaint
Vehicle was in for state inspection at an authorized inspection station. It failed inspection due to severely rusted and deteriorated rear K-Frame which had to be replaced to pass inspection. This is a major defect I feel caused by manufacture negligence. There were no warnings, messages or any signals indicating a problem. This issue could have severely caused an injury or even death had it not been detected by the mechanic inspector. Mechanic stated to me that he had replaced several of the rear K-Frames in the last year on this make and model.
NHTSA ODI #11456652
Mileage unknown · Mar 6, 2022
Structure
While driving recently we noticed that the vehicle pulled to one side while braking, and very hard under quick stop tests. Vehicle handling felt extremely dangerous when performing a hard brake test. An inspection was performed, and the service center found a rotted out rear subframe, and cracking around the suspension mounti…
Read full complaint
While driving recently we noticed that the vehicle pulled to one side while braking, and very hard under quick stop tests. Vehicle handling felt extremely dangerous when performing a hard brake test. An inspection was performed, and the service center found a rotted out rear subframe, and cracking around the suspension mounting brackets. After researching this repair, we found this to be a common problem in this and similar model Mercedes-Benz (MB) vehicles of that vintage. I understand that a recall may have been issued in Canada regarding this issue, but not in the U.S. Mercedes-Benz and their service stations have acknowledged this issue is common but they have not taken action to rectify this serious problem, or to compensate owners for the repair costs, which range from $3500 to $6000 depending on where the vehicle is serviced. We are the first owners of this car. It is barely 10 years old, is regularly maintained, and thoroughly washed during the winter months to remove road salt. A well maintained vehicle should not deteriorate this rapidly from rust, especially a Mercedes-Benz. We feel that it is unacceptable for MB to remain unaccountable for this problem.
NHTSA ODI #11455453
Mileage unknown · Feb 14, 2022
Structure
Per the dealership in connection with a regular service, the rear subframe rusted out and became structurally weak and was a safety hazard. The problem was confirmed and repaired by an independent repair shop. From Google searches, this issue does not appear to be an uncommon problem. Car is garaged and receives regular underb…
Read full complaint
Per the dealership in connection with a regular service, the rear subframe rusted out and became structurally weak and was a safety hazard. The problem was confirmed and repaired by an independent repair shop. From Google searches, this issue does not appear to be an uncommon problem. Car is garaged and receives regular underbody washes for road salt.
NHTSA ODI #11451935
Mileage unknown · Jan 7, 2022
Structure
This is a followup to a previous report. I now have photos and the actual part that was replaced. While driving on secondary road at 45 mph, braked for stoplight in 2012 Mercedes C300 4matic. Car veered left, rear swung right, and right front dove downward. Luckily regained control and prevented swerving into oncoming traffic…
Read full complaint
This is a followup to a previous report. I now have photos and the actual part that was replaced. While driving on secondary road at 45 mph, braked for stoplight in 2012 Mercedes C300 4matic. Car veered left, rear swung right, and right front dove downward. Luckily regained control and prevented swerving into oncoming traffic. Took car to my regular mechanic and it was determined that the welds on the left rear portion of the rear subframe had rusted out from the inside of the subframe, severing the attachment to the left rear wheel control arms. The car had been inspected 6 months earlier and there was no sign of problem. The failure was catastrophic, not gradual. Upon removal, it was also noted that the right mounting bracket was also in the process of rusting through and failing. When the mechanic called the local Mercedes dealer, the service manager was not surprised and proceeded to outline what parts would be needed to carry out the repair. When I contacted the local Mercedes dealer, myself, they said this wasn’t an uncommon problem, but there was not recall or service bulletin on the problem. Was given a rough quote of $5000 to affect the repair. I also contacted Mercedes Benz USA and was told there were no recalls or service bulletins, but they might be able to provide some “Goodwill Assistance” to offset the expected cost if I had it towed to a MB dealer and got a quote from them. Benzworld.org, an owners forum with over 5 million participants world-wide https://www.benzworld.org/threads/w204-rear-subframes-deterioration.3048088/#post-17965564 has multiple postings about the problem as do other forums including CarProblemZoo.com https://www.carproblemzoo.com/mercedesbenz/c300/suspension-problems.php . This design/manufacturer defect has had recalls in both Europe and Canada. Why this is not being addressed in the US? This sudden failure is potentially life-threatening.
NHTSA ODI #11446590
43,000 miles · Dec 13, 2021
Structure
The contact's wife owns a 2012 Mercedes-Benz C300. The contact stated that upon taking the vehicle to the dealer to be serviced, he was informed that the subframe was severely corroded and could fracture. The manufacturer was notified of the failure and advised the contact that they could not assist as the vehicle was out of war…
Read full complaint
The contact's wife owns a 2012 Mercedes-Benz C300. The contact stated that upon taking the vehicle to the dealer to be serviced, he was informed that the subframe was severely corroded and could fracture. The manufacturer was notified of the failure and advised the contact that they could not assist as the vehicle was out of warranty. The vehicle was not repaired. The approximate failure mileage was 43,000.
NHTSA ODI #11443648
Mileage unknown · Nov 26, 2021
Structure
While driving on secondary road at 45 mph, braked for stoplight in 2012 Mercedes C300 4matic. Car veered left, rear swung right, and right front dove downward. Luckily regained control and prevented swerving into oncoming traffic. Took car to my regular mechanic and it was determined that the welds on the left rear portion of…
Read full complaint
While driving on secondary road at 45 mph, braked for stoplight in 2012 Mercedes C300 4matic. Car veered left, rear swung right, and right front dove downward. Luckily regained control and prevented swerving into oncoming traffic. Took car to my regular mechanic and it was determined that the welds on the left rear portion of the rear subframe had rusted out from the inside of the subframe, severing the attachment to the left rear wheel control arms. The car had been inspected 6 months earlier and there was no sign of problem. The failure was catastrophic, not gradual. When the mechanic called the local Mercedes dealer, the service manager was not surprised and proceeded to outline what parts would be needed to carry out the repair. When I contacted the local Mercedes dealer, myself, they said this wasn’t an uncommon problem, but there was not recall or service bulletin on the problem. Was given a rough quote of $5000 to affect the repair. I also contacted Mercedes Benz USA and was told there were no recalls or service bulletins, but they might be able to provide some “Goodwill Assistance” to offset the expected cost if I had it towed to a MB dealer and got a quote from them. Benzworld.org, an owners forum with over 5 million participants world-wide https://www.benzworld.org/threads/w204-rear-subframes-deterioration.3048088/#post-17965564 has multiple postings about the problem as do other forums including CarProblemZoo.com https://www.carproblemzoo.com/mercedesbenz/c300/suspension-problems.php . This design/manufacturer defect has had recalls in both Europe and Canada. Why this is not being addressed in the US? This sudden failure is potentially life-threatening.
NHTSA ODI #11441743
Official recalls
6May 22, 2020
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2012 C250, C250 Coupe, C300, C350, C350 Coupe, C63 AMG, and C63 AMG Coupe vehicles equipped with a front passenger air bag assembly replaced under a prior recall. An incorrect replacement front passenger air bag may have been installed.
Consequence & remedy
Consequence: An incorrect passenger air bag may not provide adequate protection, increasing the risk of injury in the event of a crash.
Remedy: MBUSA will notify owners, and dealers will replace the passenger air bag module, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020060011.
Jan 9, 2019
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2014 C250, C300 4Matic, C350, C63 AMG, E350 4Matic Coupe, E350 Cabrio, E350 Coupe, SLS AMG Cabrio, SLS AMG Coupe, 2014-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, GLK 350, GLK250 BlueTec 4Matic, GLK350 RWD, 2015-2017 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2014-2017 E550 Cabrio, and 2014-2016 E550 Coupe vehicles sold, or ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP, and VI or "Zone A." Additionally, MBUSA is recalling certain 2012-2014 C250, E350 4Matic Coupe, SLS AMG Cabrio, 2012-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, 2011 C300, 2011-2014 C300 4Matic, C350, C63 AMG, E350 Cabrio, E350 Coupe, SLS AMG Coupe, 2015-2016 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2011-2016 E550 Cabrio, E550 Coupe, 2011-2015 GLK350 4Matic, GLK350 RWD, and 2013-2015 GLK250 BlueTec 4Matic vehicles ever registered in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." MBUSA is also recalling certain 2012-2014 C250, E350 4Matic Coupe, SLS AMG Cabrio 2012-2015 C250 Coupe, C350 4Matic Coupe, C350 Coupe, C63 AMG Coupe, 2010-2011 C300, 2010-2014 C300 4Matic, C350, C63 AMG, E350 Coupe, 2011-2014 E350 Cabrio, SLS AMG Coupe, 2015-2016 E400 4Matic Coupe, E400 Cabrio, E400 Coupe, 2016-2017 E550 Cabrio, 2010-2016 E550 Coupe, 2010-2015 GLK350 4Matic, GLK350 RWD, and 2013-2015 GLK250 BlueTec 4Matic vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MO, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI and WY or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the passenger or other occupants resulting in serious injury or death.
Remedy: MBUSA will notify owners, and dealers will replace the passenger frontal air bag module, free of charge. The recall began March 29, 2019. Owners may contact MBUSA customer service at 1-800-367-6372.
Oct 6, 2017
Mercedes-Benz USA, LLC. (MBUSA) is recalling these vehicles: 2014-2018 CLA250, CLA250 4Matic, CLA45 AMG 4Matic, 2015-2018 GLA250, GLA250 4Matic, GLA45 AMG 4Matic, C300 4Matic, C63S AMG, 2012-2014 C250, C350, C300 4Matic, E550 4Matic, 2013-2014 C63 AMG, 2012-2015 C250 Coupe, C350 Coupe, C63 AMG Coupe, 2013-2015 C350 4Matic Coupe, GLK250 4Matic BlueTec, GLK350, GLK350 4Matic, 2016-2017 C350e, C43 AMG, 2015 C400 4Matic, 2016-2018 C63 AMG, GLC300, GLC300 4Matic, 2017-2018 C300 Coupe, C300 4Matic Coupe, C43 AMG, C63 AMG Coupe, C63S AMG Coupe, C300 Cabriolet, C300 4Matic Cabriolet, C43 AMG Cabriolet, C63 AMG Cabriolet, C63S AMG Cabriolet, GLC300 4Matic Coupe, GLC43 AMG, GLC43 AMG Coupe, 2014 E350 Coupe, E350 4Matic Coupe, E350 Cabriolet, E400 Hybrid, 2015-2017 E400 Coupe, E400 4Matic Coupe, E400 Cabriolet, 2014-2017 E550 Coupe, E550 Cabriolet, B250e, 2014-2016 E250 BlueTec, E63 AMG 4Matic Wagon, 2012-2013 E350 BlueTec, 2012-2016 E350, E350 4Matic, 2015-2016 E400, E400 4Matic, 2012 E63 AMG, 2014-2015 E250 4Matic BlueTec, 2013-2016 E350 Wagon, 2017 GLC300d 4Matic, and 2018 GLC350e 4Matic. The driver's air bag may unexpectedly deploy due to insufficient grounding of the steering components if an electrostatic discharge occurs and the air bag clockspring is broken.
Consequence & remedy
Consequence: If the driver air bag inadvertently deploys, it can increase the risk of injury and a crash.
Remedy: MBUSA will notify owners, and dealers will add sufficient grounding to the steering components, free of charge. The recall began in December 6, 2017. Owners may contact MBUSA customer service at 1-877-496-3691.
Mar 14, 2017
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2016 AMG GT-S, GLC300, CLA250 and GLE300d 4Matic vehicles, 2013 C250, E350 BlueTec and G63 AMG vehicles, 2008-2014 C300 vehicles, 2013-2014 C300 4Matic and ML350 4Matic vehicles, 2009 C350 vehicles, 2014 CLS550, E350 4Matic, E350 Coupe 4Matic, E350 Wagon 4Matic, GLK350 and SL550 vehicles, 2012 CLS550 4Matic vehicles, 2012-2016 E350 vehicles, 2016-2017 GL450 4Matic vehicles, 2012-2014 ML350 4Matic BlueTec vehicles, 2015 S550, S550 4Matic and C300 4Matic Sedan vehicles, 2015-2016 C300 Sedan vehicles, and 2017 SL63 AMG vehicles. Various control units on these vehicles may have been updated with incorrect software, potentially affecting the correct deployment of the air bags in the event of a crash.
Consequence & remedy
Consequence: If the air bags do not deploy as intended in the event of a crash, there would be an increased risk of injury in the event of a crash.
Remedy: MBUSA will notify owners, and dealers will update software in the affected control units, free of charge. The recall began April 21, 2017. Owners may contact MBUSA customer service at 1-800-367-6372.
Additional source detail variants (2)
Electrical System:software
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2016 AMG GT-S, GLC300, CLA250 and GLE300d 4Matic vehicles, 2013 C250, E350 BlueTec and G63 AMG vehicles, 2008-2014 C300 vehicles, 2013-2014 C300 4Matic and ML350 4Matic vehicles, 2009 C350 vehicles, 2014 CLS550, E350 4Matic, E350 Coupe 4Matic, E350 Wagon 4Matic, GLK350 and SL550 vehicles, 2012 CLS550 4Matic vehicles, 2012-2016 E350 vehicles, 2016-2017 GL450 4Matic vehicles, 2012-2014 ML350 4Matic BlueTec vehicles, 2015 S550, S550 4Matic and C300 4Matic Sedan vehicles, 2015-2016 C300 Sedan vehicles, and 2017 SL63 AMG vehicles. Various control units on these vehicles may have been updated with incorrect software, potentially affecting the correct deployment of the air bags in the event of a crash.
Consequence: If the air bags do not deploy as intended in the event of a crash, there would be an increased risk of injury in the event of a crash.
Remedy: MBUSA will notify owners, and dealers will update software in the affected control units, free of charge. The recall began April 21, 2017. Owners may contact MBUSA customer service at 1-800-367-6372.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2016 AMG GT-S, GLC300, CLA250 and GLE300d 4Matic vehicles, 2013 C250, E350 BlueTec and G63 AMG vehicles, 2008-2014 C300 vehicles, 2013-2014 C300 4Matic and ML350 4Matic vehicles, 2009 C350 vehicles, 2014 CLS550, E350 4Matic, E350 Coupe 4Matic, E350 Wagon 4Matic, GLK350 and SL550 vehicles, 2012 CLS550 4Matic vehicles, 2012-2016 E350 vehicles, 2016-2017 GL450 4Matic vehicles, 2012-2014 ML350 4Matic BlueTec vehicles, 2015 S550, S550 4Matic and C300 4Matic Sedan vehicles, 2015-2016 C300 Sedan vehicles, and 2017 SL63 AMG vehicles. Various control units on these vehicles may have been updated with incorrect software, potentially affecting the correct deployment of the air bags in the event of a crash.
Consequence: If the air bags do not deploy as intended in the event of a crash, there would be an increased risk of injury in the event of a crash.
Remedy: MBUSA will notify owners, and dealers will update software in the affected control units, free of charge. The recall began April 21, 2017. Owners may contact MBUSA customer service at 1-800-367-6372.
Jan 10, 2017
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2012 C300 4Matic, C250, C250 Coupe, C350, C350 Coupe 4Matic, C350 Coupe, C63 AMG, C63 AMG Coupe, E350 Coupe 4Matic, E350 Cabrio, E350 Coupe, E550 Cabrio, E550 Coupe, GLK350 4Matic, GLK350, SLS AMG Cabrio, and SLS AMG Coupe vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above MBUSA is recalling certain 2009 C300 4Matic, C300, C350 and C63 AMG vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above MBUSA is recalling certain 2008 C300 4Matic, C300, and C350 vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: MBUSA will notify owners, and dealers will replace the front passenger air bag modules, free of charge. Owners were sent an interim notification in March 2017. Second notices started going out in October 2018 and continue to be mailed as parts become available. Owners may contact MBUSA customer service at 1-877-496-3691
Dec 3, 2012
Mercedes-Benz is recalling certain model year 2011-2012 S400, S550, S550 4Matic, S63 AMG, C300, C300 4Matic, E350, GLK350, GLK350 4Matic, CL550 4Matic, and CL63 AMG vehicles manufactured from April 18, 2011, through July 12, 2011. Due to an irregularity stemming from the molding process of the fuel filter flange, the fuel filter flange may crack when operated in high temperatures.
Consequence & remedy
Consequence: If the fuel filter flange cracks, it will leak fuel which may lead to a fire if an external ignition source is present.
Remedy: Mercedes-Benz will notify owners, and dealers will replace the fuel filter, free of charge. The recall campaign is expected to begin in February 2013. Owners may contact Mercedes-Benz at 1-800-367-6372.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration