Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 14 of 16 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Vehicle Speed Control. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electronic Stability Control (esc). Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
Electronic Stability Control (esc)Power TrainService Brakes, Hydraulic
The contact owns a 2015 Mercedes-Benz Sprinter 3500. The contact stated while driving approximately 35 mph, the transmission inadvertently downshifted into third gear and the vehicle stalled with an unknown warning light illuminated. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the rea…
Read full complaint
The contact owns a 2015 Mercedes-Benz Sprinter 3500. The contact stated while driving approximately 35 mph, the transmission inadvertently downshifted into third gear and the vehicle stalled with an unknown warning light illuminated. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the rear wheel speed sensors were faulty and needed to be replaced. The vehicle was repaired, and the failure was remedied. The contact later received notification of NHTSA campaign number 21V042000 (Electronic Stability Control) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not contacted. Vin tool confirms parts not available. The failure mileage was 52,000.
NHTSA ODI #11426973
12,000 miles · Oct 25, 2020
Electronic Stability Control (esc)Service Brakes
I WAS DRIVING ON AN INTERSTATE HWY AND THE ABS AND ESP WARNING MALFUNCTION OCCURED WITH A VISIT WORKSHOP MESSAGE. THE ENGINE RPM REVED UP AND THE VEHICLE SLOWED TO 40 MPH. I WAS ABLE TO GET TO A SAFE PLACE. CONSULTATION WITH A REPAIR FACILITY DETERMINED THE CAUSE TO BE THE WHEEL SPEED SENSORS ON THE REAR WHEELS. FURTHER INVESTIG…
Read full complaint
I WAS DRIVING ON AN INTERSTATE HWY AND THE ABS AND ESP WARNING MALFUNCTION OCCURED WITH A VISIT WORKSHOP MESSAGE. THE ENGINE RPM REVED UP AND THE VEHICLE SLOWED TO 40 MPH. I WAS ABLE TO GET TO A SAFE PLACE. CONSULTATION WITH A REPAIR FACILITY DETERMINED THE CAUSE TO BE THE WHEEL SPEED SENSORS ON THE REAR WHEELS. FURTHER INVESTIGATION REVEALED THIS SAME THING PREVIOUSLY OCCURED WITH THE PREVIOUS OWNER WITH 4000 MILES ON THE VEHICLE THE SPEED SENSORS WERE REPLACED AT FACTORY AUTH DEALER AT THAT TIME. THIS INCIDENT I AM DESCRIBING OCCURED AT 12000 MILES ON THE VEHICLE. I WAS 700 MILES FROM HOME AND THE NEAREST FACTORY REPAIR FACILITY'S ONLY EMERGENCY OPENING WAS 3 DAYS IN THE FUTURE. THE INDEPENDENT REPAIR FACILITY THAT DIAGNOSED THE PROBLEM WAS NOT ABLE TO PERFORM THE NECESSARY REPAIRS. I DROVE HOME IN LIMP MODE. 4 SPEED SENSORS WERE PURCHASED AT A MERCEDES DEALER FOR A COST OF $900.00 AND REPLACED BY MYSELF. PRIOR TO REPLACING THE SENSORS THE SECOND TIME THE ABS AND ESP WARNING OCCURED BRIEFLY AND CLEARED ON THEIR OWN. MUCH RESEARCH HAS SHOWN THIS IS A VERY COMMON FAILURE OF THESE VEHICLES.
NHTSA ODI #11366293
31,000 miles · Sep 29, 2020
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
VEHICLE HAS A HIGH FAILURE RATE FOR TIRE ROTATION SPEED SENSORS. THIS CONDITION IMMEDIATELY DISABLES THE ANTILOCK BRAKES, STABILITY CONTROL, TRACTION CONTROL AND CRUISE CONTROL. VEHICLE MILEAGE WAS 31000 MILES AT LOSS OF THIRD SENSOR. VEHICLE WAS IN MOTION AT HIGHWAY SPEEDS AT THE TIME OF ALL FAILURES.
Mercedes-Benz USA, LLC - DBA Sprinter (Mercedes) is recalling certain model year 2015 Sprinter 2500 and Sprinter 3500 vehicles manufactured February 28, 2014, to January 22, 2015. In the affected vehicles, oil may leak from around the chain tensioner gasket area.
Consequence & remedy
Consequence: Leaking oil may drip onto a hot engine surface, increasing the risk of a fire. Additionally, the leaking oil may be a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Mercedes will notify owners, and dealers will replace the chain tensioner gasket, free of charge. The recall began May 18, 2015. Owners may contact Mercedes customer service at 1-877-762-8267. Note: This recall is an expansion of 14V-764.
Mercedes-Benz USA, LLC - DBA Sprinter (Sprinter) is recalling certain model year 2015 Sprinter 2500 and 3500 vehicles manufactured July 1, 2014, to October 14, 2014. In the affected vehicles, the abutting wedge, a component attached to the door jamb to make opening the door easier after a severe frontal impact, may have been installed incorrectly.
Consequence & remedy
Consequence: If a vehicle that has an incorrectly installed abutting wedge is involved in a severe frontal accident, a greater force may be necessary to open the doors, increasing the risk of injury.
Remedy: Sprinter will notify owners, and dealers will check the installation of the abutting wedge, correcting it as necessary, free of charge. The recall began in March 2015. Owners may contact Sprinter customer service at 1-877-762-8267.
Mercedes-Benz USA, LLC - DBA Sprinter (Mercedes) is recalling certain model year 2014-2015 Sprinter 2500, and Sprinter 3500 vehicles manufactured February 28, 2014, to November 21, 2014. In the affected vehicles, oil may leak from around the chain tensioner gasket area.
Consequence & remedy
Consequence: Leaking oil may drip onto a hot engine surface, increasing the risk of a fire. Additionally, the leaking oil may be a road hazard for other vehicles, increasing the risk of a crash.
Remedy: Mercedes will notify owners, and dealers will replace the chain tensioner gasket, free of charge. The recall began on December 19, 2014. Owners may contact Mercedes customer service at 1-877-762-8267. Mercedes' number for this recall is 2014120003.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2015 Mercedes Benz Sprinter 3500 Problems, Complaints & Recalls | Skip That Year
Illustration