1995 Mercedes Benz S Class

MY AUXILIARY FANS WOULD NOT INITIATE, SO WE DECIDED TO REPLACE THE SWITCH THAT CONTROLS THE FANS. LOW AND BEHOLD, THE WIRING THAT WAS ATTACHED TO THIS SWITCH WAS CRUMBLING LIKE STALE BREAD CRUMBS AND FLAKES. I WANTED TO REPLACE THE WIRE, SO I UNDID THE ENTIRE HARNESS. I FOUND WORSE! THE ENTIRE HARNESS WAS CRUMBLING, BUT I WAS NOT ABLE TO SEE IT BEFORE BECAUSE OF THE BLACK COVERING AROUND THE WIRING. THE HARNESS IS COMPLETELY RUINED AND I CAN'T BELIEVE THE # OF COMPLAINTS I'M FINALLY SEEING REGARDING THIS PROBLEM. WOW! BAD ENGINEERING ON THE PART OF MERCEDES FOR THIS ISSUE. MY CAR IS A 1995 THAT HAS BEEN GARAGE ITS ENTIRE LIFE, FOR THE MOST PART. I AM GOING THROUGH THE PAINSTAKING LABOR OF RE-WIRING THIS ENTIRE HARNESS MYSELF...AND IT'S NOT LOOKING GOOD. *TR

THE FUEL SYSTEM WIRING HARNESS ON MY 1995 MERCEDES-BENZ S600 SHORTED OUT AND MADE MY CAR INOPERABLE. THIS OCCURRED WHILE SITTING IN TRAFFIC DRIVE BACK FROM WORK. I WAS ABLE TO 'JIGGLE' THE WIRES ENOUGH TO LIMP TO MY DRIVEWAY. WHILE 'LIMPING', THE CAR CONTINUOUSLY BACKFIRED AND HEAVED TOWARDS THE CARS IN FRONT OF ME, NARROWLY REAR-ENDING THEM. *TR

I HAVE A 1995 S320 BENZ . ON END OF SEPTEMBER THE ENGINE LIGHT COMES ON AND I CHANGED THE AIR MASS FLOW SENSOR THAN A MONTH LATER THE A/C SOMETIMES WORK AND OTHER TIMES NOT I CHANGED THE VACUUM HOSES THAT GOES TO AC SOLENOID PLUS THE EGR HOSE, AND ONE WIRE THAT GOES TO THE A/C RELAY. NOW THE ENGINE LIGHT AGAIN GOES ON AND I CALLED THE DEALER AND ASK IF ANY RECALL ON 1995 S320 THEY SAY NO. YET THERE IS OVER 150 COMPLAINED TO YOUR DEPARTMENT. *NM

MY 1995 MERCEDES S320 WIRING HARNESS INSULATION DECOMPOSING. BARE WIRES ARE EXPOSED AT ENGINE COIL CONNECTIONS. THE INSULATION ON THE HARNESS WIRES IS JUST CRUMBLING. VEHICLE IS PRESENTLY DISABLED IN LIMP MODE. PRIOR TO THIS, THE VEHICLE WOULD GO INTO LIMP MODE WHILE EXECUTING TURNS. PART COST IS $750; DEALER LABOR COST IS $600. THE WIRING MAY HAVE DAMAGED OTHER ELECTRICAL COMPONENTS (I.E.: COMPUTER OR VOLTAGE REGULATOR). THIS WIRING INSULATION PROBLEM IS NOT NORMAL WITH ANY VEHICLE, NO LESS ONE THAT COSTS $65,000 NEW. THIS MOST DEFINITELY SHOULD BE A RECALL ITEM. *JB

MY 1995 MERCEDES S320 HAS BEEN STALLING AND MISFIRING AND SOMETIMES DOESN'T START UP. I TOOK IT FOR TUNE UP, BUT THE MECHANIC SAID HE CANT DO ANYTHING BECAUSE THE FAULT WIRING HARNESS INSULATION FROM FACTORY IS PEELING OFF AND MAKING THE WIRES SHORT-CIRCUIT AND IF HE TRIES TO DO ANYTHING IT WILL MAKE IT WORSE,I HAVE TALKED TO SEVERAL MERCEDES OWNERS WITH EARLIER AND MID 90S WHO HAVE SAME PROBLEM AND I THINK THIS IS A POTENTIAL FIRE HAZARD AND YOU SHOULD PETITION THE MANUFACTURER ON OUR BEHALF. *NM

PARTS OF THE ELECTRICAL SYSTEM BEGAN FAILING. DRIVERS WINDOW WOULD NOT OPERATE AND AFTER MUCH TROUBLESHOOTING BY THE REPAIR SHOP, THE SWITCH WAS REPLACED. SEVERAL WEEKS LATER GAUGES ON THE DASH FAILED AND THE PASSENGER WINDOW AND HORN FAILED TO OPERATE. AFTER DISASSEMBLING THE INTERIOR (SEATS, CONSOLE, DASH, ETC.) THE REPAIR SHOP CAME UPON THE PROBLEM - WIRES SHORTING ALL ALONG THE WIRING HARNESS AND CAUSE SPARKS AND SHORTS THROUGHOUT. *NM