Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 14 of 18 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
18 reports
55,000 miles · Jan 20, 2004
Fuel System, GasolineFire
CAR CAUGHT ON FIRE WHILE DRIVING IN NORMAL CITY TRAFFIC. SMOKE BEGAN COMING OUT OF THE RIGHT SIDE OF THE HOOD. PULLED OVER IMMEDIATELY AND GOT OUT OF THE VEHICLE NOTICING FLAMES COMING FROM UNDERNEATH THE FRONT OF THE CAR. BY THE TIME THE FIREFIGHTERS PUT OUT THE BLAZE THE FRONT PART OF THE CAR WAS DESTROYED. THE CASE WAS INVEST…
Read full complaint
CAR CAUGHT ON FIRE WHILE DRIVING IN NORMAL CITY TRAFFIC. SMOKE BEGAN COMING OUT OF THE RIGHT SIDE OF THE HOOD. PULLED OVER IMMEDIATELY AND GOT OUT OF THE VEHICLE NOTICING FLAMES COMING FROM UNDERNEATH THE FRONT OF THE CAR. BY THE TIME THE FIREFIGHTERS PUT OUT THE BLAZE THE FRONT PART OF THE CAR WAS DESTROYED. THE CASE WAS INVESTIGATED BY PALM BEACH COUNTY FIRE RESCUE. THE VEHICLE WAS METICULOUSLY MAINTAINED BY OWNER. HAS BEEN SERVICED REGULARLY FOLLOWING THE SCHEDULE RECOMMENDED BY MANUFACTURER AND USED FUEL, LUBRICANTS ETC. RECOMMENDED BY MERCEDES BENZ. OWNER BOUGHT THE CAR NEW IN 1999 AND ALWAYS TOOK FOR SERVICES, SAFETY RECALLS AND REPAIRS TO AUTHORIZED MERCEDES BENZ DEALER. AT THE TIME OF THE FIRE, THE CAR HAD ARROUND 55,000 MILES. NOTE: THIS COMPLAIN WAS REPOTED VIA PHONE ALSO. CASE WAS INVESTICATED BY PALM BEACH COUNTY FIRE RESCUE.*AK
NHTSA ODI #10054490
45,000 miles · Jan 15, 2004
Engine And Engine CoolingEquipmentSteering
I HAVE PROBLEMS WITH MY CHECK ENGINE LIGHT FROM AND FAULTY OXYGEN SENSOR, THE CAR WAS REPAIRED UNDER WARRANTY. THEN I HAD A HOSE DISCONNECT AND LOST POWER STEERING PRIOR TO THE RECALL ON THE HOSE CLOAMP AND I PAID THE TOWING AND REPAIRS MYSELF. NOW I HAVE HAD A MAJOR MECHANICAL PROBLEM AND ON AUGUST 5TH, MY CAR LOST POWER STEER…
Read full complaint
I HAVE PROBLEMS WITH MY CHECK ENGINE LIGHT FROM AND FAULTY OXYGEN SENSOR, THE CAR WAS REPAIRED UNDER WARRANTY. THEN I HAD A HOSE DISCONNECT AND LOST POWER STEERING PRIOR TO THE RECALL ON THE HOSE CLOAMP AND I PAID THE TOWING AND REPAIRS MYSELF. NOW I HAVE HAD A MAJOR MECHANICAL PROBLEM AND ON AUGUST 5TH, MY CAR LOST POWER STEERING, AIR CONDITIONING, THE BATTERY LIGHT CAME ON AND THEN MY CAR BEGAN OVERHEATING. APPARENTLY THE CRANKSHAFT BROKE AND IT SHREDDED ONE OF THE MAJOR BELTS, WHICH DAMAGED THE OIL PAN AND WATER PUMP. I IMMEDIATELY PULLED OVER AND HAD THE CAR TOWED 20 MILES TO THE DEALER. THE BILL IS GOING TO BE $3000. I SAW A SIMILAR COMPLAINT ON THE NHTSA WEB SITE. I AM CONCERNED THAT OTHER CONSUMERS MAY HAVE SIMILAR PROBLEMS AND MAY NOT BE ABLE TO PULL OVER SAFELY, NOT TO MENTION THE COST OF REPAIRS.
NHTSA ODI #10069784
100,000 miles · Oct 31, 2003
Power Train
DRIVE SHAFT FAILURE. *LA
NHTSA ODI #10045211
46,600 miles · Feb 21, 2003
Steering
FIRST OCCURANCE WAS LEAKAGE 2 MONTHS PRIOR, CLAMP TIGHTENED BY DEALER. 2ND OCCURENCE ON REPORTED DATE, STARTED TO DRIVE OUT OF PARKING LOT, POWER STEERING HOSE BLEW OFF, LOST ALL FLUID AND POWER STEERING ASSIST.
NHTSA ODI #10007936
115,000 miles · Feb 20, 2003
Steering
POWER STEERING HOSE CLAMPS. BASED ON PUBLISHED COMMENTS BY INDIVIDUALS ON VARIOUS INTERNET CHAT GROUPS FOR THIS TRUCK REGARDING HYDRAULIC FLUID LEAKS AND FAILURES OF THE POWER STEERING HOSE, I CHECK MY HOSES AND FOUND THAT THE LOWER HOSE WAS ABOUT TO COME OFF. THE CLAMP, WHICH WAS LOOSE, WAS RETIGHTENED.
NHTSA ODI #10007841
Mileage unknown · Jul 10, 2000
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
TRANSMISSION FAILED, REPAIRED FOUR TIMES, ELECTRICAL SYSTEM, BATTERY FAILED, REPLACED, OZ SENSOR FAILED REPLACE 3 TIMES, FUEL SYSTEM PUMP AND SENSOR REPLACED, FRONT PASSENGER RESTRAINT SYSTEM FAILED
NHTSA ODI #9001677
Mileage unknown · Jul 6, 2000
Visibility
DESIGN DEFECT IN SIDE REARVIEW MIRROR. IT WILL NOT EXTENDED FAR ENOUGH UP AND OUTWARDS, CAUSING POOR VISIBILITY. *AK *ML
NHTSA ODI #864885
Mileage unknown · Mar 1, 2000
Seat Belts
RECALL 99V328000/ SEAT BELT LATCH MECHANISM. CONSUMER HAS BEEN WAITING FOR PARTS FOR OVER A MONTH, AND MANUFACTURER HAS NOT CONTACTED CONSUMER AFTER SEVERAL ATTEMPTS OF CALLS. *AK
MERCEDES-BENZ IS RECALLING CERTAIN MODEL YEAR 1999-2002 M-CLASS AND MODEL YEAR 2000-2003 M-CLASS AMG VEHICLES. THE CRUISE CONTROL SYSTEM IN THE AFFECTED VEHICLES ALLOWS THE DRIVER TO DISENGAGE THE SYSTEM IN A NUMBER OF WAYS, INCLUDING TAPPING THE BRAKE PEDAL, USING THE CRUISE CONTROL STALK, OR BRAKING THE VEHICLE ENOUGH TO REACH A CERTAIN RATE OF DECELERATION. MERCEDES-BENZ HAS DETERMINED THAT UNDER CERTAIN CIRCUMSTANCES USE OF THE BRAKE PEDAL MAY NOT AUTOMATICALLY DISENGAGE CRUISE CONTROL AS EXPECTED BY THE DRIVER, ALTHOUGH THE OTHER MEANS OF DEACTIVATING CRUISE CONTROL REMAIN FULLY OPERATIVE. SPECIFICALLY, WHERE THE DRIVER PUMPS THE BRAKES RATHER THAN APPLYING CONSISTENT PEDAL FORCE, THE LEVEL OF FORCE REQUIRED MAY BE UNUSUALLY HIGH.
Consequence & remedy
Consequence: DIFFICULTY OR DELAY IN DISENGAGING CRUISE CONTROL CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING OCTOBER 2011. OWNERS MAY CONTACT MERCEDES-BENZ AT 1-800-367-6372.
MERCEDES-BENZ IS RECALLING 125,228 MY 1998-2004 M-CLASS VEHICLES. THE HOSE CLAMP USED TO SECURE THE POWER STEERING FLUID COOLING HOSE TO THE POWER STEERING FLUID COOLER MAY NOT PROVIDE SUFFICIENT CLAMPING FORCE FOR THIS CONNECTION.
Consequence & remedy
Consequence: THE LOSS OF POWER STEERING FLUID MAY RESULT IN DIMINISHED POWER STEERING OVER TIME AND ULTIMATELY CAN DAMAGE THE POWER STEERING PUMP. THIS COULD RESULT IN A LOSS OF CONTROL AND A CRASH WITHOUT WARNING.
Remedy: AN EARLIER RECALL REPAIR PERFORMED ON THESE VEHICLES MAY NOT BE SUFFICIENT TO PREVENT A FUTURE LEAKAGE OR FAILURE OF THE POWER STEERING HOSE CONNECTION (PLEASE SEE 03V121). SINCE IT IS NOT POSSIBLE THROUGH INSPECTION TO IDENTIFY SPECIFIC VEHICLES THAT MAY NOT HAVE BEEN PROPERLY REPAIRED, ALL VEHICLES REPAIRED PRIOR TO NOVEMBER 15, 2003, WILL BE REPAIRED AGAIN. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2008. OWNERS MAY CONTACT MERCEDES-BENZ AT 1-800-367-6372.
ON CERTAIN PASSENGER VEHICLES, THE HOSE CLAMP USED TO SECURE THE POWER STEERING FLUID COOLING HOSE TO THE POWER STEERING FLUID COOLER MAY NOT PROVIDE SUFFICIENT CLAMPING FORCE FOR THIS CONNECTION.
Consequence & remedy
Consequence: THE LOSS OF POWER STEERING FLUID MAY RESULT IN DIMINISHED POWER STEERING OVER TIME AND ULTIMATELY CAN DAMAGE THE POWER STEERING PUMP.
Remedy: DEALERS WILL INSTALL A NEW HOSE CLAMP ON THE POWER STEERING HOSE TO THE POWER STEERING COOLER. DURING CLAMP REPLACEMENT, THE POWER STEERING COOLING HOSE WILL BE INSPECTED AND REPLACED AS NECESSARY. OWNER NOTIFICATION BEGAN JUNE 16, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MERCEDES-BENZ AT 1-800-367-6372.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE LATCHING MECHANISM ON THE SEAT BELT ASSEMBLY WAS NOT ASSEMBLED CORRECTLY. IF THE PLASTIC COVER IS LOOSE DURING THE ENGAGEMENT OF THE BUCKLE TONGUE TO THE LATCH MECHANISM, THE BUCKLE COULD UNLATCH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE SEAT BELT BUCKLES. IF EITHER THE DRIVER OR FRONT PASSENGER SEAT BELT BUCKLE IS FOUND TO BE DEFECTIVE, IT WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA08009 · Brake Line Chafe
Opened Apr 28, 2008 · Closed Dec 16, 2009
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ANALYSIS OF COMPLAINTS TO ODI AND MERCEDES AND WARRANTY CLAIM DATA SUBMITTED BY MERCEDES INDICATES THAT THE ALLEGED DEFECT HAS OCCURRED AT A LOW RATE (36.5 COMPLAINTS PER 100,000 VEHICLES AND 0.29 PERCENT WARRANTY CLAIM RATE), WITH NO DISCERNABLE DEFECT TREND INDICATING THAT THE RATE OF CHAFING RELATED BRAKE LINE FAILURES IS INCREASING.THERE HAVE BEEN NO NEW COMPLAINTS SINCE JANUARY 2009.WHEN THE ANALYSIS IS LIMITED TO INCIDENTS OF BRAKE LINE LEAKAGE THAT RESULTED IN ALLEGATIONS OF REDUCED BRAKE EFFECTIVENESS, THE RATE DROPS EVEN FURTHER (22.3 COMPLAINTS PER 100,000 VEHICLES AND 0.04 PERCENT WARRANTY CLAIM RATE). MERCEDES PROVIDED DATA SHOWING THAT IN THE RARE INSTANCES WHEN CHAFING DID PROGRESS TO BRAKE LINE LEAKAGE THE DRIVER WOULD BE IMMEDIATELY ALERTED TO A PROBLEM BY ILLUMINATION OF THE BRIGHT YELLOW ESP/BAS WARNING LAMP AND CHANGES IN BRAKE PEDAL FEEL.CONTINUED OPERATION WITH A LEAKING BRAKE LINE WOULD RESULT IN ILLUMINATION OF THE BRIGHT RED BRAKE WARNING LAMP AND AN AUDIBLE CHIME DUE TO LOW MASTER CYLINDER RESERVOIR LEVEL. CONTINUED OPERATION WITH THE BRAKE WARNING LAMP ILLUMINATED WOULD ULTIMATELY DRAIN THE RESERVOIR FOR THE AFFECTED CIRCUIT, RESULTING IN LOSS OF THE CIRCUIT AND AN APPROXIMATELY 80% INCREASE IN STOPPING DISTANCES. SURVEYS CONDUCTED BY ODI AND VRTC INDICATE THAT ROUTING ANOMALIES MAY BE MORE COMMON THAN THE COMPLAINT AND WARRANTY DATA SUGGEST FOR THE SUBJECT LINE BUNDLE, WITH LINE CONTACT OR OTHER ROUTING ANOMALY NOTED IN 13 OF 51 VEHICLES SURVEYED BY ODI AND VRTC (25.5%).WHILE EVIDENCE OF CONTACT BETWEEN THE FUEL LINE AND SUBJECT BRAKE IN A PARTICULAR VEHICLE IS NOT NECESSARILY PREDICTIVE OF EVENTUAL LINE FAILURE/LEAKAGE, SIGNIFICANT CHAFING WEAR WAS NOTED IN TWO SURVEY VEHICLES (3.9%).TO ADDRESS CONCERNS WITH LINE ROUTING AND ENSURE THAT LINES WITH EVIDENT CHAFING DO NOT PROGRESS TO A LEAK CONDITION, MERCEDES WILL CONDUCT AN OWNER NOTIFICATION PROGRAM INSTRUCTING OWNERS TO BRING THE VEHICLES TO A DEALER FOR A FREE INSPECTION AND REPAIR.LINES THAT DO NOT HAVE A SPACER (RUBBER GROMMET OR OMEGA-CLIP) BETWEEN THE SUBJECT FUEL AND BRAKE LINES WILL HAVE AN OMEGA-CLIP SPACER INSTALLED TO ENSURE ADEQUATE CLEARANCE BETWEEN THE LINES.BRAKE LINES WITH CHAFE MARKS WILL BE REPLACED. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-009 CLOSING REPORT.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ANALYSIS OF COMPLAINTS TO ODI AND MERCEDES AND WARRANTY CLAIM DATA SUBMITTED BY MERCEDES INDICATES THAT THE ALLEGED DEFECT HAS OCCURRED AT A LOW RATE (36.5 COMPLAINTS PER 100,000 VEHICLES AND 0.29 PERCENT WARRANTY CLAIM RATE), WITH NO DISCERNABLE DEFECT TREND INDICATING THAT THE RATE OF CHAFING RELATED BRAKE LINE FAILURES IS INCREASING.THERE HAVE BEEN NO NEW COMPLAINTS SINCE JANUARY 2009.WHEN THE ANALYSIS IS LIMITED TO INCIDENTS OF BRAKE LINE LEAKAGE THAT RESULTED IN ALLEGATIONS OF REDUCED BRAKE EFFECTIVENESS, THE RATE DROPS EVEN FURTHER (22.3 COMPLAINTS PER 100,000 VEHICLES AND 0.04 PERCENT WARRANTY CLAIM RATE). MERCEDES PROVIDED DATA SHOWING THAT IN THE RARE INSTANCES WHEN CHAFING DID PROGRESS TO BRAKE LINE LEAKAGE THE DRIVER WOULD BE IMMEDIATELY ALERTED TO A PROBLEM BY ILLUMINATION OF THE BRIGHT YELLOW ESP/BAS WARNING LAMP AND CHANGES IN BRAKE PEDAL FEEL.CONTINUED OPERATION WITH A LEAKING BRAKE LINE WOULD RESULT IN ILLUMINATION OF THE BRIGHT RED BRAKE WARNING LAMP AND AN AUDIBLE CHIME DUE TO LOW MASTER CYLINDER RESERVOIR LEVEL. CONTINUED OPERATION WITH THE BRAKE WARNING LAMP ILLUMINATED WOULD ULTIMATELY DRAIN THE RESERVOIR FOR THE AFFECTED CIRCUIT, RESULTING IN LOSS OF THE CIRCUIT AND AN APPROXIMATELY 80% INCREASE IN STOPPING DISTANCES. SURVEYS CONDUCTED BY ODI AND VRTC INDICATE THAT ROUTING ANOMALIES MAY BE MORE COMMON THAN THE COMPLAINT AND WARRANTY DATA SUGGEST FOR THE SUBJECT LINE BUNDLE, WITH LINE CONTACT OR OTHER ROUTING ANOMALY NOTED IN 13 OF 51 VEHICLES SURVEYED BY ODI AND VRTC (25.5%).WHILE EVIDENCE OF CONTACT BETWEEN THE FUEL LINE AND SUBJECT BRAKE IN A PARTICULAR VEHICLE IS NOT NECESSARILY PREDICTIVE OF EVENTUAL LINE FAILURE/LEAKAGE, SIGNIFICANT CHAFING WEAR WAS NOTED IN TWO SURVEY VEHICLES (3.9%).TO ADDRESS CONCERNS WITH LINE ROUTING AND ENSURE THAT LINES WITH EVIDENT CHAFING DO NOT PROGRESS TO A LEAK CONDITION, MERCEDES WILL CONDUCT AN OWNER NOTIFICATION PROGRAM INSTRUCTING OWNERS TO BRING THE VEHICLES TO A DEALER FOR A FREE INSPECTION AND REPAIR.LINES THAT DO NOT HAVE A SPACER (RUBBER GROMMET OR OMEGA-CLIP) BETWEEN THE SUBJECT FUEL AND BRAKE LINES WILL HAVE AN OMEGA-CLIP SPACER INSTALLED TO ENSURE ADEQUATE CLEARANCE BETWEEN THE LINES.BRAKE LINES WITH CHAFE MARKS WILL BE REPLACED. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-009 CLOSING REPORT.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ANALYSIS OF COMPLAINTS TO ODI AND MERCEDES AND WARRANTY CLAIM DATA SUBMITTED BY MERCEDES INDICATES THAT THE ALLEGED DEFECT HAS OCCURRED AT A LOW RATE (36.5 COMPLAINTS PER 100,000 VEHICLES AND 0.29 PERCENT WARRANTY CLAIM RATE), WITH NO DISCERNABLE DEFECT TREND INDICATING THAT THE RATE OF CHAFING RELATED BRAKE LINE FAILURES IS INCREASING.THERE HAVE BEEN NO NEW COMPLAINTS SINCE JANUARY 2009.WHEN THE ANALYSIS IS LIMITED TO INCIDENTS OF BRAKE LINE LEAKAGE THAT RESULTED IN ALLEGATIONS OF REDUCED BRAKE EFFECTIVENESS, THE RATE DROPS EVEN FURTHER (22.3 COMPLAINTS PER 100,000 VEHICLES AND 0.04 PERCENT WARRANTY CLAIM RATE). MERCEDES PROVIDED DATA SHOWING THAT IN THE RARE INSTANCES WHEN CHAFING DID PROGRESS TO BRAKE LINE LEAKAGE THE DRIVER WOULD BE IMMEDIATELY ALERTED TO A PROBLEM BY ILLUMINATION OF THE BRIGHT YELLOW ESP/BAS WARNING LAMP AND CHANGES IN BRAKE PEDAL FEEL.CONTINUED OPERATION WITH A LEAKING BRAKE LINE WOULD RESULT IN ILLUMINATION OF THE BRIGHT RED BRAKE WARNING LAMP AND AN AUDIBLE CHIME DUE TO LOW MASTER CYLINDER RESERVOIR LEVEL. CONTINUED OPERATION WITH THE BRAKE WARNING LAMP ILLUMINATED WOULD ULTIMATELY DRAIN THE RESERVOIR FOR THE AFFECTED CIRCUIT, RESULTING IN LOSS OF THE CIRCUIT AND AN APPROXIMATELY 80% INCREASE IN STOPPING DISTANCES. SURVEYS CONDUCTED BY ODI AND VRTC INDICATE THAT ROUTING ANOMALIES MAY BE MORE COMMON THAN THE COMPLAINT AND WARRANTY DATA SUGGEST FOR THE SUBJECT LINE BUNDLE, WITH LINE CONTACT OR OTHER ROUTING ANOMALY NOTED IN 13 OF 51 VEHICLES SURVEYED BY ODI AND VRTC (25.5%).WHILE EVIDENCE OF CONTACT BETWEEN THE FUEL LINE AND SUBJECT BRAKE IN A PARTICULAR VEHICLE IS NOT NECESSARILY PREDICTIVE OF EVENTUAL LINE FAILURE/LEAKAGE, SIGNIFICANT CHAFING WEAR WAS NOTED IN TWO SURVEY VEHICLES (3.9%).TO ADDRESS CONCERNS WITH LINE ROUTING AND ENSURE THAT LINES WITH EVIDENT CHAFING DO NOT PROGRESS TO A LEAK CONDITION, MERCEDES WILL CONDUCT AN OWNER NOTIFICATION PROGRAM INSTRUCTING OWNERS TO BRING THE VEHICLES TO A DEALER FOR A FREE INSPECTION AND REPAIR.LINES THAT DO NOT HAVE A SPACER (RUBBER GROMMET OR OMEGA-CLIP) BETWEEN THE SUBJECT FUEL AND BRAKE LINES WILL HAVE AN OMEGA-CLIP SPACER INSTALLED TO ENSURE ADEQUATE CLEARANCE BETWEEN THE LINES.BRAKE LINES WITH CHAFE MARKS WILL BE REPLACED. ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FOR ADDITIONAL INFORMATION REGARDING THIS ENGINEERING ANALYSIS REFER TO THE EA08-009 CLOSING REPORT.
RQ08002 · Power Steering Hose Leak
Opened Mar 11, 2008 · Closed Sep 17, 2008
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
MERCEDES-BENZ USA (MBUSA) WILL NOTIFY CERTAIN MODEL YEAR (MY) 1998 THROUGH 2003 M-CLASS OWNERS OF THE NEED TO BRING THEIR VEHICLES INTO DEALERS TO ADDRESS THE ISSUE PREVIOUSLY CAMPAIGNED UNDER MBUSA RECALL 2003-040005 (NHTSA RECALL 03V-121).THE MBUSA CAMPAIGN, WHICH ODI IS DESIGNATING RECALL 08V-465, WILL REPLACE THE POWER STEERING COOLER HOSE AND CLAMP IN ALL VEHICLES THAT RECEIVED THE ORIGINAL RECALL REMEDY FOR 03V-121 AND WHICH HAVEN'T RECEIVED A SUBSEQUENT REPAIR TO INSTALL A REVISED HOSE AND CLAMP.APPROXIMATELY ONE-THIRD OF THE VEHICLES THAT RECEIVED THE ORIGINAL REPAIR PROCEDURE AND PARTS RETURNED FOR SUBSEQUENT SERVICE FOR LEAKAGE FROM THE HOSE FITTING AND, IN APPROXIMATELY 10 PERCENT OF THESE VEHICLES, COMPLETE SEPARATION OF THE HOSE FROM THE COOLER.A REVISED SERVICE PROCEDURE FOR 03V-121, WHICH INVOLVED REPLACING THE OLD HOSE AND CLAMP WITH MODIFIED PARTS, HAD SIGNIFICANTLY LOWER RATES OF RETURN REPAIRS.MBUSA WILL APPLY THE REVISED SERVICE PROCEDURE FROM 03V-121 TO THE VEHICLES COVERED UNDER 08V-465.ACCORDINGLY THIS RECALL QUERY IS CLOSED.
Additional source detail variants (3)
Steering:hydraulic Power Assist:hose, Piping, And Connections
MERCEDES-BENZ USA (MBUSA) WILL NOTIFY CERTAIN MODEL YEAR (MY) 1998 THROUGH 2003 M-CLASS OWNERS OF THE NEED TO BRING THEIR VEHICLES INTO DEALERS TO ADDRESS THE ISSUE PREVIOUSLY CAMPAIGNED UNDER MBUSA RECALL 2003-040005 (NHTSA RECALL 03V-121).THE MBUSA CAMPAIGN, WHICH ODI IS DESIGNATING RECALL 08V-465, WILL REPLACE THE POWER STEERING COOLER HOSE AND CLAMP IN ALL VEHICLES THAT RECEIVED THE ORIGINAL RECALL REMEDY FOR 03V-121 AND WHICH HAVEN'T RECEIVED A SUBSEQUENT REPAIR TO INSTALL A REVISED HOSE AND CLAMP.APPROXIMATELY ONE-THIRD OF THE VEHICLES THAT RECEIVED THE ORIGINAL REPAIR PROCEDURE AND PARTS RETURNED FOR SUBSEQUENT SERVICE FOR LEAKAGE FROM THE HOSE FITTING AND, IN APPROXIMATELY 10 PERCENT OF THESE VEHICLES, COMPLETE SEPARATION OF THE HOSE FROM THE COOLER.A REVISED SERVICE PROCEDURE FOR 03V-121, WHICH INVOLVED REPLACING THE OLD HOSE AND CLAMP WITH MODIFIED PARTS, HAD SIGNIFICANTLY LOWER RATES OF RETURN REPAIRS.MBUSA WILL APPLY THE REVISED SERVICE PROCEDURE FROM 03V-121 TO THE VEHICLES COVERED UNDER 08V-465.ACCORDINGLY THIS RECALL QUERY IS CLOSED.
Steering:hydraulic Power Assist:power Steering Fluid
MERCEDES-BENZ USA (MBUSA) WILL NOTIFY CERTAIN MODEL YEAR (MY) 1998 THROUGH 2003 M-CLASS OWNERS OF THE NEED TO BRING THEIR VEHICLES INTO DEALERS TO ADDRESS THE ISSUE PREVIOUSLY CAMPAIGNED UNDER MBUSA RECALL 2003-040005 (NHTSA RECALL 03V-121).THE MBUSA CAMPAIGN, WHICH ODI IS DESIGNATING RECALL 08V-465, WILL REPLACE THE POWER STEERING COOLER HOSE AND CLAMP IN ALL VEHICLES THAT RECEIVED THE ORIGINAL RECALL REMEDY FOR 03V-121 AND WHICH HAVEN'T RECEIVED A SUBSEQUENT REPAIR TO INSTALL A REVISED HOSE AND CLAMP.APPROXIMATELY ONE-THIRD OF THE VEHICLES THAT RECEIVED THE ORIGINAL REPAIR PROCEDURE AND PARTS RETURNED FOR SUBSEQUENT SERVICE FOR LEAKAGE FROM THE HOSE FITTING AND, IN APPROXIMATELY 10 PERCENT OF THESE VEHICLES, COMPLETE SEPARATION OF THE HOSE FROM THE COOLER.A REVISED SERVICE PROCEDURE FOR 03V-121, WHICH INVOLVED REPLACING THE OLD HOSE AND CLAMP WITH MODIFIED PARTS, HAD SIGNIFICANTLY LOWER RATES OF RETURN REPAIRS.MBUSA WILL APPLY THE REVISED SERVICE PROCEDURE FROM 03V-121 TO THE VEHICLES COVERED UNDER 08V-465.ACCORDINGLY THIS RECALL QUERY IS CLOSED.
Steering:hydraulic Power Assist System
MERCEDES-BENZ USA (MBUSA) WILL NOTIFY CERTAIN MODEL YEAR (MY) 1998 THROUGH 2003 M-CLASS OWNERS OF THE NEED TO BRING THEIR VEHICLES INTO DEALERS TO ADDRESS THE ISSUE PREVIOUSLY CAMPAIGNED UNDER MBUSA RECALL 2003-040005 (NHTSA RECALL 03V-121).THE MBUSA CAMPAIGN, WHICH ODI IS DESIGNATING RECALL 08V-465, WILL REPLACE THE POWER STEERING COOLER HOSE AND CLAMP IN ALL VEHICLES THAT RECEIVED THE ORIGINAL RECALL REMEDY FOR 03V-121 AND WHICH HAVEN'T RECEIVED A SUBSEQUENT REPAIR TO INSTALL A REVISED HOSE AND CLAMP.APPROXIMATELY ONE-THIRD OF THE VEHICLES THAT RECEIVED THE ORIGINAL REPAIR PROCEDURE AND PARTS RETURNED FOR SUBSEQUENT SERVICE FOR LEAKAGE FROM THE HOSE FITTING AND, IN APPROXIMATELY 10 PERCENT OF THESE VEHICLES, COMPLETE SEPARATION OF THE HOSE FROM THE COOLER.A REVISED SERVICE PROCEDURE FOR 03V-121, WHICH INVOLVED REPLACING THE OLD HOSE AND CLAMP WITH MODIFIED PARTS, HAD SIGNIFICANTLY LOWER RATES OF RETURN REPAIRS.MBUSA WILL APPLY THE REVISED SERVICE PROCEDURE FROM 03V-121 TO THE VEHICLES COVERED UNDER 08V-465.ACCORDINGLY THIS RECALL QUERY IS CLOSED.
PE03058 · Engine Crankshaft Pulley Failure
Opened Dec 17, 2003 · Closed Apr 22, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF ENGINE CRANKSHAFT PULLEY HARMONIC BALANCER FAILURE THAT COULD RESULT IN LOSS OF POWER-STEERING ASSIST.ODI HAS RECEIVED A TOTAL OF 546 NON-DUPLICATIVE REPORTS THAT ALLEGE ENGINE CRANKSHAFT PULLEY HARMONIC BALANCER FAILURE ON ALL MERCEDES-BENZ VEHICLES USING THE SUBJECT COMPONENT.THE SUBJECT COMPONENT FAILURES ARE PROGRESSIVE IN NATURE AND ONLY A SMALL PERCENTAGE OF THE COMPLAINTS AND WARRANT CLAIMS INVOLVED A FAILURE THAT HAD PROGRESSED FAR ENOUGH TO EFFECT POWER STEERING PERFORMANCE (6 OF 55 ODI COMPLAINTS REFERENCE INCREASED STEERING EFFORT).THERE HAVE BEEN NO CRASHES OR INJURIES RELATED TO THE ALLEGED DEFECT.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT ATTACHED FOR FURTHER DETAIL.
1999 Mercedes Benz M Class Problems, Complaints & Recalls | Skip That Year
Illustration