IllustrationVERY STRONG SMELL OF FUEL, EXTERIOR REAR LEFT SIDE. FOUND FUEL LEAK, LEFT REAR OF VEHICLE, DRIPPING HEAVY UNDERNEATH. TOOK VEHICLE TO A EUROPEAN CAR SHOP, MECHANIC REPLACED FUEL SEAL OF FUEL PUMP UNDER REAR SEAT. MECHANIC REMOVED LARGE AMOUNT OF FUEL FROM THE AFFECTED AREA (LEAK UNDER REAR SEAT). *TR
2004 Mercedes Benz E500
Owner reports · Recalls · Investigations
More warning signs than most E500 years
Owner complaints for the 2004 Mercedes Benz E500 are substantially higher than the model-year median of 50.
About this comparison →How this year compares
Owner complaints by model year
Compare all E500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
1225–50K
2450–75K
2975–100K
43100–150K
12150K+
127 reports with mileage · 15 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports2 fire reports2 injury reports
Fuel/propulsion System complaints
56 reportsA STRONG GAS SMELL IN THE PASSENGER CABIN AS WELL AS OUTSIDE DRIVER SIDE PASSENGER DOOR AND THE CHECK ENGINE LIGHT PROMPTED ME TO TAKE THE CAR TO A LOCAL DEALER. AFTER DIAGNOSTIC TEST, DEALER INDICATED THERE WAS A LEAKING FUEL PURGE VALVE AND SHUT OFF VALVE. AFTER A $1,600 QUOTE, I REQUESTED THEY NOT DO THE WORK SO I COULD TAK…
Read full complaint
A STRONG GAS SMELL IN THE PASSENGER CABIN AS WELL AS OUTSIDE DRIVER SIDE PASSENGER DOOR AND THE CHECK ENGINE LIGHT PROMPTED ME TO TAKE THE CAR TO A LOCAL DEALER. AFTER DIAGNOSTIC TEST, DEALER INDICATED THERE WAS A LEAKING FUEL PURGE VALVE AND SHUT OFF VALVE. AFTER A $1,600 QUOTE, I REQUESTED THEY NOT DO THE WORK SO I COULD TAKE IT FOR A SECOND OPINION. WAS CALLED BACK LATER THAT DAY AND INFORMED OF A "MISCOMMUNICATION" AND THAT THE CAR WAS FIXED WITH A $1,600 BILL AWAITING ME. I WORKED OUT A PAYMENT AGREEMENT WITH THE DEALER AND NEVER TOOK THE CAR BACK DESPITE INTERMITTENT GAS SMELLS IN AND OUTSIDE THE CAR AND CHECK ENGINE LIGHT GOING ON AND OFF. THE CHECK ENGINE LIGHT CAME BACK ON FOR GOOD LESS THAN 12 MONTHS LATER. TOOK CAR TO ANOTHER LOCAL SHOP WHERE I WAS TOLD ONE OF THE FUEL PUMPS NEEDED TO BE REPLACED. $600 LATER, AND 4 MORE TRIPS BACK TO THE SHOP, THE CHECK ENGINE LIGHT AND STRONG GAS FUMES STILL PERMEATE THE CAR. TOOK IT TO SHOP #3 TODAY AND WAS TOLD THERE IS A CRACK IN THE FUEL TANK. THE QUOTE IS $1,700. I DON'T TRUST THE DEALER, AND BELIEVE THAT THE FUEL PUMP REPLACE BY SHOP #2 WAS NOT THE ISSUE. IT APPEARS AS IF IT'S BEEN THE FUEL TANK ALL ALONG. THIS IS CLEARLY A DEFECT IN THE PART AS THE CAR HAS NEVER BEEN IN AN ACCIDENT AND HAS LESS THAN 70K MILES ON IT CURRENTLY. IT'S A SAFETY HAZARD AND WITH TWO CHILDREN, I DON'T HAVE A CHOICE BUT TO FIX THE PROBLEM. PLEASE LET ME KNOW IF THERE IS ANYTHING ADDITIONAL NECESSARY TO HELP CONCLUDE THIS INVESTIGATION. I'M HOPING THERE WILL BE RECOURSE WITH MBUSA TO REIMBURSE IT'S CUSTOMERS FOR THE FAULTY PART REPLACEMENT AND LABOR COSTS. THANK YOU. *TR
WE PURCHASED THIS VEHICLE RECENTLY FROM A PRIVATE SELLER. THE FIRST TIME WE FILLED UP THE TANK, WE NOTICED A VERY STRONG GASOLINE ODOR. I CALLED THE SELLER AND HE TOLD ME THAT THE ONLY WAY TO AVOID THAT IS BY NOT TOPPING OFF THE TANK. I FIGURED THIS WASN'T NORMAL, SO I STARTED DOING SOME RESEARCH. TURNS OUT MERCEDES E CLASS V…
Read full complaint
WE PURCHASED THIS VEHICLE RECENTLY FROM A PRIVATE SELLER. THE FIRST TIME WE FILLED UP THE TANK, WE NOTICED A VERY STRONG GASOLINE ODOR. I CALLED THE SELLER AND HE TOLD ME THAT THE ONLY WAY TO AVOID THAT IS BY NOT TOPPING OFF THE TANK. I FIGURED THIS WASN'T NORMAL, SO I STARTED DOING SOME RESEARCH. TURNS OUT MERCEDES E CLASS VEHICLES HAVE A PROBLEM WITH THE FUEL SEAL. IN FACT, THERE WAS A RECALL FOR THIS PROBLEM, BUT THE LOCAL MERCEDES DEALER DOES NOT WANT TO HONOR IT BECAUSE THEY SAY IT IS ONLY FOR THE AMG MODELS. BUT MY MODEL HAS THE SAME PROBLEM. THEN, UPON FURTHER INVESTIGATION, I FOUND THAT A CLASS ACTION LAWSUIT AGAINST MERCEDES WAS BEING FILED THIS YEAR FOR THE SAME EXACT ISSUE CONCERNING E CLASS VEHICLES FROM 2003-2009. *TR
UPON FILLING UP THE CAR EMITS A STRONG GAS SMELL. THE GAS SMELL CONTINUES TO BE PRESENT ALL THE TIME EVEN WHEN THE CAR IS PARKED AND NOT TURNED ON. *TR
EVERYTIME I FILL MY FUEL TANK I'VE NOTICED A STRONG FUEL ODOR. UPON INSPECTION I HAVE FOUND THE FUEL TANK TO HAVE TRACES OF FUEL ON THE EXTERIOR OF TANK, SO MY TANK HAS A LEAK SOMEWHERE. *TR
CAR WAS NOT MOVING WHEN WE NOTICED A STRONG ODOR OF GASOLINE COMING FROM THE REAR SEAT AREA, WHEN WE PULLED INTO OUR GARAGE THE ODOR WAS SO STRONG WE MOVED THE CAR TO THE OUTSIDE TO PREVENT A POSSIBLE FIRE IN OUR HOME, I CALLED THE DEALER AND THE SERVICE MANAGER IMMEDIATELY TOLD ME THAT HE THOUGHT THE GAS TANK SENDER/SENSOR WAS …
Read full complaint
CAR WAS NOT MOVING WHEN WE NOTICED A STRONG ODOR OF GASOLINE COMING FROM THE REAR SEAT AREA, WHEN WE PULLED INTO OUR GARAGE THE ODOR WAS SO STRONG WE MOVED THE CAR TO THE OUTSIDE TO PREVENT A POSSIBLE FIRE IN OUR HOME, I CALLED THE DEALER AND THE SERVICE MANAGER IMMEDIATELY TOLD ME THAT HE THOUGHT THE GAS TANK SENDER/SENSOR WAS LEAKING AND POSSIBLY THAT BOTH SENSORS WERE LEAKING AND POSSIBLY THE TANK. HE ALSO TOLD ME THAT GASOLINE COULD BE POOLING ON TOP OF THE GAS TANK CAUSING THE ODOR. HE LATER CALLED ME AND CONFIRMED THAT ALL OF THE ABOVE HAD HAPPENED AND COULD BE REPAIRED FOR APPROXIMATELY $3250.00 I ASK IF THIS WAS A RECURRING PROBLEM ON THIS MODEL HE SAID THAT THERE WERE NO RECALLS OR WARNING BUT THEY HAD SEEN THIS PROBLEM BEFORE. I THEN WENT ON LINE AND FOUND A LOT OF BLOGS DESCRIBING MY PROBLEM ALMOST IDENTICALLY. IN MY OPINION THIS IS A SERIOUS DEFECT IN THE CONSTRUCTION OF THIS CAR AND COULD AND PROBABLY WILL CAUSE SERIOUS INJURY AND POSSIBLY DEATH TO SOME ONE RIDING IN THIS MODEL. I BELIEVE THERE IS ENOUGH EVIDENCE IN THE RECURRING BLOGS THAT MERCEDES IS QUITE AWARE OF THIS SERIOUS SAFETY PROBLEM AND ARE PROBABLY IGNORING THIS VERY EXPENSIVE FIX, PLEASE DO NOT IGNORE THIS COMPLAINT UNTIL SOMEONE OR SEVERAL ARE HURT OR KILLED. *TR
I OWN 2004 MERCEDES E500 4MATIC ONE DAY AFTER FILLING GAS TANK WITH FUEL NOTICE STRONG SMELL CAME FROM DRIVER REAR SIDE OF THE CAR. I DROVE TO MY GARAGE AND INVESTIGATE THIS PROBLEM. THE SENDING FUEL UNIT LOCATED UNDER REAR SEAT DRIVERS SIDE HAS A CRACK FROM WHICH FUEL LEAKING OUT. CALLED TO MERCEDES BENZ OF USA SEVERAL TIMES…
Read full complaint
I OWN 2004 MERCEDES E500 4MATIC ONE DAY AFTER FILLING GAS TANK WITH FUEL NOTICE STRONG SMELL CAME FROM DRIVER REAR SIDE OF THE CAR. I DROVE TO MY GARAGE AND INVESTIGATE THIS PROBLEM. THE SENDING FUEL UNIT LOCATED UNDER REAR SEAT DRIVERS SIDE HAS A CRACK FROM WHICH FUEL LEAKING OUT. CALLED TO MERCEDES BENZ OF USA SEVERAL TIMES, BUT THEY REFUSED FIX THIS PROBLEM. THIS IS THE SERIOUS SAFETY ISSUE. *TR
CRACKED FUEL FILTER MODULE WITH LEAKING FUEL UNDER LEFT BACK SEAT. *TR
TL* THE CONTACT OWNS A 2004 MERCEDES BENZ E500. THE CONTACT STATED THAT HE SMELLED AN OVERPOWERING ODOR OF GASOLINE FUMES IN THE CABIN OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS BUT THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS AND OFFERED NO ASSISTANCE. THE MANUFACTURER WAS NOTI…
Read full complaint
TL* THE CONTACT OWNS A 2004 MERCEDES BENZ E500. THE CONTACT STATED THAT HE SMELLED AN OVERPOWERING ODOR OF GASOLINE FUMES IN THE CABIN OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS BUT THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS AND OFFERED NO ASSISTANCE. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE VEHICLE HAD BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 225,000. UPDATED 11/1/12 *CN UPDATED 11/13/2012 *JS
THE VEHICLE HAS THE SMELL OF GAS VENTING INTO THE PASSENGER COMPARTMENT AND CONCERNED FOR PASSENGER SAFETY. CURRENTLY THE VEHICLE IS NOT PROPERLY MEETING OR COMPLYING WITH EPA REGULATIONS CONCERNING PROPER EMISSIONS OF FUEL VENTILATION AND HAS GROSS PRODUCT SAFETY ISSUE CONCERNING PASSENGER(S) INSIDE THE VEHICLE. THE FUELING…
Read full complaint
THE VEHICLE HAS THE SMELL OF GAS VENTING INTO THE PASSENGER COMPARTMENT AND CONCERNED FOR PASSENGER SAFETY. CURRENTLY THE VEHICLE IS NOT PROPERLY MEETING OR COMPLYING WITH EPA REGULATIONS CONCERNING PROPER EMISSIONS OF FUEL VENTILATION AND HAS GROSS PRODUCT SAFETY ISSUE CONCERNING PASSENGER(S) INSIDE THE VEHICLE. THE FUELING SYSTEM IS VENTING IMPROPERLY AND FUEL SENDER IS NOT SEALED PROPERLY. CAR HAS NEVER HAD PROBLEM UNTIL CURRENT DATE OF FILING. AWARE OF CURRENT MERCEDES CORPORATE LEGAL RESPONSE TO YOUR ENQUIRE HOWEVER THE SYSTEM HAS NEVER BEEN WORKED ON (BY MERCEDES DEALER) NOR IS THIS JUST A MINOR ISSUE WITH LOW VEHICLE COUNT. PLEASE PROTECT ME AND MY FAMILY CONCERNING THIS ISSUE! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Official recalls
324V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
22V954000 · Visibility:sun/moon Roof Assembly
Dec 23, 2022
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please refer to MBUSA's recall report for specific vehicle model details. The glass sunroof panel may not be properly secured and may detach.
Consequence & remedy
Consequence: A detached sunroof panel may become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary free of charge. Owner notification letters were mailed February 3, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. This recall expands NHTSA recall number 19V-918. MBUSA's numbers for this recall are 2023010004, 2023010005, and 2023010006.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un