2003 Mercedes Benz C230

I HAVE 2003 MERCEDES BENZ C230. WHENEVER I WOULD START THE VEHICLE IT WOULD GIVE ME JERK OR MAKE NOISE AND FINALLY JUST BEFORE TAKING IT TO A DEALER IT STALLED. I HAD IT TOWED. THE VEHICLE WAS TAKEN TO A LOCAL SHOP, WHICH SUGGESTED THAT THE PROBLEM IS MUCH LARGER AND NEEDS THE ATTENTION OF THE MANUFACTURER AND HENCE TO TAKEN TO THE DEALER. IT WAS DIAGNOSED AS THE TIMING CHAIN WAS DEFECTIVE AND THE LOCAL SHOP OWNER SAID THIS WAS A COMMON PROBLEM WITH THIS VEHICLE AND A SERIOUS PROBLEM WITH MAJOR COST TO FIX. THE MANUFACTURER WAS CONTACTED WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE IS NOT REPAIRED AS THE COST OF FIX IS AS LARGE AS THE CARS CURRENT VALUE. THE FAILURE AND CURRENT MILEAGE IS 68,000. *TR

TL* THE CONTACT OWNS A 2003 MERCEDES BENZ C230. THE CONTACT STATED THAT WHENEVER SHE WOULD START THE VEHICLE, IT WOULD JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE CAM SHAFT SENSOR WAS LEAKING AND THE TIMING CHAIN WAS DEFECTIVE. THE MANUFACTURER WAS CONTACTED WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 92,000.

LEAK ON THE ANTIFREEZE COOLANT TANK WHERE THE THIN HOSE CONNECTS TO THE COOLANT TANK ON TOP, THE STEEL TUBE THAT IS MOLDED INTO THE PLASTIC SLIPPED OUT AND THE PLASTIC PART CRACKED CREATING A LEAK. THE ANTIFREEZE MAY LEAK AND ACCUMULATE UNDER THE CAR, IT CAN DAMAGE THE ENGINE, ALSO IT CAN LEAK WHILE DRIVING CAUSING HAZARDOUS / SLIPPERY CONDITIONS, ALSO CHILDREN OR PETS / ANIMALS MAY DRINK THE LEAKED ANTIFREEZE. THIS IS DANGEROUS. *TR

THE CAM SENSORS ON THE MERCEDES M271 ENGINE LEAK OIL WHICH SPREADS TO OTHER COMPONENTS VIA THE WIRE HARNESSES CONNECTED TO CAM SENSORS. OIL CONTAMINATION WILL DAMAGE OTHER ELECTRICAL COMPONENTS (NAMELY THE ECU AND EXHAUST OXYGEN SENSORS) IF THE CAM SENSORS AND WIRE HARNESSES ARE NOT REPLACED. A NEW CAM SENSOR AND WIRE HARNESS HAS BEEN DESIGNED AS THE CORRECTIVE ACTION. THE DEFECTIVE CAM SENSOR AND WIRE HARNESS WERE USED ON THE PREVIOUS ENGINE DESIGN (M111). THERE IS A TECHNICAL SERVICE BULLETIN FOR M111 ENGINE BUT NOT THE M271 ENGINE. MERCEDES REFUSES TO RECALL THIS DEFECTIVE DESIGN ON THE M271 ENGINE CAUSING OWNERS TO PAY FOR THE $900 PREVENTATIVE MAINTENANCE. WITHOUT THIS REPAIR THE ECU (PART COST $2000) AND OXYGEN SENSORS (QTY 2 @ $238 EA) WILL BE EVENTUALLY DAMAGED AND WILL NEED TO BE REMOVED AND REPLACED. WITHIN THE PAST WEEK, PAID MORE THAN $ 2,400.00 TO REPLACE 2 CAM SENSORS, 2 OXYGEN SENSORS, AND WIRING HARNESS. REPAIR SHOP SAYS THAT THIS IS A DEFECT THAT MB HAS KNOWN ABOUT FOR YEARS. *TR

1. THE HEADLIGHT CANNOT BE TURN ON AS I DROVE INTO A 1-MILE DARK TUNNEL IN US WEST. 2. IT PERSISTS FOR ABOUT 1-DAYS DURING A TRIP TO THE US WEST IN THE DRY HEAT ENVIRONMENT. AFTER THAT, THE HEADLIGHT WORK NORMAL AGAIN AS I CAME BACK TO CALIFORNIA. 3. NOTHING HAS BEING DONE SINCE THEN SINCE I WILL PROBABLY NOT DRIVE TO US WEST IN THE VISIBLE NEAR FUTURE. THE OLD PARTS ARE STILL AVAILABLE IN MY CAR. *TR

TL*THE CONTACT OWNS A 2003 MERCEDES BENZ C230. THE CONTACT STATED THAT HE WAS DRIVING APPROXIMATELY 30 MPH WHEN HE CRASHED INTO A TREE THAT HAD FALLEN IN THE STREET. THE AIR BAGS DID NOT DEPLOY AND HE SUFFERED FOUR BROKEN BONES AS A RESULT; THE VEHICLE WAS ALSO DESTROYED. HE WAS TOLD BY THE MANUFACTURER THAT THE SECONDARY THRESHOLDS WERE NOT EXCEEDED TO DEPLOY THE AIR BAGS. AN INDEPENDENT INSPECTOR STATED THAT THE AIR BAGS SHOULD HAVE DEPLOYED. THE VEHICLE IDENTIFICATION NUMBER WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 120,000. UPDATED 3/24/10 *CN UPDATED 06/11/10.*JB

C230K COUPE AT 73,000 MILES WITH SUDDEN VALVE GUIDES WORN BAD CYLINDER,COMPRESSION LOSS RECENTLY IN APRIL I WAS CALLED INTO MBZ FOR A RECALL ON A VACUUM HOSE, HERE I AM A FEW MONTHS LATER AND I'M DRIVING AND MY CAR STARTS SHAKING ,IDLING STRANGE AND THEN I TAKE IT TO A MECHANIC AND HE FIGURED IT AT FIRST GLANCE IT MAY BE WORN VALVE GASKET SEALS AND I SAID OK LET'S CHANGE THEM AND PUT IN NEW PLUGS TOO...THEN HE CHECKS THE COMPRESSION AND DISCOVERS THAT IT IS HALF OF WHAT IT SHOULD BE, WHAT? WHY SHOULD THE CYLINDER HEADS BE WORN AND NEED TO BE REPLACED FOR NEARLY $3000, ...THIS SEEMS TO BE HAPPENING TOO MANY OWNERS OF THIS MODEL ON HERE AND MBZFORUMS FOR THIS 2003-2005 YEARS. LOSS OF COMPRESSION IN ONE OR MORE CYLINDERS. THIS SHOULD BE RECOGNIZED BY MBZ AS A DEFECT AND SINCE WHEN DO THESE ENGINES FAIL AT 50,000OR EVEN 80,000? I FEEL THIS SHOULD BE PAID FOR BY THEM, THIS IS RIDICULOUS AND SHOULD NOT BE HAPPENING AT THIS MILEAGE!! DEFECT,FLAW IN DESIGN...THEY NEED TO STEP UP AND ADMIT IT AT MERCEDES HEADQUARTERS. PLEASE HELP US OWNERS , THEY ARE GETTING AWAY WITH THIS, MENTIONING VACUUM HOSE RECALLS ON THIS 2003 YEAR BUT SOME DEALERS HAVE RECOGNIZED THAT THESE ENGINES ARE DEFECTIVE AND A RECALL NEEDS TO BE DONE ON THESE VALVE GUIDES/CYLINDER HEADS. WHY IS IT THAT THERE IS AN INCONSISTENCY ON HOW THIS PROBLEM IS RECOGNIZED BY THE DEALER AND HANDLED. SOME ON THE FORUMS HAVE SAID THAT THE DEALER SCREWED THEM IF THE 50,000 WARRANTY IS OVER AND OTHERS HAVE HAD THE PARTS ONLY PAID FOR BY THE DEALER AND OTHERS HAVE HAD THE WHOLE THING PAID!! TOO MANY OF THESE C230K ENGINE CYLINDERS/VALVE GUIDES ARE GOING BAD, THEY ARE DEFECTIVE AND MBZ SHOULD BE CORRECTING THIS. I SHOULD NOT PAY $3000 TO REBUILD ENGINE THAT HAS BEEN MAINTAINED ON SCHEDULE AND FOR A CAR THAT IS AT ONLY 73,000 MILES THANKS *TR

JUST LIKE OTHER REPORTS HERE - ELECTRICAL MALFUNCTION. 50K MILES. TOOK TO MB DEALER FOR ROUGH IDLE AT COLD START UP AND LOW SPEEDS; LOUDER THAN NORMAL IDLE AT START AND IN REVERSE. NO CHECK ENGINE LIGHT, NO ERROR OR PROBLEM INDICATED IN DASH AT ALL. SAME DIAGNOSIS - DEALER REPORTED CAM SOLENOIDS LEAKING ENGINE OIL INTO THE WIRING HARNESS SHORTING HARNESS COMPONENTS (O2 SENSORS ETC.), HIGH $$$ $3600-$4000 REPAIR. ISSUE SHOULD BE RESOLVED AND PAID FOR BY MB SINCE THIS IS KNOWN DEFECT THAT SEVERELY REDUCES THE DRIVE-ABILITY AND VALUE OF THE VEHICLE. *TR