2005 Mazda Tribute

PASSENGER SIDE WHEEL WELL INCLUDING STRUT FOR TOP OF SHOCK ABSORBER RUSTED CAUSING A DANGEROUS CONDITION. IN THE 10 YRS I OWNED THIS CAR, NO IMPENDING FAILURE OF THAT AREA WAS DETECTED IN ALL ANNUAL AND OTHER INSPECTIONS.WHILE DRIVING IN HEAVY TRUCK TRAFFIC ON I87 (PA) I HEARD A LOUD EXPLOSION, SMELLED BURNING RUBBER, AND TEMPORARILY LOST CONTROL OF MY VEHICLE. I MANEUVERED TO THE SIDE OF THE HIGHWAY, EXAMINED THE REAR PASSENGER TIRE AND WAS ABLE TO REMOVE AND BEND PIECES OF METAL THAT WERE RUBBING ON THE TIRE. THIS IS APPARENTLY A WELL-KNOWN PROBLEM WITH TRIBUTES AND FORD ESCAPES (2001-?) AND HAS BEEN REPORTED TO THOSE COMPANIES MULTIPLE TIMES. I WAS ABLE TO CAUTIOUSLY PROCEED DRIVING WITH VEHICLE TO MY DESTINATION. THE CAR IS UNSTABLE WHILE MAKING TURNS, ESPECIALLY IF THE ROAD CAUSES THE RIGHT REAR TIRE TO BOUNCE. NONE OF THE RECALL NOTICES I RECEIVED SINCE BUYING THIS CAR IN 2007 HAVE EVER MENTIONED RIGHT REAR RUST PROBLEMS. IF I HAD BEEN NOTIFIED OF THIS IMPENDING DANGEROUS CONDITION I WOULD HAVE TAKEN STEPS TO PREVENT IT. DOES SOMEONE HAVE TO BE SERIOUSLY INJURED OR KILLED BEFORE MAZDA AND FORD DO THE RIGHT THING TO CORRECT THE OBVIOUS MANUFACTURING DEFECT IN 2001-PRESENT (?) TRIBUTES AND ESCAPES?

ON JULY 12, 2017 WHILE DRIVING MY CAR TO WORK I NOTICED SEVERAL LOUD THUMPS COMING FROM THE BACK OF MY CAR. I STOPPED AT THE GAS STATION TO SEE WHERE THE NOISE WAS COMING FROM AND NOTICED THAT MY RIGHT WEAR WHEEL WELL HAD RUSTED OUT. I WALKED OVER TO THE LEFT SIDE AND NOTICED NO EROSION OR RUST. I TOOK MY CAR TO THE TO A NEAR BODY SHOP AND THE TOTAL TO REPLACE THIS WOULD BE OVER $2,000. I ALSO SEARCHED ON THE WEB AND FOUND A WEBSITE CALLED ABOUTAUTOMOBLE.COM WHO HAD A LIST OF 51 OF THE SAME COMPLAINTS AS MINE.

I HEARD A LOUD CREAKING/THUD NOISE COMING FROM THE REAR PASSENGER SIDE WHEEL AREA WHILE DRIVING OVER ANY SIZE BUMP/DEPRESSION ON CITY STREETS AND HIGHWAYS. LOOKING CLOSER, I SAW THAT IT WAS BECAUSE THE METAL AROUND THAT PARTICULAR SHOCK MOUNT HAD RUSTED AND CRACKED, AND THE MOUNT WOULD FLEX INWARDS WHEN THE SHOCK WAS COMPRESSED. THE PROBLEM IS ONLY ON THAT WHEEL, AND IT IS A COMMON ISSUE WITH OTHER VEHICLES OF THE SAME MODEL, SO IT MUST BE A DESIGN FLAW.

THIS VEHICLE IS OWNED BY ME BUT USED BY MY SON IN COLORADO. ON A RECENT TRIP NEAR MOAB, UT ON THE WAY TO A CAMP SITE, MY SON HEARD A STRANGE NOISE. UPON INVESTIGATION HE NOTED THE FRAME IN THE RIGHT REAR WHEEL WELL HOLDING THE UPPER END OF THE SHOCK ABSORBER HAD BROKEN IN TWO PLACES FROM RUST INTRUSION. AN INSPECTION OF THE LEFT REAR WHEEL WELL INDICATED MINIMAL RUSTING. SINCE THE TIRES WERE RECENTLY REPLACED THIS FAILURE WAS A SURPRISE AS THE MECHANIC DIDN'T NOTE EXCESSIVE RUST, CRACKING OR SIGNS OF METAL FATIGUE. WHEN THE INCIDENT OCCURED MY SON WAS DRIVING ON A GRAVEL ROAD TOWARD A DESIGNATED CAMPGROUND JUST A SHORT DISTANCE FROM A PAVED HIGHWAY. ALTHOUGH THE VEHICLE HAS 4 WHEEL DRIVE, IT WAS NEVER USED IN A ROUGH MANNER SUCH AS FOR 4 WHEELING OR ON ROUGH UNEVEN SURFACES. THIS WAS MY PERSONAL VEHICLE UNTIL A YEAR AGO. WE HAD JUST SPENT $1,500 FOR NEW TIRES, A CARBURATOR REPAIR AND A NEW WINDSHIELD THAT A ROCK HAD CRACKED. IT WAS OUR INTENT TO OWN THE VEHICLE A FEW YEARS LONGER SINCE IT HAS ONLY 135,000 AND IS IN GOOD CONDITION. MY SON WAS ABLE TO SAFELY RETURN TO STEAMBOAT, A 5 HOUR DRIVE FROM MOAB, BUT WAS VERY CONCERNED THE ENTIRE SHOCK WOULD PUSH THROUGH THE WHEEL WELL CAUSING THE VEHICLE TO LIST OR DRIFT RESULTING IN LOSS OF CONTROL OR A ROLLOVER, I.E. SERIOUS INJURY OR DEATH. A LOCAL BODY SHOP REFUSED TO MAKE REPAIRS DUE TO THE EXTENSIVE DAMAGE. TO MAKE THE VEHICLE SALVAGE BASED ON ITS CURRENT VALUE AND CONDITION IS UNTHINKABLE, YET IF REPAID CANNOT BE MADE AT A REASONABLE COST, THIS MAY BE OUR ONLY CHOICE. MY RESEARCH SUGGEST THE RIGHT REAR WHEEL RUST IS FAIRLY COMMON IN TRIBUTES AND ESCAPES, YET NO RECALL.

PASSENGER SIDE INNER REAR WHEEL WELL RUSTED OUT AND COMPLETELY SEPERATED SHOCK FROM FRAME. I WAS DRIVING ALONG LAST WEEK AND SUDDENLY STARTED HEARING A RATTLING SOUND. I PULLED OVER TO INSPECT ONLY TO FIND NOTHING IN TRUNK. TOOK TRUCK TO MECHANIC ONLY TO BE TOLD THE ENTIRE SHOCK HAD SEPERATED FROM FRAME. THE OTHER WHEEL WELL IS RUST FREE. THIS IS A KNOWN PROBLEM IN MAZDA TRIBUTES ONLY RECALLED FROM 2001-2004, WHEN TRIBUTES FROM 2001-2006 HAVE INTERCHANGEABLE PARTS AND TONS OF PEOPLE ONLINE IN ALL FORUMS ARE EXPERIENCING THE SAME RUST PROBLEM IN THE SAME LOCATIONS ALL OVER THE US.

THE RIGHT, REAR WHEEL WELL IS COMPLETELY RUSTED THROUGH AND LOOKS LIKE A MAJOR ACCIDENT WAITING TO HAPPEN. THE SHOCK MOUNT IS CONNECTED TO THIS PORTION OF THE FRAME AND WILL MORE THAN LIKELY SHEAR OFF SOON. UPON SEARCHING THIS ISSUE, IT APPEARS THAT SEVERAL OTHER 2005 MAZDA TRIBUTE AND FORD ESCAPE OWNERS HAVE EXPERIENCED THE SAME DEFECT. MAZDA/FORD RECALLED 2001-2004 MODELS FOR THE SAME PROBLEM, BUT HAS YET TO ADDRESS THE PROBLEM FOR THE 2005 MODEL YEAR. BASED ON THE WIDESPREAD NATURE OF THE PROBLEM, IT IS OBVIOUS THAT THIS A FACTORY DEFECT AND SHOULD BE RECALLED EITHER WILLINGLY OR UNWILLINGLY.