IllustrationCONSUMER STATES: THE COOLING FANS DO NOT COME ON AFTER THE VEHICLE TURNED OFF. THE VEHICLE OVER HEATS UNLESS THE PARKING LIGHTS ARE TURNED ON. IT GET TO HOT BEFORE THE FANS COME ON. *NM
1994 Mazda RX-7
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all RX-7 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 18 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports2 fire reports1 injury reports
Electrical System complaints
2 reportsI WAS ON MY WAY TO WORK, DRIVING UNDER VERY NORMAL CONDITIONS. I HAD THE FOLLOWING ACCESSORIES ON AT THE TIME OF THE FIRE. HEATER, RADIO, REAR DEFROSTER, AND MAYBE THE HEADLIGHTS. I WAS STOPPED AT A TRAFFIC LIGHT WHEN SMOKE STARTED TO COME OUT FROM UNDER THE HOOD. I PULLED OVER TURNED OFF THE CAR AND SLOWLY OPENED THE HOOD T…
Read full complaint
I WAS ON MY WAY TO WORK, DRIVING UNDER VERY NORMAL CONDITIONS. I HAD THE FOLLOWING ACCESSORIES ON AT THE TIME OF THE FIRE. HEATER, RADIO, REAR DEFROSTER, AND MAYBE THE HEADLIGHTS. I WAS STOPPED AT A TRAFFIC LIGHT WHEN SMOKE STARTED TO COME OUT FROM UNDER THE HOOD. I PULLED OVER TURNED OFF THE CAR AND SLOWLY OPENED THE HOOD TO FIND THE MAIN FUSE BOX (CONNECTED TO THE BATTERY) ON FIRE. THERE WERE FLAMES ABOUT 4-5 INCHES HIGH. I WAS ABLE TO BLOW THE FIRE OUT. I THEN LET THE CAR REST FOR ABOUT 15 MINUTES. AFTER THAT I STARTED THE CAR AND DROVE IT HOME. AFTER THE FIRE, ANY TIME ANY ELECTRICAL ACCESSORY IS TURNED ON (BLINKER, LIGHTS, HEATER, A/C, BRAKES) THE "CHARGE" AND "ABS" WARNING LIGHTS COME ON, AND SO DO THE WARNING LIGHTS BUILT INTO THE OIL PRESSURE, FUEL LEVEL, AND WATER TEMP GAUGES. THE FIRE DAMAGED THE ONE END OF THE FUSE BOX WITH THE 120 AMP FUSE AS WELL AS SOME SURROUNDING WIRES AND CONNECTORS, AND THE UNDERHOOD INSULATION WHICH WAS BURNED BY THE FLAMES.
Official recalls
396V149000 · Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
Aug 2, 1996
OIL MIST CONTAINED IN THE ENGINE INTAKE AIR CAN COLLECT OVER TIME IN THE BRAKE VACUUM CHECK VALVE PREVENTING THE CHECK VALVE FROM OPENING AT THE SPECIFIED PRESSURE REDUCING POWER ASSIST TO THE BRAKES.
Consequence & remedy
Consequence: BRAKE PERFORMANCE CAN BE DIMINISHED INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE TWO VACUUM HOSES, INCLUDING THE CHECK VALVE, WITH MODIFIED HOSES.
95V069000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Mar 30, 1995
RESIDUAL ENGINE HEAT CAN CAUSE PREMATURE DETERIORATION OF THE FUEL HOSE CAUSING THE HOSE TO LEAK. ALSO, REMOVING AND REINSTALLING THE DETERIORATED FUEL HOSES INCREASES THE LIKELIHOOD OF A LEAK.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL CONTROL UNIT FOR THE ELECTRIC COOLING FAN. THE FAN WILL THEN ACTIVATE AFTER THE ENGINE IS TURNED OFF WHEN THE COOLANT EXCEEDS A SPECIFIED TEMPERATURE. THE FUEL HOSES WILL ALSO BE REPLACED WITH REVISED HOSES.
94V094000 · Engine And Engine Cooling:cooling System
May 11, 1994
THE RADIATOR CAP PRESSURE RELIEF VALVE RELEASE PRESSURE IS SET TOO HIGH. THIS CAN CAUSE THE COOLANT TO REACH TEMPERATURES THAT EXCEED THE THERMAL DESIGN LIMITS OF SOME COMPONENTS OF THE COOLANT SYSTEM. SHOULD THIS OCCUR, ENGINE COOLANT CAN LEAK COLLECT ON TOP OF THE ENGINE.
Consequence & remedy
Consequence: IF ENGINE COOLANT LEAKS ONTO THE HOT ENGINE EXHAUST MANIFOLD FROM THE TOP OF THE ENGINE, AN ENGINE COMPARTMENT FIRE CAN RESULT.
Remedy: DEALERS WILL INSPECT THE VEHICLES AND IF ANY VEHICLE EXHIBITS COOLANT LEAKAGE OR IF THE COOLANT LEVEL HAS DROPPED TO THE POINT WHERE THE COOLANT LOSS WOULD BE SUFFICIENT TO TRIGGER THE COOLANT LEVEL WARNING SYSTEM, COMPONENTS POTENTIALLY SUBJECT TO DETERIORATION FROM OVERHEATING WOULD BE REPLACED. THESE PARTS INCLUDE THE WATER PUMP BEARING HOUSING, THE WATER LEVEL SENSOR AND RADIATOR UPPER HOSE, THE THERMOSTAT GASKET, AND ALL WATER HOSES LOCATED ABOVE THE ENGINE. IN ADDITION, ALL VEHICLES IN WHICH THOSE COMPONENTS ARE REPLACED WOULD ALSO HAVE THE COOLING SYSTEM AND OTHER SYSTEMS THAT CARRY FLAMMABLE LIQUIDS CHECKED TO MAKE CERTAIN THAT ENGINE OVERHEATING HAD NOT CAUSED ANY PROBLEMS IN THOSE SYSTEMS. ANY IDENTIFIED PROBLEMS WILL BE REPAIRED. THE RADIATOR CAP, FILLER CAP, AND FILLER CAP BODY OF ALL RECALLED VEHICLES WILL BE REPLACED BY NEWLY DESIGNED PARTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.