DROVE ON HIGHWAY AND VEHICLE STARTED TO SMOKE. PULLED OFF AN EXIT, OPENED HOOD AND FLAMES WERE COMING OUT FROM ENGINE COMPARTMENT. CAR IS SITTING AT A GARAGE WAITING TO BE REPAIRED. THIS IS THE THE 3RD ENGINE IN THE CAR, ALL RESULTING FROM OVERHEATING OR FIRE. 6/2001- ANTIFREEZE FIRE- ISSUED A USED ENGINE 5/2005- ANTIFREEZE …
Read full complaint
DROVE ON HIGHWAY AND VEHICLE STARTED TO SMOKE. PULLED OFF AN EXIT, OPENED HOOD AND FLAMES WERE COMING OUT FROM ENGINE COMPARTMENT. CAR IS SITTING AT A GARAGE WAITING TO BE REPAIRED. THIS IS THE THE 3RD ENGINE IN THE CAR, ALL RESULTING FROM OVERHEATING OR FIRE. 6/2001- ANTIFREEZE FIRE- ISSUED A USED ENGINE 5/2005- ANTIFREEZE FIRE- BOUGHT A USED ENGINE 3/2006-ANTIFREEZE AND OIL LEAK- REPLACE ALL ASSOCIATED HOSES/O-RINGS 2/2012- ENGINE FIRE- WAITING FOR REPAIRS. *TT
OIL MIST CONTAINED IN THE ENGINE INTAKE AIR CAN COLLECT OVER TIME IN THE BRAKE VACUUM CHECK VALVE PREVENTING THE CHECK VALVE FROM OPENING AT THE SPECIFIED PRESSURE REDUCING POWER ASSIST TO THE BRAKES.
Consequence & remedy
Consequence: BRAKE PERFORMANCE CAN BE DIMINISHED INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE TWO VACUUM HOSES, INCLUDING THE CHECK VALVE, WITH MODIFIED HOSES.
RESIDUAL ENGINE HEAT CAN CAUSE PREMATURE DETERIORATION OF THE FUEL HOSE CAUSING THE HOSE TO LEAK. ALSO, REMOVING AND REINSTALLING THE DETERIORATED FUEL HOSES INCREASES THE LIKELIHOOD OF A LEAK.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL CONTROL UNIT FOR THE ELECTRIC COOLING FAN. THE FAN WILL THEN ACTIVATE AFTER THE ENGINE IS TURNED OFF WHEN THE COOLANT EXCEEDS A SPECIFIED TEMPERATURE. THE FUEL HOSES WILL ALSO BE REPLACED WITH REVISED HOSES.
THE RADIATOR CAP PRESSURE RELIEF VALVE RELEASE PRESSURE IS SET TOO HIGH. THIS CAN CAUSE THE COOLANT TO REACH TEMPERATURES THAT EXCEED THE THERMAL DESIGN LIMITS OF SOME COMPONENTS OF THE COOLANT SYSTEM. SHOULD THIS OCCUR, ENGINE COOLANT CAN LEAK COLLECT ON TOP OF THE ENGINE.
Consequence & remedy
Consequence: IF ENGINE COOLANT LEAKS ONTO THE HOT ENGINE EXHAUST MANIFOLD FROM THE TOP OF THE ENGINE, AN ENGINE COMPARTMENT FIRE CAN RESULT.
Remedy: DEALERS WILL INSPECT THE VEHICLES AND IF ANY VEHICLE EXHIBITS COOLANT LEAKAGE OR IF THE COOLANT LEVEL HAS DROPPED TO THE POINT WHERE THE COOLANT LOSS WOULD BE SUFFICIENT TO TRIGGER THE COOLANT LEVEL WARNING SYSTEM, COMPONENTS POTENTIALLY SUBJECT TO DETERIORATION FROM OVERHEATING WOULD BE REPLACED. THESE PARTS INCLUDE THE WATER PUMP BEARING HOUSING, THE WATER LEVEL SENSOR AND RADIATOR UPPER HOSE, THE THERMOSTAT GASKET, AND ALL WATER HOSES LOCATED ABOVE THE ENGINE. IN ADDITION, ALL VEHICLES IN WHICH THOSE COMPONENTS ARE REPLACED WOULD ALSO HAVE THE COOLING SYSTEM AND OTHER SYSTEMS THAT CARRY FLAMMABLE LIQUIDS CHECKED TO MAKE CERTAIN THAT ENGINE OVERHEATING HAD NOT CAUSED ANY PROBLEMS IN THOSE SYSTEMS. ANY IDENTIFIED PROBLEMS WILL BE REPAIRED. THE RADIATOR CAP, FILLER CAP, AND FILLER CAP BODY OF ALL RECALLED VEHICLES WILL BE REPLACED BY NEWLY DESIGNED PARTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE94009 · Turbocharger Malfunction
Opened Jan 31, 1994 · Closed May 24, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System
There is no summary currently available
1993 Mazda RX-7 Problems, Complaints & Recalls | Skip That Year
Illustration