IllustrationBRAKE ROTORS NEEDED TO BE REPLACED, AS WELL AS U JOINTS/ POWER STEERING/BUSHINGS AND WHEEL BEARINGS. DEALE HAS HAD CAR FOR FOUR MONTHS. *AK
1991 Mazda Navajo
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1991 Mazda Navajo do not stand out strongly from the model-year median of 22.
About this comparison →How this year compares
Owner complaints by model year
Compare all Navajo years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 39 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports0 fire reports3 injury reports
Power Train complaints
7 reportsVEHICLE WON'T GO INTO REVERSE DUE TO TRANSMISSION FAILURE. ALSO, BRACKET SEPARATED FROM THE REAR END, AND VEHICLE SQUEAKS WHEN CONSUMER GOES OVER A SPEED BUMP. IN ADDITION, AND A PART TO THE BRAKES MELTED AND THE ABS BRAKE SYSTEM STAYS ON. DEALER CAN'T DETERMINE THE PROBLEM, AND THE BRAKES HAVE BEEN REPLACED. CONSUMER IS ALS…
Read full complaint
VEHICLE WON'T GO INTO REVERSE DUE TO TRANSMISSION FAILURE. ALSO, BRACKET SEPARATED FROM THE REAR END, AND VEHICLE SQUEAKS WHEN CONSUMER GOES OVER A SPEED BUMP. IN ADDITION, AND A PART TO THE BRAKES MELTED AND THE ABS BRAKE SYSTEM STAYS ON. DEALER CAN'T DETERMINE THE PROBLEM, AND THE BRAKES HAVE BEEN REPLACED. CONSUMER IS ALSO HAVING PROBLEMS WITH THE BATTERY AND ENGINE GASKET. *AK
SPEEDOMETER WORKED INTERMITTENTLY IN COLD WEATHER.
TRANSMISSION GEARS CRACKED, CAUSING VEHICLE TO STALL. *AK
4 OUT OF 5 GEARS BROKE OFF WITHOUT ANY WARNING, CAUSING TRANSMISSION FAILURE. *AK
BRAKES LOCKED UP DUE TO DEFECTIVE REAR BRAKE SHOES/DRUMS.
DIFFERENTIAL FAILED, PREVENTING 4WD FROM ENGAGING. *SKD
Official recalls
597V235002 · Structure:body:roof And Pillars
Feb 25, 1998
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH FACTORY INSTALLED SUNROOF. THE SUNROOF GLASS PANEL ASSEMBLY CAN SEPARATE WHILE THE VEHICLE IS MOVING DUE TO INCORRECT HINGE ENGAGEMENT. THIS WAS CAUSED BY IMPROPER SUNROOF INSTALLATION OF THE GLASS PANEL.
Consequence & remedy
Consequence: UNEXPECTED SEPARATION OF THE SUNROOF GLASS PANEL COULD POSSIBLY DISTRACT THE DRIVER INCREASING THE RISK OF A VEHICLE CRASH OR LOSS OF VEHICLE CONTROL.
Remedy: OWNERS WILL BE PROVIDED WITH AN INSTRUCTION BOOKLET WHICH THOROUGHLY OUTLINES, WITH ILLUSTRATIONS, THE PROPER PROCEDURES FOR THE REMOVAL, STORAGE, AND REINSTALLATION OF THE SUNROOF'S GLASS PANEL. A WARNING LABEL FOR ATTACHMENT TO THE SUNROOF'S LATCH KNOB WILL ALSO BE PROVIDED TO THE OWNERS.
96V024002 · Service Brakes, Hydraulic:power Assist:hydraulic
Feb 28, 1996
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
Consequence & remedy
Consequence: IF A CRACK OCCURS, IT COULD RESULT IN ONE OR BOTH STUDS FRACTURING. THE MASTER CYLINDER COULD THEN SEPARATE FROM THE VACUUM BOOSTER, WHEN THE BRAKES ARE APPLIED, PREVENTING THE SERVICE BRAKES FROM FULLY ACTIVATING INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE POWER BRAKE VACUUM BOOSTER ASSEMBLY.
91V189001 · Power Train:automatic Transmission
Nov 4, 1991
WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR.
Consequence & remedy
Consequence: DRIVER MAY BELIEVE THE VEHICLE IS SAFELY ENGAGED IN PARKWHEN THE GEAR IS NOT TRULY ENGAGED. THIS CAN LEAD TO THE VEHICLE JUMPING OUT OFGEAR UNINTENTIONALLY, VEHICLE ROLLAWAY WHEN PARKED ON A SLOPED SURFACE, ANDINADVERTENT MOTION WHEN THE VEHICLE IS STARTED. ALL OF THESE CONDITIONS CANRESULT IN A VEHICLE ACCIDENT.
Remedy: REPAIR THE TRANSMISSION WITH A NEW PARK PAWL.
91V028000 · Structure:body:bumpers
Feb 13, 1991
REAR BUMPER MAY BE SUSCEPTIBLE TO FATIGUE CRACKING UNDER EXTENDED TRAILER TOW SERVICE WHEN USING A BUMPER MOUNTED TRAILER HITCH.
Consequence & remedy
Consequence: BUMPER COULD SEPARATE FROM VEHICLE WHEN USING A BUMPERMOUNTED TRAILER HITCH BALL.
Remedy: INSTALL TWO ADDITIONAL BRACKETS, ONE ADDITIONAL BAR AND ASSOCIATED FASTENERS TO PREVENT BUMPER SEPARATION.
91V020000 · Fuel System, Gasoline:storage:tank Assembly
Jan 5, 1991
FRONT HEAT SHIELD EXTENSION MAY CONTACT THE UPPER FRONT CORNER OF PLASTIC FUEL TANK DAMAGING OR PUNCTURING THE FUEL TANK.
Consequence & remedy
Consequence: SUCH FUEL TANK DAMAGE COULD ALLOW VAPOR AND OR FUEL TOESCAPE; THIS COULD RESULT IN A FIRE IF A SOURCE OF IGNITION IS PRESENT.
Remedy: RELOCATE HEAT SHIELD; REPLACE FUEL TANK IF DAMAGED OR PUNCTURED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE92084 · Front Seat Track Failure
Opened Oct 23, 1992 · Closed Feb 26, 1993
Status: closed (inferred from source dates) · Seats
There is no summary currently available
PE91127 · Park Pawl Bending
Opened Sep 16, 1991 · Closed Nov 8, 1991
Status: closed (inferred from source dates) · Power Train:automatic Transmission
There is no summary currently available
Additional source detail variants (2)
Power Train:automatic Transmission
There is no summary currently available
Power Train:automatic Transmission
There is no summary currently available