2007 Mazda CX-7

I OWN A 2007 MAZDA CX7 THAT THE A/C COMPRESSOR SEIZED UP ON CAUSING A NEAR FIRE UNDER THE HOOD. I HEARD AN AWFUL NOISE AND SAW SMOKE BILLOWING UNDER THE HOOD. I SHUT IT DOWN IMMEDIATELY KNOWING THAT WHAT WAS ABOUT TO HAPPEN COULDN'T BE GOOD. I WENT ONLINE AND FOUND OUT THIS HAS HAPPENED TO MANY CX7S NOW THE DEALER IS TELLING ME THAT BECAUSE I'VE OWNED THIS FOR 37 MONTHS, (35,000 MILES) THAT IT ISN'T COVERED BY THE 60,000 MILE DRIVE TRAIN WARRANTY, (IF I CAN'T DRIVE IT, ITS A DRIVETRAIN PROBLEM TO ME)...THIS NEEDS TO BE A CLASS ACTION LAWSUIT..OR A RECALL YOU'RE CHOICE. *TR

MY WIFE WAS DRIVING OUR 2007 CX-7 WITH APPROXIMATELY 28K MILES ALONG A FOUR LANE MAJOR ROAD WHEN CAR LOST POWER AND BECAME BASICALLY UNDRIVEABLE. LEAVING HER SITTING ON A EXTREMELY BUSY SECTION OF ROAD WITH MY 2 YEAR OLD SON IN THE BACK SEAT AS PEOPLE ARE FLYING OFF AN ENTRANCE RAMP FROM ABERDEEN PROVING GROUND. SHE FOUGHT IT TO THE SHOULDER OF US ROUTE 40 NORTH OF BALTIMORE, LEAVING HER IN A VERY DANGEROUS SITUATION. MAZDA DEALERSHIP WHERE VEHICLE WAS PURCHASED WAS LESS THAN A HALF MILE FROM FAILURE LOCATION AND AFTER TRAFFIC HAD DIED DOWN I WAS ABLE TO LIMP VEHICLE TO DEALER WITH WIFE FOLLOWING ME AT 10 MPH. TURBOCHARGER FAILURE HAS BEEN BLAMED, AS USUAL MAZDA HAS DENIED WARRANTY WORK DUE TO ENGINE SLUDGE, EVEN THOUGH VEHICLE HAS BEEN MAINTAINED. AFTER THOROUGH RESEARCH FOR THE LAST MONTH, WHILE MY VEHICLE HAS SAT AT THE DEALERSHIP, VIA MANY WEBSITES EDMUNDS FORUM, MYCX7.COM, MAZDAS247.COM ETC. MAZDA IS CLAIMING SAME ENGINE SLUDGE IS CAUSE OF FAILURE OF NUMEROUS TIMING CHAINS, TURBOS, VVT ACTUATORS ETC. EVEN ON VEHICLES THAT HAVE BEEN MAINTAINED BY THEIR DEALERSHIPS. THERE HAS BEEN A TECHNICAL SERVICE BULLETIN RELEASED BY MAZDA (TSB# MTOL - 5505) THAT STATED THE FLAWED DESIGN OF THEIR PCV SYSTEM NOT ALLOWING OIL TO DRAIN PROPERLY FROM THE TURBOCHARGER. NO FIX HAS BEEN MADE AVAILABLE WITH RECENT INFORMATION I HAVE READ IN REGARDS TO THE FLAWED PCV NOT CIRCULATING THE OIL. HOPE SOMEONE CAN BRING THIS FLAWED DESIGN ENGINE TO LIGHT BEFORE SOMEONE OR A FAMILY IS KILLED IN A MAJOR ACCIDENT WHERE THEIR CAR LEAVES THEM STRANDED IN THE MIDDLE OF A HIGHWAY LIKE I-95. THANKS FOR THE TIME IN LOOKING INTO THIS MATTER. *TR

WHILE DRIVING AT NIGHT AT HIGHWAY SPEED, NOISE STARTED TO COME FROM ENGINE COMPARTMENT. SEEMED TO COME AND GO, BUT SUDDENLY SMELLED SMOKE AND LOST POWER STEERING. NEARLY HAD A HEAD ON COLLISION. THIS WAS A VERY SERIOUS NEAR MISS. MANAGED TO GET CAR TO NEIGHBORHOOD CAR REPAIR SHOP. AFTER INSPECTION, CAUSE WAS DETERMINED TO BE SEIZED A/C COMPRESSOR THAT LED TO CASCADING FAILURES. COST TO REPAIR ALL DAMAGE WAS $2250. I HAVE SINCE READ THAT THIS IS A COMMON FAILURE ON MAZDA CX-7 AND STILL NO RECALL? I WILL BE SENDING A CLAIM TO MAZDA USA AND WOULD ALSO BE INTERESTED IN JOINING ANY CLASS ACTION SUITE TO RECOUPE ALL MY COSTS AND TO FORCE MAZDA USA TO MAKE A RECALL. FAMILY'S LIVES ARE AT STAKE. *TR

APPROXIMATELY THREE WEEKS AGO, I NOTICED INCREASING DIFFICULTY MANEUVERING MY CAR AND TWO WEEKS AGO, AS I TURNED ONTO MY STREET, (TRAVELING AT APPROXIMATELY 5 MPH), MY CAR ACTUALLY SLID ACROSS THE INTERSECTION AND INTO THE CURB ON THE OPPOSITE SIDE OF THE STREET. FORTUNATELY, NO PEDESTRIANS WERE NEARBY AND NEITHER MY CAR NOR I SUSTAINED ANY INJURY. CURIOUS AS TO WHY THIS WOULD HAVE OCCURRED, MY HUSBAND INVESTIGATED AND MUCH TO OUR DISMAY, WE DISCOVERED THAT MY BRIDGESTONE TURANZA TIRES ' WITH JUST 18,800 MILES ON THEM ' WERE BALD EXCEPT FOR THE GROOVES THAT RUN ALONG THE CIRCUMFERENCE OF THE TIRE. AT THIS TIME, WE CALLED TWO AREA BRIDGESTONE DEALERS WHO JOINTLY CONSENTED THAT THE TIRE HAD NO TREAD WEAR WARRANTY WHICH FURTHER SERVED TO REINFORCE THE FACT THAT BRIDGESTONE IS AWARE THAT THE TURANZA IS A POOR QUALITY TIRE NOT WORTHY OF WARRANTY. WHEN QUESTIONED ABOUT THE POOR STATE OF THE TIRES AFTER JUST 18,800 MILES, THEY INDICATED, THAT OTHER THAN THE FACT THAT THE TURANZA WAS A 'CHEAP' TIRE (THEIR SPECIFIC VERBIAGE), IT COULD ALSO BE DUE TO POOR DRIVER HABITS OR AN OUT-OF-ALIGNMENT VEHICLE OR BOTH. BECAUSE I AM THE SOLE DRIVER OF MY VEHICLE AND COMMUTE JUST 21 MILES ROUND-TRIP TO MY JOB VIA A STATE-MAINTAINED ROAD WITH A MAXIMUM SPEED LIMIT OF 50 MPH, POOR DRIVER HABITS IS ELIMINATED. FURTHERMORE, INVESTIGATION ALSO REVEALED THAT THE CAR WAS, IN FACT, NOT OUT-OF-ALIGNMENT, AS WE HAVE NOW REPLACED ALL FOUR TIRES ON THE VEHICLE AND CONFIRMED THAT THE ALIGNMENT WAS FINE. FRANKLY, WE FIND IT NOTHING SHORT OF DESPICABLE THAT BRIDGESTONE CONTINUES TO SELL THESE TIRES WHEN FULLY AWARE OF ITS POOR QUALITY AND IT IS PARTICULARLY DISHONORABLE THAT YOU ARE WILLING TO RISK PEOPLES' LIVES BECAUSE THEY ARE UNKNOWINGLY DRIVING ON INFERIOR, NON-WARRANTED TIRES. *TR

WHILE DRIVING WE HEARD A NOISE FROM THE ENGINE, WE WERE ABOUT A MILE FROM OUR DESTINATION. WHEN WE PULLED INTO THE PARKING LOT WE SAW SMOKE COMING FROM THE ENGINE COMPARTMENT. WHEN MY HUSBAND OPENED THE HOOD, WE SAW FLAMES. WE IMMEDIATELY CALLED 911 AND RAN TO THE BUILDING TO PROCURE A FIRE EXTINGUSHER. WE WERE ABLE TO LOCATE ONE AND MY HUSBAND PUT OUT THE FIRE. WE WERE TOLD BY THE MAZDA DEALERSHIP THAT THE COMPRESSOR CLUTCH HAD FAILED, CAUSING THE FIRE. WE HAD PURCHASED AN EXTENDED WARRANTY ON THE VEHICLE, UNFORTUNATELY, IT ONLY COVERED TO 60,000 MILES AND THE VEHICLE HAD 61,000 MILES. THE SERVICE MANAGER SUGGESTED THAT WE SHOULD FILE A CLAIM ON OUR INSURANCE, BUT SINCE WE HAVEN'T BEEN ABLE TO GET A DETAILED ESTIMATE ON THE DAMAGES, WE HAVEN'T PROCEEDED THAT FAR YET. THEY HAVE HAD THE VEHICLE FOR THREE DAYS AND THERE IS NO COMPLETE INFORMATION ON THE DAMAGES. *TR

2007 MAZDA CX-7 - A/C COMPRESSOR WENT OUT ON WAY HOME FROM FL TO ATL. WHITE SMOKE FROM RIGHT SIDE ENGINE BAY. WAS ABLE TO TURN OFF A/C IN TIME TO KEEP VEHICLE RUNNING. SEEMS THIS IS A KNOWN ISSUE WITH MAZDA. $900 TO REPLACE PARTS AND LABOR. MAZDA OF ROSWELL STATES ISSUE WAS UNKNOWN TO THEM. MAZDA USA IS AWARE AS WELL AS ALL THE FORUMS AND THIS SITE AS WELL FROM OTHER CUSTOMERS. MANY CUSTOMERS HAVE HAD THIS HAPPEN MULTIPLE TIMES. SOME WITHIN THE 36K BTB WARRANTY, SOME AFTER. POWERTRAIN IS UP TO 60K. WITH THIS BEING A KNOWN ISSUE, SHOULDN'T THIS BE A RECALL IF IT IS A PROBLEM THAT WILL OCCUR ON MOST 2007 CX-7'S WITH THE PART? I HAVE EMAILED MAZDA USA AS WELL. *TR

TL* THE CONTACT OWNS A 2007 MAZDA CX7. WHILE DRIVING 40 MPH THE VEHICLE MADE A LOUD NOISE AND THEN SMOKE WAS CAME FROM UNDERNEATH THE HOOD OF THE VEHICLE. SHE THEN PULLED OVER TO A MECHANIC SHOP. SHE WAS ADVISED THAT THE ENGINES OIL LEVEL WAS DEPLETED. HOWEVER SHE WAS NOT SCHEDULED FOR ANOTHER OIL CHANGE UNTIL THE 25TH OF DECEMBER . THE VEHICLE WAS THEN TOWED TO THE DEALER AND THE TECHNICIAN STATED THAT THE TURBO FAILED IN HER VEHICLE . THE VEHICLE WILL BE REPAIRED AT THE OWNERS EXPENSE. THE FAILURE AND CURRENT MILEAGES WERE 65000. UPDATED 02/1710 *BF UPDATED 02/19/10