2023 Mazda CX-5

Loud fan noise coming from the passenger side headlight. Noise continues when car has been turned off and stops when the light shuts off. Dealer said that replacement of the passenger headlamp assembly needed but would charge because it was not longer under warrant due to mileage. No warning lamps, messages nor other items appeared. The symptoms began around 40,000 miles.

After driving a few mile, the following two warnings come up * Smart Brake System Malfunction * Forward Radar Sensor System malfunction. If I turn off the car and then restart, the warnings go away. However, it comes back if I drive for a while again. I have visited dealership a few times for the same issue, they replaced the wheel bearing and brake switch. The warning disappeared for days and came back.

The driver-side power door mirror on my 2023 Mazda CX-5 vibrates excessively at highway speeds above 75 mph, especially on windy days. The vibration is so severe that it causes a blurred and distorted view, making it difficult to clearly see vehicles in adjacent lanes. This poses a significant safety risk, as it impairs my ability to make safe lane changes and monitor surrounding traffic. I brought the issue to the attention of my Mazda dealership during a scheduled service appointment, but they dismissed it as "normal" and quoted approximately $700 to replace the mirror - despite the fact that this appears to be a known issue with Mazda vehicles. Numerous owners of recent Mazda models have reported similar problems online, yet Mazda has not issued a Technical Service Bulletin (TSB) for the 2023 CX-5. I am attaching a previous TSB (09-002/13) that Mazda released for earlier CX-5 models (2013–2014), which addressed the same mirror vibration issue through structural reinforcement and mirror replacement. This suggests the problem may still persist in newer models. The mirror is available for inspection upon request. No warning lights or messages were displayed, and the issue began shortly after I started driving the vehicle on highways. Link to previous TSB - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car has a lot of vibration when driving 60mph and above. Have had this issue looked at more than 5 times and they had my card for 1 month at the dealership trying to find the issue. This started back in February of 2024 and I have purchased 4 sets of tires and nothing makes the vibrations of the seat, steering wheel go away. Originally it wasn’t vibrating while driving back in February of 2025 only when braking to which I said to them I think it’s the rotors that have an issue. They never check the rotors and said it was my tires that were cupped. I put new tires on the car and still the same issue and went back to the dealership in April of 2024 and let them know it think it’s the rotors. In fact it was the rotors they were warped and they balanced the tires again. The dealership recommended resurfacing the rotors to which I had done. A Couple of months later the vibration while driving started. Bought another set of tires had then installed, balanced and aligned and still vibration. I thought maybe it’s the brand so I bought another set of tires to which the problem is still there. Now besides the vibration while driving I have vibrations while braking again after the dealership put in new rotors back in Nov. 2024. When to the dealership on 06.26.25 let them know the vibration while braking is happening again and I think it’s the rotors. They check them and rotors are warped again about only 6.5 months.The service manager said she will resurface them for me for no charge but then the service advisor said if they do that that the resurfacing is going to make me have to change the brake pads as I will end up in the red since my brake pads are in the yellow right now. I said then don’t resurface because I am not paying for the brake pads when that should’ve been done the first time the rotors were warped. I feel like I risk my life everyday driving this car to work 34miles one way.

When driving the vehicle, my car exhibits a rocking / shake when going from brake to gas at speeds below 20 mph. I was told by the dealership that it is normal operation, but when driving two other CX5’s, the behavior did not exhibit. I do not know what to do. I have also brought it to 2 independent mechanics and they told me the engine mounts needed to be replaced. I did the service at 36,000 miles and it did not get rid of the problem. It seems to be a defect of the car, which I’ve been living with since 2023. The issue has been ongoing.