My truck sat for a while I charged the Batt. I drove to the landfill in Tehachapi Ca. It ran fine. I unloaded the trash the engine idled for 30+min. The landfill had debris on the ground. The truck ran fine back to town. I had 3/4 fuel. I decided to fill up at the Loves gas station I filled it all the way 2 clicks I think. I st…
Read full complaint
My truck sat for a while I charged the Batt. I drove to the landfill in Tehachapi Ca. It ran fine. I unloaded the trash the engine idled for 30+min. The landfill had debris on the ground. The truck ran fine back to town. I had 3/4 fuel. I decided to fill up at the Loves gas station I filled it all the way 2 clicks I think. I started up the truck after fueling it ran terribly I had a flashing check engine light. I drove home 2milles when home the truck was on 🔥 FIRE!! I turned off engine. Put lots of h20 on fire. Disconnected Batt put more h20. I don't know if it started at gas station or in between. I can ask neighbors. The fire was under the driver's seat underneath the truck. I don't know if it was damaged by debris at the dump there was lots of [XXX] on the ground. It has not been inspected yet. I have not started any repairs. No police report. No damage to any one or property (except my truck). It is in my driveway and can be inspected there or towed. No pictures but I can take some. I am glad it didn't cause the gas station to go up in flames. Yes I have it insurance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11567241
98,000 miles · Jul 26, 2018
Electrical SystemExterior Lighting
THE ELECTRICAL SYSTEM SHUT DOWN WHILE I WAS DRIVING, TURNING OFF AIR CONDITIONER, RADIO, INTERIOR LIGHTS, AND TURN INDICATOR. THE DASH LIT UP ABS, AIRBAG, AND CRUISE CONTROL INDICATORS. WHEN I STOPPED, I TURNED OFF THE ENGINE AND TURNED THE KEY TO POWER WITHOUT STARTING ENGINE AND FOUND THE ELECTRICAL WORKING AGAIN. I TRIED DRIV…
Read full complaint
THE ELECTRICAL SYSTEM SHUT DOWN WHILE I WAS DRIVING, TURNING OFF AIR CONDITIONER, RADIO, INTERIOR LIGHTS, AND TURN INDICATOR. THE DASH LIT UP ABS, AIRBAG, AND CRUISE CONTROL INDICATORS. WHEN I STOPPED, I TURNED OFF THE ENGINE AND TURNED THE KEY TO POWER WITHOUT STARTING ENGINE AND FOUND THE ELECTRICAL WORKING AGAIN. I TRIED DRIVING AGAIN AND THE ELECTRICAL SYSTEM WORKED FOR A SHORT TIME AND WENT OFF AGAIN. WHEN IT FIRST HAPPENED, I WAS DRIVING STRAIGHT ON A CITY STREET
NHTSA ODI #11113986
31,777 miles · Apr 25, 2016
Electrical System
TL* THE CONTACT OWNS A 2003 MAZDA B-SERIES TRUCK. THE CONTACT STATED THAT THE IGNITION SWITCH FAILED INTERMITTENTLY. THE CONTACT MENTIONED THAT A NEUTRAL SAFETY SWITCH WAS INSTALLED AND THE FAILURE PROGRESSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 31,777. THE VIN WAS NOT PROVIDED…
Read full complaint
TL* THE CONTACT OWNS A 2003 MAZDA B-SERIES TRUCK. THE CONTACT STATED THAT THE IGNITION SWITCH FAILED INTERMITTENTLY. THE CONTACT MENTIONED THAT A NEUTRAL SAFETY SWITCH WAS INSTALLED AND THE FAILURE PROGRESSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 31,777. THE VIN WAS NOT PROVIDED.
NHTSA ODI #10861183
31,880 miles · Feb 12, 2006
Electrical System
12/07/05 ENGINE DIED ON 4 LANE HWY, 42 MILES FROM HOME IN RUSH HOUR TRAFFIC. TOWED TO DEALER, WHO TWO DAYS LATER STATED PROBLEM WAS FUEL PUMP RELAY, AND IT WAS FIXED. 01/25/05 TRUCK DIED IN INTERSECTION AT 4:30 P.M. HUSBAND TAPED WIRES AND WIRE-TIED CONNECTOR TO RELAY. DEALER ORDERED FUEL CUT-OFF SWITCH 01/27/05 AND DID NOT INST…
Read full complaint
12/07/05 ENGINE DIED ON 4 LANE HWY, 42 MILES FROM HOME IN RUSH HOUR TRAFFIC. TOWED TO DEALER, WHO TWO DAYS LATER STATED PROBLEM WAS FUEL PUMP RELAY, AND IT WAS FIXED. 01/25/05 TRUCK DIED IN INTERSECTION AT 4:30 P.M. HUSBAND TAPED WIRES AND WIRE-TIED CONNECTOR TO RELAY. DEALER ORDERED FUEL CUT-OFF SWITCH 01/27/05 AND DID NOT INSTALL UNTIL 02/03/06, BECAUSE WAITING FOR PART. DEALER RELOCATED THE RELAY FROM FLOOR BOARD TO BEHIND THE PASSENGER KICK PANEL AND WIRE-TIED THE CONNECTOR TO THE RELAY AND SWORE THIS WOULD SOLVE PROBLEM. ON 02/10/06 THE ENGINE DIED AT 1:00 P.M., 50 MILES FROM HOME. BECAUSE OF PREVIOUS HISTORY, I MANAGED TO RESET AND CONTINUE HOME AND LEFT MESSAGE WITH SERVICE MANAGER. MY HUSBAND DECIDED TO INSPECT SITUATION, AND DISCOVERED THE WIRE CONNECTOR THAT PLUGS INTO THE RELAY IS BROKEN AND IS THE CAUSE FOR FAILURE. WE BELIEVE THIS DAMAGE WAS PROBABLY CAUSED BY THE ORIGINAL LOCATION OF ASSEMBLY UNDERNEATH PASSENGER FLOOR MAT. PRESENTLY AWAITING CALL BACK FROM SERVICE MANAGER. *JB
MAZDA IS RECALLING MODEL YEAR 1995 THROUGH 1997 AND MODEL YEAR 2001 THROUGH 2003 TRUCKS EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS) AND/OR ANTI-LOCK BRAKE SYSTEM (ABS) AND MANUFACTURED ON OR BEFORE DECEMBER 5, 2002. A COMPONENT OF THE CRUISE CONTROL DEACTIVATION SWITCH MAY DETERIORATE OVER TIME AND DEVELOP A LEAK. THIS OCCURRENCE COULD CAUSE THE SWITCH TO OVERHEAT, SMOKE OR BURN WHICH COULD RESULT IN AN UNDER HOOD FIRE.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: MAZDA WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A UNIVERSAL FUSED JUMPER HARNESS ON THE CRUISE CONTROL DEACTIVATION SWITCH FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 11, 2009. OWNERS MAY CONTACT MAZDA AT 1-800-222-5500 OPTION #6.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting:brake Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:tail Lights
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF ALL WARRANTY CLAIMS SUBMITTED TO FORD FOR BRAKE LAMP FAILURE, FORD IDENTIFIED ONLY 120 THAT WERE RELATED TO WIRE CHAFE NEAR THE CHMSL, AND MOST (115 OF THE 120) WERE REPORTED FOR THE SUPER CAB CHMSL. ODI'S REVIEW OF FORD'S WARRANTY CLAIMS AND COMPLAINT DATA REVEALS A DECLINING TREND FOR THE SUPER CAB AND THAT TREND CLOSELY PARALLELS THE TREND FOR THE STANDARD CAB AS WELL.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2003 Mazda B-SERIES Truck Problems, Complaints & Recalls | Skip That Year
Illustration