IllustrationTRANSMISSION 1ST/2ND GEAR SYNCHROMESH WENT OUT 5 TIMES, FINALLY MAZDA ADMITTED SOMETHING WAS WRONG WITH ENGINE,3X WAS UNDER WARRANTY, LAST 2X I PAID ALL COSTS. JUDGE RULED AGAINST MAZDA IN SMALL CLAIMS COURT.
2002 Mazda B-SERIES Truck
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Mazda B-SERIES Truck do not stand out strongly from the model-year median of 26.
About this comparison →How this year compares
Owner complaints by model year
Compare all B-SERIES Truck years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
100–25K
525–50K
450–75K
075–100K
1100–150K
1150K+
21 reports with mileage · 7 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports0 fire reports3 injury reports
Power Train complaints
6 reportsSINCE I PURCHASED THE VEHICLE THERE HAS BEEN NOTICEABLE PLAY IN THE REAR DIFFERENTIAL. I IGNORED IT FOR A LONG TIME AND THEN AFTER THE WARRANTY HAD EXPIRED I TOOK IT TO A REPAIR SHOP IN THE AREA THAT HAS A VERY GOOD REPUTATION FOR REPAIRING AND SETTING UP DIFFERENTIALS. AFTER EXAMINING THE GEARS IN THE REAR END HE TOLD ME THE …
Read full complaint
SINCE I PURCHASED THE VEHICLE THERE HAS BEEN NOTICEABLE PLAY IN THE REAR DIFFERENTIAL. I IGNORED IT FOR A LONG TIME AND THEN AFTER THE WARRANTY HAD EXPIRED I TOOK IT TO A REPAIR SHOP IN THE AREA THAT HAS A VERY GOOD REPUTATION FOR REPAIRING AND SETTING UP DIFFERENTIALS. AFTER EXAMINING THE GEARS IN THE REAR END HE TOLD ME THE PLAY WAS CAUSED BY A PART THAT WAS MACHINED INCORRECTLY AT THE FACTORY. HE SAID IT WAS A HOLE THAT WAS DRILLED TOO LARGE FOR THE PIN THAT IS INSTALLED IN IT TO HOLD THE AXLE GEARS IN PLACE. HE ASSURED ME THAT IT WAS NOT CAUSED BY WEAR BECAUSE THIS PIN IS NOT A MOVING PART. I HAVE CONTINUED TO DRIVE THE TRUCK WITHOUT ANY REPAIR BEING MADE, IT DOES NOT SEEM TO BE GETTING ANY WORSE, BUT WHO KNOWS HOW LONG UNTIL IT FAILS? *TR
DT*: THE CONTACT OWNS A 2002 MAZDA B-2300 TRUCK. WHILE AT A STOP AND ATTEMPTING TO ACCELERATE THE VEHICLE STALLED. THE DEALER DETERMINED THE TRANSMISSION NEEDS TO BE REPLACED HOWEVER, NO REPAIRS HAVE BEEN MADE. *AK UPDATED 03/09/06
3 MONTHS AFTER I PURCHASED MY TRUCK, I STARTED HAVING PROBLEMS WITH THE TRANSMISSION. THE TRANSMISSION BANGS LIKE SOMEONE HIT ME FROM THE REAR WHEN SHIFTED FROM PARK TO REVERSE. IT ALSO SHUTTERS WHEN I PRESS THE ACCELERATOR.
WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING VEHICLE WILL STALL WHILE ENGAGING THE CLUTCH PEDAL.*AK
TRANSMISSION WILL NOT SHIFT INTO OVERDRIVE UNTIL SPEEDS OF 58-60 ARE REACHED - WHEN ACCELERATING. TOOK VEHICLE TO DEALER FOR THE COMPLAINT. DEALER TECH SAID VEHICLE WOULD NOT SHIFT DURING 'AGRESSIVE ACCELERATING' . DRIVER MUST EASE UP ON GAS PEDAL BEFORE TRANSMISSION WOULD SHIFT TO OVERDRIVE. SAID THIS WAS NORMAL. NEVER HEARD O…
Read full complaint
TRANSMISSION WILL NOT SHIFT INTO OVERDRIVE UNTIL SPEEDS OF 58-60 ARE REACHED - WHEN ACCELERATING. TOOK VEHICLE TO DEALER FOR THE COMPLAINT. DEALER TECH SAID VEHICLE WOULD NOT SHIFT DURING 'AGRESSIVE ACCELERATING' . DRIVER MUST EASE UP ON GAS PEDAL BEFORE TRANSMISSION WOULD SHIFT TO OVERDRIVE. SAID THIS WAS NORMAL. NEVER HEARD OF AN AUTOMATIC TRANSMISSION WITH SUCH REQUIREMENTS. NONE THAT I HAVE EVER OWNED REQUIRED AN EASING UP ON GAS IN ORDER TO SHIFT. WHEN I FOLLOWED DEALERS INSTRUCTIONS, VEHICLE WILL STILL NOT SHIFT UNTIL IT HAS BEEN DRIVEN FOR SOME PERIOD OF TIME. UNDER SUCH CONDITIONS, I CAN'T GET INTO OVERDRIVE FOR THE TRIPS I TAKE, SO THE OVERDRIVE DOES ME NO GOOD. VEHICLE GETS VERY POOR MILEAGE AS A RELULT. DON'T THINK THIS IS A NORMAL CONDITION. I ONLY HAVE LESS THAN 2000 MILES (SINCE OCT 2002) BECAUSE OF SUCH DRIVING CONDITIONS AND POOR MILEAGE.*AK
Official recalls
209V414000 · Vehicle Speed Control:cruise Control
Oct 23, 2009
MAZDA IS RECALLING MODEL YEAR 1995 THROUGH 1997 AND MODEL YEAR 2001 THROUGH 2003 TRUCKS EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS) AND/OR ANTI-LOCK BRAKE SYSTEM (ABS) AND MANUFACTURED ON OR BEFORE DECEMBER 5, 2002. A COMPONENT OF THE CRUISE CONTROL DEACTIVATION SWITCH MAY DETERIORATE OVER TIME AND DEVELOP A LEAK. THIS OCCURRENCE COULD CAUSE THE SWITCH TO OVERHEAT, SMOKE OR BURN WHICH COULD RESULT IN AN UNDER HOOD FIRE.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: MAZDA WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A UNIVERSAL FUSED JUMPER HARNESS ON THE CRUISE CONTROL DEACTIVATION SWITCH FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 11, 2009. OWNERS MAY CONTACT MAZDA AT 1-800-222-5500 OPTION #6.
07V347000 · Vehicle Speed Control
Aug 7, 2007
ON CERTAIN TRUCKS EQUIPPED WITH A SPEED CONTROL SYSTEM, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. AN INTERIM NOTICE WAS SENT TO OWNERS ON SEPTEMBER 7, 2007, DIRECTING THEM TO HAVE THE SPEED DEACTIVATION CONTROL SWITCH DISCONNECTED TEMPORARILY. A SECOND NOTIFICATION LETTER TO OWNERS WAS IN FEBRUARY 2008 ADVISING THEM TO RETURN TO DEALERS FOR INSTALLATION OF THE REPAIR PART. OWNERS OF AFFECTED VEHICLES WHO DID NOT RECEIVE A PHASE 2 NOTICE AND HAVE NOT HAD THE RECALL COMPLETED WILL BE NOTIFIED BEGINNING AUGUST 6, 2008. OWNERS MAY CONTACT MAZDA AT 1-800-222-5500.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.