ABS BRAKES ON REAR ALWAYS BEEN BAD, VERY GRABBY, LOCKUP WITH MEDIUM TO HARD PRESSURE. REPORTED TO DEALER, CHECKED, SAID "NO PROBLEM FOUND." THERE IS A PROBLEM, THERE'S ALWAYS BEEN A PROBLEM AND NOW IT IS GETTING WORSE. I'VE ALMOST HAD AN ACCIDENT ON SEVERAL OCCASIONS AS A DIRECT RESULT OF THIS PROBLEM. I'VE BEEN LIVING WITH …
Read full complaint
ABS BRAKES ON REAR ALWAYS BEEN BAD, VERY GRABBY, LOCKUP WITH MEDIUM TO HARD PRESSURE. REPORTED TO DEALER, CHECKED, SAID "NO PROBLEM FOUND." THERE IS A PROBLEM, THERE'S ALWAYS BEEN A PROBLEM AND NOW IT IS GETTING WORSE. I'VE ALMOST HAD AN ACCIDENT ON SEVERAL OCCASIONS AS A DIRECT RESULT OF THIS PROBLEM. I'VE BEEN LIVING WITH IT FOR SEVERAL YEARS, BUT IT IS GETTING TO THE POINT WHERE IT IS EXTREMLY DANGEROUS. I'VE SET UP AN APPOINTMENT WITH THE DEALER, BUT WANTED IT ON RECORD WITH YOU AS WELL. FRONT SPINDLE AND BEARING WENT OUT AT 28,439 MILES. DEALER REPLACED. IT IS GOING OUT AGAIN AT 53,000 MILES. ONLY SUPPOSED TO BE CHECKED EVER 30,000 MILES NOT REPLACED!
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
Consequence & remedy
Consequence: IF A CRACK OCCURS, IT COULD RESULT IN ONE OR BOTH STUDS FRACTURING. THE MASTER CYLINDER COULD THEN SEPARATE FROM THE VACUUM BOOSTER, WHEN THE BRAKES ARE APPLIED, PREVENTING THE SERVICE BRAKES FROM FULLY ACTIVATING INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE POWER BRAKE VACUUM BOOSTER ASSEMBLY.
DURING EXTREME COLD, NORTHERN CLIMATE WINTER CONDITIONS, ICE CAN FORM IN THE THROTTLE BODY OF THE ENGINE CAUSING THE THROTTLE PLATE TO REMAIN IN THE HIGHWAY CRUISING POSITION AFTER THE ACCELERATOR IS RELEASED OR THE SPEED CONTROL IS DEACTIVATED.
Consequence & remedy
Consequence: THE VEHICLE STOPPING DISTANCES CAN BE INCREASED POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: DEALERS WILL REPLACE THE AIR INTAKE DUCT AND VALVE ASSEMBLY WITH REVISED UNITS.
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
THE FRONT FUEL LINES HAVE A SECTION OF FLEXIBLE HOSE THAT IS SUSCEPTIBLE TO CRACKING WHICH CAN ALLOW FUEL LEAKAGE.
Consequence & remedy
Consequence: LEAKING FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE FRONT FUEL LINE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA96004 · Rear Brake Lockup
Opened Apr 16, 1996 · Closed Apr 9, 1997
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP96001 · Rear ANTI-LOCK Brakes Lock Up
Opened Jan 3, 1996 · Closed Apr 23, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
PETITIONER: ROGER YOUNG NHTSA#: ES95120208 ODI # 490741
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
1994 Mazda B-SERIES Truck Problems, Complaints & Recalls | Skip That Year
Illustration