Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 64 of 282 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 177 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports6 fire reports14 injury reports
What owners actually said
282 reports
Mileage unknown · Aug 13, 1999
Power Train
MAZDA REP RANDY HAYNES INFORMED ME THAT TRANSMISSION FAILURE RATE IS EXTREMELY HIGH ON THIS MODEL AND ALSO 1994 FORD ESCORTS (SAME TRANSMISSION) DUE TO INADEQUATE TRANSMISSION COOLING UNIT. TORK CONVERTER OVERHEATS AND DAMAGES TRANSMISSION. CLEARLY THIS IS A DESIGN FLAW. HAYNES STATES THAT FAILURES HAVE OCCURRED AT 25,000 MIL…
Read full complaint
MAZDA REP RANDY HAYNES INFORMED ME THAT TRANSMISSION FAILURE RATE IS EXTREMELY HIGH ON THIS MODEL AND ALSO 1994 FORD ESCORTS (SAME TRANSMISSION) DUE TO INADEQUATE TRANSMISSION COOLING UNIT. TORK CONVERTER OVERHEATS AND DAMAGES TRANSMISSION. CLEARLY THIS IS A DESIGN FLAW. HAYNES STATES THAT FAILURES HAVE OCCURRED AT 25,000 MILES. ALSO STATES THAT MAZDA SPENT $25,000,000 LAST YEAR REPLACING TRANSMISSIONS ALONE. DEALER AND MANUFACTURER HAVE NO INTEREST IN CORRECTING PROBLEM.
NHTSA ODI #709943
Mileage unknown · Aug 6, 1999
Power Train
CAR JUMPS INTO FIRST GEAR WITH VIOLENT JERKS AT SPEED WITHOUT WARNING. SEATBELTS LOCK UP AND CAR IS DIFFICULT TO CONTROL. DEALER UNABLE TO FIND THE PROBLEM WITH OVER 18 TRIES. HAVE PAID FOR LIMITER SWITCH REPLACEMENT SEVERAL TIMES WITH NO IMPROVEMENT. WANTS ME TO PAY FOR NEW TRANS. NO WAY! PROBLEM HAS BEEN AT LEAST MONTH…
Read full complaint
CAR JUMPS INTO FIRST GEAR WITH VIOLENT JERKS AT SPEED WITHOUT WARNING. SEATBELTS LOCK UP AND CAR IS DIFFICULT TO CONTROL. DEALER UNABLE TO FIND THE PROBLEM WITH OVER 18 TRIES. HAVE PAID FOR LIMITER SWITCH REPLACEMENT SEVERAL TIMES WITH NO IMPROVEMENT. WANTS ME TO PAY FOR NEW TRANS. NO WAY! PROBLEM HAS BEEN AT LEAST MONTHLY SINCE PURCHASE THEY CANNOT FIND THE PROBLEM AND NOW WANT TO SHOTGUN SOLUTION AFTER MUCH DANGER, FRUSTRATION AND EXPENSE.
NHTSA ODI #709666
Mileage unknown · Aug 5, 1999
Service Brakes, Hydraulic
REAR CALIPERS FAILED CAUSING THE VEHICLE BRAKES TO LOCK AND SMOKE UP WHILE DRIVING. NLM
NHTSA ODI #547769
Mileage unknown · Jul 27, 1999
Electrical SystemFire
I WAS DRIVING TO WORK. SMOKE STARTED COMING FROM UNDER THE DASH BOARD. THE CAR CUT OFF. I GOT OUT OF THE CAR, RAISED THE HOOD. THE WIRE THAT COMES OUT OF THE DASH BOARD WAS RED. ABOUT 20 SECONDS LATER, SMOKE CONSUME THE CAR AND THE DASH BOARD WAS ON FIRE. THE INSIDE OF THE CAR WAS BURNED. FROM THE DASH BOARD TO THE TRUNK. T…
Read full complaint
I WAS DRIVING TO WORK. SMOKE STARTED COMING FROM UNDER THE DASH BOARD. THE CAR CUT OFF. I GOT OUT OF THE CAR, RAISED THE HOOD. THE WIRE THAT COMES OUT OF THE DASH BOARD WAS RED. ABOUT 20 SECONDS LATER, SMOKE CONSUME THE CAR AND THE DASH BOARD WAS ON FIRE. THE INSIDE OF THE CAR WAS BURNED. FROM THE DASH BOARD TO THE TRUNK. THE FIRE REPORT SAID IT WAS ELECTRIAL PROBLEM.
NHTSA ODI #709277
Mileage unknown · Jul 26, 1999
Electrical SystemVehicle Speed Control
RECEIVED VEHICLE AFTER A FEW MONTHS & THE ENGINE STARTED SURGING. THE VEHICLE WOULD ALSO STUTTER. IT WOULD SOMETIMES BUCK OR JERK. SOMETIMES WOULD STALL OUT. WAS INFORMED THE ECM MODULE SHOULD CORRECT THE PROBLEM ONCE INSTALLED. *AK
NHTSA ODI #843320
Mileage unknown · Jul 20, 1999
Power Train
MECHANIC WILL NOT TOUCH TRANSMISSION BECAUSE OF KNOWN DEFECT. *AK
NHTSA ODI #708847
Mileage unknown · Jul 19, 1999
Power Train
DEALER SAYS TRANSMISSION ELECTRONICS ARE FAULTY,REQUIRING NEW TRANSMISSION. SEEMS TO BE A VERY COMMON PROBLEM WITH THIS MODEL YEAR. HOLD LIGHT ON DASH FLASHING INDICATING PROBLEM. *AK
NHTSA ODI #708834
Mileage unknown · Jun 4, 1999
Unknown Or Other
NO SUMMARY LISTED FOR THIS VEHICLE. *AK
NHTSA ODI #707202
Mileage unknown · Jun 2, 1999
Electrical System
VEHICLE STALLED WHILE DRIVING AT ABOUT 70MPH. VEHICLE HAD TO BE STOPPED, AND ENGINE HAD TO BE TURNED BACK ON. DEALER INDICATED THAT AN ELECTRICAL PART CAUSED VEHICLE TO LOSE POWER. *AK
NHTSA ODI #838741
Mileage unknown · May 13, 1999
Power TrainVehicle Speed Control
TRANSMISSION BEGAN "JUMPING" GEARS AND ENGINE REVVING WILDLY AT APPROXIMATELY 35000 MILES. DEALER FAILED TO FIND ANY PROBLEM ON 2 OCCASIONS. ON THE 3RD ATTEMPT, I SAT SERVICE MANAGER IN CAR WITH ME TO EXPERIENCE PROBLEM. DEALER SUPPOSEDLY FIXED TRANSMISSION. AT APPROXIMATELY 71,000 MILES AIR FLOW SENSOR HAD TO BE REPLACED. …
Read full complaint
TRANSMISSION BEGAN "JUMPING" GEARS AND ENGINE REVVING WILDLY AT APPROXIMATELY 35000 MILES. DEALER FAILED TO FIND ANY PROBLEM ON 2 OCCASIONS. ON THE 3RD ATTEMPT, I SAT SERVICE MANAGER IN CAR WITH ME TO EXPERIENCE PROBLEM. DEALER SUPPOSEDLY FIXED TRANSMISSION. AT APPROXIMATELY 71,000 MILES AIR FLOW SENSOR HAD TO BE REPLACED. AT 72000 MILES "HOLD" LIGHT BEGAN FLASHING. DEALER PULLED CODE 628 FROM THE COMPUTER AND TOLD US THIS MEANT THE ENTIRE TRANSMISSION HAD TO BE REPLACED. I TOLD SERVICE MANAGER, GENERAL MANAGER AND DISTRICT SERVICE MANAGER THAT 72000 MILES WAS ENTIRELY TOO SOON FOR A TRANSMISSION TO NEED TO BE COMPLETELY REPLACED, ESPECIALLY IN LIGHT OF PREVIOUS PROBLEMS, AND WANTED MAZDA TO PAY FOR PART. I WAS TOLD "TOUGH LUCK". IT HAS BEEN BROUGHT TO MY ATTENTION THAT THIS IS NOT AN ISOLATED PROBLEM WITH MAZDA TRANSMISSIONS. I STILL WANT SOME FORM OF ASSISTANCE FROM MAZDA! *AK
Mazda North American Operations (Mazda) is recalling certain model year 1989-1998 MPV, 1990-1995 323, 1990-1998 Protege, 1992-1993 MX-3, 1993-1995 929, 1993-1997 MX-6, and 1993-1998 626 vehicles. In the affected vehicles, grease applied to the contact points inside the ignition switch may become conductive and overheat.
Consequence & remedy
Consequence: If the ignition switch overheats there would be an increased risk of a fire.
Remedy: Mazda will notify owners, and dealers will replace the ignition switch, free of charge. The recall began on December 17, 2015. Owners may contact Mazda Customer Experience Center at 1-800-222-5500, option#6. Mazda's number for this recall is 8715J.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHT WIRE THAT RUNS THROUGH THE TURN SIGNAL LEVER CAN FAIL AT THE POINT WHERE IT IS SOLDERED TO THE HEADLIGHT SWITCH.
Consequence & remedy
Consequence: THE FAILURE OF THIS WIRE COULD CAUSE A LOSS OF HEADLIGHTS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLIGHT SWITCH LEVER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ99022 · Headlight Failure
Opened Dec 20, 1999 · Closed Aug 30, 2000
Status: closed (inferred from source dates) · Exterior Lighting
OBTAINED RECALL 99V-358
SQ98024 · Speedometer Inoperative
Opened Oct 29, 1998 · Closed Sep 10, 1999
Status: closed (inferred from source dates) · Power Train
SEE RESUME FOR DETAILS.
1994 Mazda 626 Problems, Complaints & Recalls | Skip That Year
Illustration