Air Bags. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Wheels. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports1 fire reports8 injury reports

Engine And Engine Cooling complaints

3 reports

Clear category filter

109,000 miles · Dec 9, 2014

Engine And Engine CoolingPower Train

THIS CAR HAS A ENGINE AND TRANSMISSION FROM A FORD FUSION, ITS SHIFTING VIOLENTLY AND IS NOT SAFE. THE TRANSMISSION BUILT FOR THIS VEHICLE IS VERY POOR CRAFTSMANSHIP AND NO RECALL WAS MADE. SEVERAL VEHICLES HAVE BEEN AFFECTED BY THE LACK OF QUALITY CONTROL AT FORD. *TR

NHTSA ODI #10663041

Mileage unknown · Nov 5, 2012

Electrical SystemEngine And Engine Cooling

Read full complaint

2006 LINCOLN ZEPHYR. CONSUMER WRITES IN REGARDS TO VEHICLE SMELLS OF FUMES WHILE DRIVING *TGW THE CONSUMER ALSO STATED THERE WAS A SMELL OF BURNING RUBBER AND FIRE COMING FROM UNDER THE VEHICLE, THROUGHOUT THE PASSENGER CABIN AND THROUGH THE CRACKS BETWEEN THE HOOD AND FENDER WHEEL. HE NOTICED THE VEHICLE WAS KNOCKING AND RUNNING ROUGH, SO HE TURNED IT OFF. HE THEN LIFTED THE HOOD, AND DISCOVERED SMOKE POURING OUT OF THE MOTOR. THE VEHICLE WAS TOWED TO A REPAIR SHOP. AN INSPECTION REVEALED A BAD COIL WENT BAD ON THE MOTOR, WHICH CAUSED THE ENGINE ROUGHNESS. THE COIL HAD MELTED SEVERELY. THE REPAIR SHOP INFORMED THE CONSUMER, THE COIL WOULD NOT CONNECT WITH THE COMPUTER. THE REPAIR SHOP INFORMED THE CONSUMER, THE DEALERSHIP WOULD NEED TO PROGRAM IT. THE DEALER INFORMED THE CONSUMER FIVE MORE COIL NEEDED TO BE REPLACED AS WELL AS THE COMPUTER.

NHTSA ODI #10483061

53,000 miles · Aug 5, 2010

Engine And Engine Cooling

Read full complaint

WHILE THE VEHICLE WAS RUNNING, BUT PARKED, THE A/C SUDDENLY STOPPED WORKING. AIR CONTINUED TO BLOW, BUT IT WAS HOT INSTEAD OF COOL. DIAGNOSTIC REPORT SAYS THE ACET SENSOR FAILED. REPAIR WAS DECLINED DUE TO COST ($550). NOW, EVEN WITHOUT ANY CLIMATE CONTROLS ENGAGED, THE PANEL GETS VERY HOT WHEN THE CAR IS RUNNING. IF THE SEAT A/C IS ENGAGED, IT WILL WORK UNTIL THE PANEL GETS HOT, THEN IT WON'T WORK ANYMORE. IF THE FAILED ACET SENSOR IS RESPONSIBLE FOR THE OVERHEATING BEHIND THE CLIMATE CONTROL PANEL, IT MAY BE A SAFETY ISSUE AND NOT JUST A COMFORT ISSUE. *TR

NHTSA ODI #10347425

Official recalls

21V158000 · Air Bags:frontal:driver Side:inflator Module

Mar 10, 2021

Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.

19V904000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Dec 18, 2019

Ford Motor Company (Ford) is recalling certain 2006-2010 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ vehicles. The valves within the ABS Hydraulic Control Units (HCU) may react with brake fluids containing specific corrosion preventative additives. This reaction may cause the valves to not close properly.

Consequence & remedy

Consequence: If the valves do not properly close, additional brake pedal travel may be required to stop the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will flush the brake system with DOT 4 fluid and install a new brake fluid reservoir cap. In addition, the HCU will be tested to detect a possible stuck valve condition, replacing the HCU as necessary. All services will be performed free of charge. The recall began April 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S54.

17V024000 · Air Bags:frontal:passenger Side:inflator Module

Jan 10, 2017

Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

16V384000 · Air Bags:frontal:passenger Side:inflator Module

May 31, 2016

Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.