IllustrationIDLE AIR CONTROL AND MASS AIR FLOW SENSOR CAUSING VEHICLE TO STALL WHEN MAKING TURNS IN FRONT OF ONCOMING TRAFFIC. NLM
1996 Lincoln Town Car
Owner reports · Recalls · Investigations
More warning signs than most Town Car years
Owner complaints for the 1996 Lincoln Town Car are substantially higher than the model-year median of 86.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Town Car years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
625–50K
2150–75K
3275–100K
32100–150K
14150K+
109 reports with mileage · 150 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 90 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports11 fire reports7 injury reports
Fuel System, Other complaints
1 reportsOfficial recalls
807V336000 · Vehicle Speed Control
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
01V318000 · Air Bags:frontal:driver Side:inflator Module
Oct 3, 2001
EQUIPMENT DESCRIPTION: PASSENGER VEHICLES THAT HAVE HAD THE DRIVER'S AIR BAG MODULE REPLACED AFTER APRIL 5, 2000. THE REPLACEMENT DRIVER'S AIR BAG MODULE INFLATOR MAY HAVE INSUFFICIENT WELDS THAT COULD PREVENT PROPER INFLATION OF THE AIR BAG.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIR BAG MAY NOT PROPERLY DEPLOY WHICH COULD POTENTIALLY RESULT IN LESS THAN THE INTENDED LEVEL OF OCCUPANT PROTECTION.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER'S AIR BAG MODULE. OWNER NOTIFICATION BEGAN OCTOBER 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
00V157001 · Seat Belts:front:anchorage
Jun 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET DRIVER'S SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Consequence & remedy
Consequence: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
00V157002 · Seat Belts:front:anchorage
Jun 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET FRONT PASSENGER SIDE SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Consequence & remedy
Consequence: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
98V322000 · Suspension:front:control Arm:lower Ball Joint
Dec 16, 1998
VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence & remedy
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
96V135000 · Steering:linkages
Jul 18, 1996
THE PITMAN ARMS WERE NOT FULLY LUBRICATED AT THE ASSEMBLY PLANT. THE "BALL JOINT" AT THE OUTER END OF THE PITMAN ARM CAN BECOME CONTAMINATED AND CORRODE.
Consequence & remedy
Consequence: SUCH CORROSION CAN RESULT IN ABNORMAL WEAR OF THE JOINT, RESULTING IN SEPARATION OF THE JOINT. LOSS OF STEERING CONTROL CAN OCCUR INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE VEHICLES AND IF THE JOINT IS FOUND TO HAVE SIGNIFICANT WEAR, THE ARM WILL BE REPLACED. THOSE PITMAN ARMS NOT REPLACED WILL HAVE THE "BALL JOINT" FULLY GREASED.
96V109000 · Seat Belts:rear/other
Jun 24, 1996
THE ELR/ALR FEATURE IS USED TO ACCOMMODATE CHILD RESTRAINTS. WHEN SERVICING THE REAR BELT ASSEMBLIES, WRONG PARTS COULD HAVE BEEN USED WHICH DO NOT CONTAIN THE AUTOMATIC LOCKING FEATURE.
Consequence & remedy
Consequence: IN THE EVENT OF AN ACCIDENT, THE SEAT BELT ASSEMBLIES MAY NOT PROPERLY SECURE THE CHILD RESTRAINT INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL REPLACE THE REAR BELT ASSEMBLIES WITH THE APPROPRIATE DESIGN RETRACTOR AND TONGUE ASSEMBLIES.
96V070000 · Latches/locks/linkages:doors:latch
Apr 22, 1996
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA03012 · Rear Brake Line Failure
Opened Jul 25, 2003 · Closed Apr 11, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Service Brakes, Hydraulic:fluid
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Service Brakes, Hydraulic
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
RQ03004 · Rear Brake Line Failure
Opened Mar 11, 2003 · Closed Jul 25, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Additional source detail variants (4)
Service Brakes, Hydraulic:fluid
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic:foundation Components
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
RQ03002 · Ball Joint Separation
Opened Jan 3, 2003 · Closed Jun 3, 2003
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available