IllustrationAIR BAGS ARE VERY LOUD AND THEY RUN OFTEN AIR CONDITIONING IN REAR MAKES A POPPING NOISE AIR CONDITIONING IN BLOWS THROUGH FLOOR VENTS WHEN I ACCELERATE I HAVEN'T BEEN ABLE TO FIX IT BECAUSE IT IS TOO EXPENSIVE. *TR
2005 Lincoln Navigator
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Lincoln Navigator do not stand out strongly from the model-year median of 30.
About this comparison →How this year compares
Owner complaints by model year
Compare all Navigator years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
100–25K
125–50K
1450–75K
775–100K
5100–150K
2150K+
39 reports with mileage · 9 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports2 fire reports3 injury reports
Engine And Engine Cooling complaints
5 reportsTL*THE CONTACT OWNS 2005 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THEY HAD TO REPLACE THE ENGINE SINCE THE HEAD GASKET WAS DEFECTIVE AND THERE WAS A PISTON THAT CAUSED METAL SHAVINGS TO ENTER THE ENGINE. THE VEHICLE WAS DIAGNOSED BY THE DEALER SEVERAL TIMES SINCE A KNOCKING SOUND WAS IN THE ENGINE. THE DEALER WAS UNABLE TO FIN…
Read full complaint
TL*THE CONTACT OWNS 2005 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THEY HAD TO REPLACE THE ENGINE SINCE THE HEAD GASKET WAS DEFECTIVE AND THERE WAS A PISTON THAT CAUSED METAL SHAVINGS TO ENTER THE ENGINE. THE VEHICLE WAS DIAGNOSED BY THE DEALER SEVERAL TIMES SINCE A KNOCKING SOUND WAS IN THE ENGINE. THE DEALER WAS UNABLE TO FIND THE SOURCE OF THE KNOCKING SOUNDS IN THE ENGINE. SINCE THE VEHICLE WAS 5000 MILES OVER THE WARRANTY THE ENGINE FAILED. THE DEALER INSPECTED THE ENGINE AND STATED THAT IN NEEDED TO BE REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 55000. UPDATED 11/05/10. *LJ
LTR FROM SENATOR HUTCHISON ON BEHALF OF CONSTITUENT, RE PROBLEMS WITH HER 2005 LINCOLN NAVIGATOR. *NJ THE CONSUMER STATED THERE WAS A NOISE COMING FROM THE ENGINE. THE FRONT END VIBRATED CONSTANTLY. THE CONSUMER WAS INFORMED THE TRACK BAR AND CAD MOUNT BUSHINGS NEEDED TO BE REPLACED TO CORRECT THE VIBRATING. THE SUNROOF LEAKE…
Read full complaint
LTR FROM SENATOR HUTCHISON ON BEHALF OF CONSTITUENT, RE PROBLEMS WITH HER 2005 LINCOLN NAVIGATOR. *NJ THE CONSUMER STATED THERE WAS A NOISE COMING FROM THE ENGINE. THE FRONT END VIBRATED CONSTANTLY. THE CONSUMER WAS INFORMED THE TRACK BAR AND CAD MOUNT BUSHINGS NEEDED TO BE REPLACED TO CORRECT THE VIBRATING. THE SUNROOF LEAKED, THE CD CHANGER SCRATCHED THE CD'S, THE DRIVERS SEAT WAS REPAIRED 3 TIMES, THE TIRE PRESSURE SENSOR DIDN'T WORK, THE REMOTE START DID NOT WORK, THE TRANSMISSION WAS SLIPPING, THE REAR WINDOWS WERE GRINDING, THE DRIVERS SIDE DOOR WOULD NOT OPEN, THE MIRROR WOULD NOT ADJUST AND THE WIPERS WERE REPLACED. THE CONSUMER STATED AFTER TWO YEARS OF BEING TOLD THERE WAS NOTHING WRONG WITH THE VEHICLE, IT FINALLY BROKE DOWN AND THE DEALER HAD TO PERFORM MAJOR ENGINE WORK. AFTER THE ENGINE WORK WAS COMPLETED THE CONSUMER STATED THE ENGINE CONTINUED TO MAKE NOISE AND THERE WAS ALSO HESITATION PROBLEMS. *JB UPDATED 03/01/10.
2005 LINCOLN NAVIGATOR HAS HAD LOSS OF POWER ON MULTIPLE OCCASIONS. I HAVE HAD THE VEHICLE SINCE NEW AND I HAVE TAKEN IT TO THE FORD DEALERS IN THE AREA 3 TIMES TO HAVE THE PROBLEM FIXED. DEALER HAS BEEN ABLE TO DUPLICATE THE PROBLEM BUT DOES NOT HAVE A SOLUTION TO FIX IT. VEHICLE HESITATES AND DOES NOT ACCELERATE CREATING A …
Read full complaint
2005 LINCOLN NAVIGATOR HAS HAD LOSS OF POWER ON MULTIPLE OCCASIONS. I HAVE HAD THE VEHICLE SINCE NEW AND I HAVE TAKEN IT TO THE FORD DEALERS IN THE AREA 3 TIMES TO HAVE THE PROBLEM FIXED. DEALER HAS BEEN ABLE TO DUPLICATE THE PROBLEM BUT DOES NOT HAVE A SOLUTION TO FIX IT. VEHICLE HESITATES AND DOES NOT ACCELERATE CREATING A SERIOUS HAZARD WHEN ACCELERATION IS NEEDED. FORD HAS NO SOLUTION TO REPAIR THE PROBLEM AND I WAS TOLD TO CONTINUE DRIVING THE VEHICLE AND KEEP A LOG OF WHEN THE PROBLEM EXISTS (IE; WEATHER, TIME DATE ECT). *NM
MY CAR CONTINUES TO SHUT OFF WHILE DRIVING, HAVE HAD IT SERVICED ALREADY 3 TIMES AND THE PROBLEM PERSISTS. *JB
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.