Engine. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

6 crash reports4 fire reports4 injury reports

Exterior Lighting complaints

4 reports

Clear category filter

Mileage unknown · Jun 30, 2021

Exterior LightingPower TrainUnknown Or Other

Read full complaint

1) Every used miz I test drove had a super hard jerk out of first gear including the one I purchased, I was told it was fine, went to another dealership and was told the transmission clutch was gone, repaired under warranty. 2) Gas tank door spring failed, saw its a common problem with Ford Lincoln vehicles, dealer replaced entire door housing sleeve, not covered under warranty, had to be installed twice after coming out after incorrectly installed. 3) Front headlights lens spider web cracking. When purchased I saw small stress cracks at top by hood 3 to 7 months later entire lens/globe housing look like shattered glass but still in tacted, not covered under warranty, now passenger light starting to look the same. Only had the car 13 months. Dealer service rep ask do I drive car alot or drive in the rain, I was shocked. 4) Rear trunk tail light across entire back end full of moisture. Not covered under warranty. Every since 2007 this seem to be a common problem with every car I had to poor designed product that consumer have to pay for and shouldn't. It will cost thousands of dollars to replace.

NHTSA ODI #11422885

53,000 miles · Jun 29, 2021

Exterior Lighting

The contact owns a 2017 Lincoln MKZ. The contact stated that the headlight housing was cracked. The vehicle was diagnosed but not repaired. The manufacturer was informed of the failure and informed the contact that the Vin was not under recall. The failure mileage was approximately 53,000.

NHTSA ODI #11422848

Mileage unknown · Jun 23, 2021

Exterior Lighting

The daytime running lights fail to illuminate which is a safety hazard. A message to check the headlights is displayed on the dashboard ONLY when the car is started with the remote start feature. This is a known problem as confirmed by technical service bulletin (TSB #SSM 46508)

NHTSA ODI #11422046

Mileage unknown · Jul 10, 2017

Electrical SystemExterior Lighting

2017 LINCOLN MKZ. CONSUMER WRITES IN REGARDS TO COMPUTER TOUCH SCREEN MALFUNCTION, HEADLIGHTS CONTROL SWITCH PROBLEMS. *LD THE CONSUMER STATED WITHIN THE FIRST MONTH OF PURCHASING THE VEHICLE THE TOUCH SCREEN WOULD SHUT DOWN AND REBOOT ITSELF WHILE DRIVING. THE SWITCH THAT CONTROLS THE HEADLIGHTS WAS ALSO FAULTY. UPDATED 0…

Read full complaint

NHTSA ODI #11001069

Official recalls

23V162000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

Mar 10, 2023

Ford Motor Company (Ford) is recalling certain 2013-2018 Fusion and Lincoln MKZ vehicles. The front brake hoses may rupture and leak brake fluid.

Consequence & remedy

Consequence: A brake fluid leak will increase brake pedal travel and extend the distance needed to stop the vehicle, increasing the risk of a crash.

Remedy: Dealers will replace the front brake hoses, free of charge. Owner notification letters were mailed June 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S12.

18V390000 · Power Train:automatic Transmission:torque Converter

Jun 11, 2018

Ford Motor Company (Ford) is recalling certain 2017-2018 Ford Edge and 2017 Lincoln MKZ vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.

Consequence & remedy

Consequence: If the torque converter weld studs fail, the torque converter will not be connected to the engine flexplate and the vehicle will lose the ability to move, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the torque converters, free of charge. The recall began on July 5, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S16 (S2). Note: This recall is an expansion of recall 17V-427.

18V167000 · Steering: Steering Wheel/handle Bar

Mar 12, 2018

Ford Motor Company (Ford) is recalling certain 2014-2018 Lincoln MKZ and Ford Fusion vehicles. The steering wheel retaining bolt may loosen allowing the steering wheel to detach while driving.

Consequence & remedy

Consequence: A steering wheel detachment can cause a loss of steering control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the steering wheel bolt with a longer bolt, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S08.

17V427000 · Power Train:automatic Transmission:torque Converter

Jul 6, 2017

Ford Motor Company (Ford) is recalling certain 2017 Lincoln MKZ and Ford Edge and Fusion vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.

Consequence & remedy

Remedy: Ford or Lincoln will notify owners, and dealers will replace the torque converters, free of charge. The recall began August 25, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S16.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ22004 · Front Brake Jounce Hose Failures

Opened Aug 8, 2022 · Closed Mar 24, 2023

Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On August 8, 2022, the Office of Defects Investigation (ODI) opened this investigation based on 50 Vehicle Owner Questionnaires (VOQs) alleging front brake jounce hose ruptures on model year (MY) 2013-2018 Ford Fusion and Lincoln MKZ vehicles. A ruptured front brake hose results in a brake fluid leak. As a result, the driver may experience an increase in pedal travel and a reduction in the rate of deceleration, increasing the risk of a crash. It should be noted that the subject vehicles identified fell outside the scope of NHTSA Safety Recall 20V-469, which addressed front brake hoses rupturing on certain MY 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The result causes a brake fluid leak, lengthening the distance needing to stop the vehicle, increasing the risk of a crash.On March 10, 2023, Ford Motor Company (Ford) submitted to NHTSA Safety Recall 23V-162 (Ford Recall 23S12) to address front brake jounce hoses that may rupture. Ford found the rupture occurs from a localized failure of the internal reinforcement braid due to cyclic fatigue through tensile/bending and torsional inputs during suspension and steering articulations. The supplier for the front brake jounce hoses is Hitachi. This recall affects the subject vehicles equipped with non-hybrid engines and the suspect front brake jounce hoses (a total of 1,280,726 vehicles). The recall covers subject vehicles built from February 3, 2012 to July 19, 2017 when the suspect hoses were used in vehicle production. The remedy is for dealerships to replace both front brake jounce hoses with new hoses that have a revised braid material at no cost. The vehicles equipped with hybrid engines are excluded from the recall because the internal hose pressure is much lower due to the regenerative braking provided by the hybrid brake system. No failures of brake hoses on hybrid vehicles have been reported to ODI or Ford.Ford's actions address ODIs concerns at this time. Hybrid vehicles will be monitored for related failures. The agency reserves the right to take further action if warranted by new circumstances.The 103 ODI numbers cited above can be viewed at NHTSA.gov under the following ID numbers:11511014, 11510867, 11510318, 11509030, 11505993, 11504989, 11504400, 11502147, 11502082, 11501820, 11501283, 11498439, 11498296, 11496842, 11496335, 11494931, 11494851, 11494252, 11493001, 11492084, 11492070, 11491444, 11491274, 11488858, 11488027, 11487627, 11487416, 11487233, 11486150, 11484924, 11484526, 11484080, 11483948, 11483926, 11483739, 11483723, 11482773, 11482690, 11481077, 11480788, 11480294, 11480052, 11479338, 11479334, 11479252, 11479247, 11479187, 11479094, 11479048, 11478985, 11478953, 11478729, 11478216, 11476892, 11476282, 11470558, 11468994, 11467109, 11466294, 11462746, 11461217, 11456065, 11455367, 11444848, 11436419, 11436376, 11430685, 11428329, 11425083, 11421026, 11420738, 11420735, 11420298, 11418197, 11403926, 11397549, 11366991, 11366757, 11361016, 11359968, 11354569, 11352165, 11350344, 11348799, 11343929, 11343205, 11331947, 11329020, 11319596, 11310529, 11292271, 11288455, 11254787, 11253479, 11253244, 11234622, 11230669, 11230050, 11228240, 11221111, 11143630, 11129392 and 11120228.