NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
52 reportsMileage unknown · Jun 5, 2020
Electrical System
TL* THE CONTACT OWNS A 2017 LINCOLN MKX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V809000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. BRINSON FORD LOCATED AT 1951 E. H…
Read full complaint
TL* THE CONTACT OWNS A 2017 LINCOLN MKX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V809000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. BRINSON FORD LOCATED AT 1951 E. HIGHWAY 31, CORSICANA, TX 75110, (903) 874-8880, AND THE MANUFACTURER WAS NOTIFIED BUT NO ASSISTANCE WAS OFFERED. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #11327381
40,000 miles · Apr 2, 2020
EnginePower TrainVehicle Speed Control
10 MILES AFTER STARTING OUR 2017 LINCOLN MKX IT SUDDENLY GAVE ME THE WARNING CODE OF ERROR: VEHICLE SHUTTING DOWN NOW. THE CAR COASTED ACROSS 5 LANES OF SPEEDING TRAFFIC. I ALMOST DIED WITH OUR SMALL CHILD IN THE CAR. THE CAR RESTARTED FINE ON THE SIDE OF THE ROAD. SANDERSON LINCOLN TOWED THE CAR AND DID THE BARE MINIMUM TEST…
Read full complaint
10 MILES AFTER STARTING OUR 2017 LINCOLN MKX IT SUDDENLY GAVE ME THE WARNING CODE OF ERROR: VEHICLE SHUTTING DOWN NOW. THE CAR COASTED ACROSS 5 LANES OF SPEEDING TRAFFIC. I ALMOST DIED WITH OUR SMALL CHILD IN THE CAR. THE CAR RESTARTED FINE ON THE SIDE OF THE ROAD. SANDERSON LINCOLN TOWED THE CAR AND DID THE BARE MINIMUM TESTS ON THE CAR PER THE MANUFACTURER STANDARDS. I REQUESTED THEM TO DO MORE AS THIS EXACT SAME SITUATION HAS HAPPENED TO OTHER LINCOLN OWNERS MULTIPLE TIMES IN ONE CAR. THERE HAS ALSO BEEN A RECALL ON THIS ON PREVIOUS YEARS. THIS VEHICLE ALSO HAD SOME STRANGE ACCELERATION ISSUES WHEN WE INITIALLY BOUGHT IT AND IT WAS DISMISSED BY THE SERVICER. LINCOLN CUSTOMER SERVICE NOW TOLD US WE ARE OUT OF LEMON LAW AND THEY CANNOT HELP US. DUH. LINCOLN CUSTOMER SERVICE ALSO DID SHADY THINGS TO US. THEY WOULD CALL US AT 11PM FLORIDA TIME FROM A DUMMY PHONE LINE SO THAT THEY COULD "SAY" THEY CALLED US. THE SERVICER REPLACED OUR BATTERY AND CALLED IT A DAY. INITIALLY THE MANUFACTURER SEEMED OUTRAGED THAT THE BATTERY COMPLETELY FRIED ON THE VEHICLE DURING TESTING....THEN THEY SUDDENLY CHANGED THEIR TUNE AND SAID WE WERE OUT OF LEMON LAW IN OUR STATE.
NHTSA ODI #11320003
40,000 miles · Aug 17, 2019
Unknown Or Other
HAS CARBON MONOXIDE IN THE CABIN ON HIGHWAY DRIVING . I HAVE A CO METER AS I HAVE HAD THE CAR IN TO DEALER 7 TIMES FOR SAME ISSUE & IT IS STILL NOT FIXED. THEY NOW CLAIM IT IS OK BUT STILL HAVE 15 PPM IN 10 MINUTES OF DRIVING ON HIGHWAY AND LEVEL STILL RISING. THEY SAY THIS IS AN ACCEPTABLE LEVEL. I OPEN WINDOWS & CO LEVEL DROP…
Read full complaint
HAS CARBON MONOXIDE IN THE CABIN ON HIGHWAY DRIVING . I HAVE A CO METER AS I HAVE HAD THE CAR IN TO DEALER 7 TIMES FOR SAME ISSUE & IT IS STILL NOT FIXED. THEY NOW CLAIM IT IS OK BUT STILL HAVE 15 PPM IN 10 MINUTES OF DRIVING ON HIGHWAY AND LEVEL STILL RISING. THEY SAY THIS IS AN ACCEPTABLE LEVEL. I OPEN WINDOWS & CO LEVEL DROPS TO 2PPM. THEN CLOSE WINDOWS & METER READS AGAIN IN 15 MIN 15PPM. THIS CAR IS NOT SAFE. & LINCOLN WILL NOT TAKE IT BACK. PLEASE CONTACT ME & TAKE CAR FOR TESTING IF YOU WISH I HAVE 3 MONTHS LEFT ON LEASE .THEN SOMEONE NEW WILL DIE DRIVING THIS NOT KNOWING THIS ISSUE. THIS HAS BEEN GOING ON FOR 2.5 YEARS DOES NOT HAVE ISSUE IN CITY DRIVING METER DOES NOT MOVE OVER 3PPM . ONLY ON HIGHWAY DRIVING. EVEN MORE WHEN CLIMBING GRADES . LEVELS GO UP TO 15PPM IN 5-8 MIN. THEN OF COURSE I OPEN WINDOWS. LAST FIX 8-15-19 THEY CLAIM TO HAVE FIXED A BAD BACK DOOR SEAL. DID NOT CHANGE LEVELS WHEN DRIVING ON HIGHWAY SAME .
NHTSA ODI #11244588
8,000 miles · Aug 16, 2019
Engine
I WAS DRIVING AT 50 MPH ON A MAIN HIGHWAY WHEN SUDDENLY HEARD A BELL TONE, THE CAR BEGAN TO SLOW DOWN, THE ENGINE HAD SHIFTED INTO NEUTRAL AND THE MESSAGE CENTER STATED THE ENGINE WAS SHUTTING OFF. I STEERED TO THE SIDE OF THE ROAD AND RESTARTED THE ENGINE. THIS HAS LEFT ME QUITE SHAKEN AS WE HAVE ONLY OWNED THIS VEHICLE FOR A…
Read full complaint
I WAS DRIVING AT 50 MPH ON A MAIN HIGHWAY WHEN SUDDENLY HEARD A BELL TONE, THE CAR BEGAN TO SLOW DOWN, THE ENGINE HAD SHIFTED INTO NEUTRAL AND THE MESSAGE CENTER STATED THE ENGINE WAS SHUTTING OFF. I STEERED TO THE SIDE OF THE ROAD AND RESTARTED THE ENGINE. THIS HAS LEFT ME QUITE SHAKEN AS WE HAVE ONLY OWNED THIS VEHICLE FOR A LITTLE OVER 2 WEEKS AND DO NOT KNOW WHAT TO EXPECT. WE HAVE SEEN THIS HAS OCCURRED WITH OTHER OWNERS, ALSO.
NHTSA ODI #11244537
27,000 miles · Jul 10, 2019
Electrical System
WE HAD TAKEN OUR LINCOLN FOR WARRANTY WORK ON THE NAVIGATION/STEREO AND IT WAS DETERMINED A PART NEEDED TO BE ORDERED. WE WERE TOLD WE COULD DRIVE THE CAR WHILE WAITING ON THE PART TO ARRIVE BUT WHEN WE WENT TO PICK IT UP OUR CAR WOULD NOT START. THE DEALERSHIP CHARGED THE BATTERY AND RAN IT THROUGH SOME TESTS AND EVERYTHING CHE…
Read full complaint
WE HAD TAKEN OUR LINCOLN FOR WARRANTY WORK ON THE NAVIGATION/STEREO AND IT WAS DETERMINED A PART NEEDED TO BE ORDERED. WE WERE TOLD WE COULD DRIVE THE CAR WHILE WAITING ON THE PART TO ARRIVE BUT WHEN WE WENT TO PICK IT UP OUR CAR WOULD NOT START. THE DEALERSHIP CHARGED THE BATTERY AND RAN IT THROUGH SOME TESTS AND EVERYTHING CHECKED OUT SO WE PICKED IT UP THE NEXT DAY. ONE DAY LATER THE VEHICLE ONCE AGAIN WOULD NOT START. DEALERSHIP ONCE AGAIN CHARGED BATTERY AND RAN IT THROUGH TESTS AND ONCE AGAIN EVERYTHING CHECKED OUT. WE DECIDED TO LEAVE THE VEHICLE AT THE DEALERSHIP UNTIL THE PART FOR THE NAVIGATION/STEREO WAS REPLACED AND THEN PICKED IT UP. WE DROVE IT ABOUT A WEEK WITH ABSOLUTELY NO PROBLEMS UNTIL I WAS PULLING OUT OF A PARKING LOT INTO A STREET AND MY CAR LOST ALL POWER INCLUDING STEERING WITHOUT ANY WARNING. I MANAGED TO COAST INTO A SINGLE LANE SO I WASNT BLOCKING THE ENTIRE STREET. MY CAR WOULD NOT RESTART GIVING A MESSAGE ABOUT POWER FAILURE OR POWER OFF ON THE DISPLAY. I TRIED RESTARTING SEVERAL TIMES WHILE SITTING BLOCKING TRAFFIC INCLUDING TAKING THE KEY FOB OUT OF THE CAR COMPLETELY FOR A FEW MINUTES THEN PLACING IT BACK IN THE CAR HOPING SOMETHING WOULD RESET AND STILL HAD NO LUCK. A TOW TRUCK ARRIVED AND TOWED MY LINCOLN INTO THE DEALERSHIP WHERE IT STARTED RIGHT UP SO NO CODE COULD BE FOUND. THE DEALERSHIP HAS NO WAY TO FIX THE ISSUE WITHOUT CODES. I FEEL LUCKY THIS PROBLEM HAS ONLY OCCURED IN RELATIVELY CALM TRAFFIC AND NOT WHILE I WAS ON THE INTERSTATE WHERE THIS ISSUE COULD BE DEADLY.
NHTSA ODI #11231310
10 miles · Jul 6, 2019
Engine
DURING HARD ACCELERATION, THE SMELL OF ROTTEN EGGS ENTERS THE CABIN REGARDLESS OF WHAT TYPE OF FAN IS BLOWING (AIR CONDITIONING - FRESH AIR OR RECIRCULATE). LINCOLN UNDER A TSB CLAIMED THAT THEY FIXED THE PROBLEM BY RESEALING THE REAR SEALS TO THE REAR HATCH. THE SMELL CONTINUES AND IF YOU DO RESEARCH, THIS IS A WIDESPREAD PROBL…
Read full complaint
DURING HARD ACCELERATION, THE SMELL OF ROTTEN EGGS ENTERS THE CABIN REGARDLESS OF WHAT TYPE OF FAN IS BLOWING (AIR CONDITIONING - FRESH AIR OR RECIRCULATE). LINCOLN UNDER A TSB CLAIMED THAT THEY FIXED THE PROBLEM BY RESEALING THE REAR SEALS TO THE REAR HATCH. THE SMELL CONTINUES AND IF YOU DO RESEARCH, THIS IS A WIDESPREAD PROBLEM IN FORD EDGE'S, EXPLORER'S AND LINCOLN MKX'S. FORD DOESN'T SEEM TO THINK THAT EXHAUST ENTERING THE CABIN FOR WHICH THEY DO NOT HAVE FIX FOR IS WORTHY OF A SYSTEM WIDE RECALL. I SUSPECT THAT CARBON MONOXIDE AND OTHER POISONOUS GASES ARE ENTERING THE CABIN AND CANNOT BE GOOD FOR THE OCCUPANTS... THIS ISSUE WAS PRESENT FROM THE FIRST DAY I LEASED THE VEHICLE.
NHTSA ODI #11229749
42,000 miles · Feb 25, 2019
Electrical SystemEngineFuel/propulsion System
THE CAR SHUTS OFF WITHOUT WARNING WHEN YOU ARE DRIVING. IT HAS HAPPENED 6 TIMES IN THE LAST 3 MONTHS. THE POWER STEERING SHUTS OFF AND THE CAR COMES TO A COMPLETE STOP BEFORE YOU ARE ABLE TO TRY TO RESTART THE CAR. THIS IS A VERY SERIOUS SAFETY ISSUE WHEN THIS HAPPENS ON A BUSY HIGHWAY AND YOU ARE IN THE FAST LANE OR MAKING A…
Read full complaint
THE CAR SHUTS OFF WITHOUT WARNING WHEN YOU ARE DRIVING. IT HAS HAPPENED 6 TIMES IN THE LAST 3 MONTHS. THE POWER STEERING SHUTS OFF AND THE CAR COMES TO A COMPLETE STOP BEFORE YOU ARE ABLE TO TRY TO RESTART THE CAR. THIS IS A VERY SERIOUS SAFETY ISSUE WHEN THIS HAPPENS ON A BUSY HIGHWAY AND YOU ARE IN THE FAST LANE OR MAKING A LEFT TURN ACROSS ONCOMING TRAFFIC. I TOOK THE CAR TO A LOCAL DEALER (JERRY'S FORD OF LEESBURG VA) AND IT IS NOT SHOWING ANY MAINTENANCE CODES FOR THE ISSUE AND THEY SAID THERE IS NOTHING THEY CAN DO. I SPOKE TO FORD (CASE# CAS-17221031-Z4L4R3) AND THEY SAID TO DRIVE THE CAR UNTIL THE ISSUE HAPPENS AGAIN AND HAVE IT TOWED BACK TO THE DEALER AS RESTARTING THE CAR WILL CLEAR THE MAINTENANCE CODE. I TOLD FORD THIS WAS UNACCEPTABLE DUE TO THIS BEING A VERY SERIOUS SAFETY ISSUE AND I DIDN'T THINK IT WAS A GOOD IDEA TO PUT SOMEONE'S LIFE AT RISK TO TROUBLE SHOOT THE PROBLEM WITH THE CAR. FORD HAS NO OTHER OPTIONS AT THIS TIME. FROM RESEARCH I HAVE DONE ONLINE I CAN SEE OTHER PEOPLE HAVE HAD THIS SAME EXACT ISSUE. NHTSA ID NUMBERS 11047965 AND 11055106 SEEM TO BE THE SAME ISSUE.
NHTSA ODI #11182361
8,000 miles · Dec 5, 2018
Unknown Or Other
STRONG SMELL OF EXHAUST LEAKAGE COMING FROM REAR OF VEHICLE WHEN ACCELERATING. OTHER OWNER OF MKX HAD SAME PROBLEM AND DEALER HAS CORRECTED.
NHTSA ODI #11156123
30,000 miles · Mar 26, 2018
VisibilityVisibility/wiper
TL* THE CONTACT OWNS A 2017 LINCOLN MKX. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE SUN ROOF CRACKED WITHOUT IMPACT. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #11081298
22,000 miles · Sep 20, 2017
Electrical SystemPower Train
TL* THE CONTACT OWNS A 2017 LINCOLN MKX. THE CONTACT STATED THAT THE VEHICLE WAS DESIGNED TO HAVE A TOW MODE, WHICH WOULD ALLOW THE VEHICLE TO TOW. WHILE THE 39,000 LBS VEHICLE WAS TOWING A 50,000 LBS RV, THE VEHICLE'S BATTERY FAILED. THE VEHICLE WAS DESIGNED TO GO INTO PARK MODE, WHICH LOCKED ALL FOUR TIRES WHEN THE BATTERY FAI…
Read full complaint
TL* THE CONTACT OWNS A 2017 LINCOLN MKX. THE CONTACT STATED THAT THE VEHICLE WAS DESIGNED TO HAVE A TOW MODE, WHICH WOULD ALLOW THE VEHICLE TO TOW. WHILE THE 39,000 LBS VEHICLE WAS TOWING A 50,000 LBS RV, THE VEHICLE'S BATTERY FAILED. THE VEHICLE WAS DESIGNED TO GO INTO PARK MODE, WHICH LOCKED ALL FOUR TIRES WHEN THE BATTERY FAILED. ONCE THE VEHICLE WENT INTO PARK MODE, IT CAUSED THE VEHICLE TO BE DRAGGED BY THE RV FOR SEVERAL MILES. THE CONTACT STATED THAT THE PARK MODE FEATURE SHOULD NOT OCCUR SINCE THE VEHICLE WAS IN NEUTRAL WHEN IN TOW MODE. THE CONTACT CALLED CAMELBACK FORD (1330 E CAMELBACK ROAD, PHOENIX, AZ 85014; 602-635-7551) AND WAS INFORMED THAT THE VEHICLE FUNCTIONED AS EXPECTED ACCORDING TO THE DESIGN OF THE FEATURE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE, BUT THE CONTACT DID NOT RECEIVE A RESPONSE. THE APPROXIMATE FAILURE MILEAGE WAS 22,000.
NHTSA ODI #11024701
Official recalls
5Aug 22, 2025
Ford Motor Company (Ford) is recalling certain 2016-2018 Lincoln MKX and 2015-2018 Edge vehicles. The rear brake jounce hose may rupture and leak brake fluid.
Consequence & remedy
Consequence: A brake fluid leak can extend the distance required to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the brake jounce hoses and adjust brake jounce hoses with no damage present, free of charge. Interim owner letters notifying owners of the safety risk were mailed September 8, 2025. Additional letters will be sent once the remedy is available, anticipated August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S87.
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence & remedy
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Additional source detail variants (2)
Service Brakes
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Jul 17, 2020
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence & remedy
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Additional source detail variants (3)
Seats:front Assembly:power Adjust
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Air Bags
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Electrical System:wiring:interior/under Dash
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2016-2017 Lincoln MKX vehicles equipped with 3.7L engines. The battery positive cable harness may contact the transmission shifter cable bracket resulting in a short circuit.
Consequence & remedy
Consequence: An electrical short increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will remove the battery harness clips and elbow guide, and install a wire channel shield and protective sleeve to the battery cable harness, free of charge. Interim notices informing owners of the safety risk were mailed on December 2, 2019. Owners will receive a second notice when the remedy becomes available, currently expected to be the end of April 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S41.
Feb 27, 2017
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Edge and Lincoln MKX vehicles and 2017 Lincoln Continental vehicles. In the event of a crash, the driver's frontal air bag may not fully inflate or the air bag cushion may detach from the air bag module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: During deployment, if the air bag does not fully inflate or the cushion detaches, there is an increased risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the driver frontal air bag module, free of charge. The recall began June 16, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration