NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
32 reportsClear category filter1,065 miles · Oct 28, 2016
EngineFuel/propulsion SystemVehicle Speed Control
VEHICLE PURCHASED FEBRUARY 2016. ON MARCH 15, 2016 (1,065 MILES), DRIVING VEHICLE APPROACHING AN INTERSECTION ON A BUSY STREET TO MAKE A LEFT TURN ONTO A MAJOR HIGHWAY ON-RAMP, VEHICLE LOST POWER WHILE IN MOTION AND APPEARED TO ENTER "ACCESSORY MODE". WAS ABLE TO BRING VEHICLE TO STOP (IN THE MIDDLE OF THE INTERSECTION), PUT I…
Read full complaint
VEHICLE PURCHASED FEBRUARY 2016. ON MARCH 15, 2016 (1,065 MILES), DRIVING VEHICLE APPROACHING AN INTERSECTION ON A BUSY STREET TO MAKE A LEFT TURN ONTO A MAJOR HIGHWAY ON-RAMP, VEHICLE LOST POWER WHILE IN MOTION AND APPEARED TO ENTER "ACCESSORY MODE". WAS ABLE TO BRING VEHICLE TO STOP (IN THE MIDDLE OF THE INTERSECTION), PUT IT IN PARK AND RESTART THE VEHICLE. BROUGHT IT IMMEDIATELY TO LINCOLN SERVICE DEPARTMENT. SERVICE DEPARTMENT HAD VEHICLE FOR TWO DAYS AND COULD NOT DIAGNOSE OR REPLICATE THE PROBLEM. GAVE THE VEHICLE BACK TO ME WITHOUT ATTEMPTING ANY REPAIRS. ON MAY 14, 2016 (2,838 MILES), DRIVING AT LOW SPEED ON BACK ROADS, VEHICLE LOST POWER AGAIN WHILE IN MOTION AND ENTERED ACCESSORY MODE. BROUGHT IT IMMEDIATELY TO LINCOLN SERVICE DEPARTMENT. THE SERVICE DEPARTMENT COULD NOT REPLICATE THE ISSUE, BUT FOUND A TSB THAT THEY THOUGHT WOULD APPLY TO THE ISSUE. THE TECHNICIANS REPROGRAMMED THE SOFTWARE IN THE POWER CONTROL MODULE AND GAVE THE VEHICLE BACK TO ME. ON JUNE 25, 2016 (3,663 MILES), DRIVING AT LOW SPEED ON A MAIN ROAD, VEHICLE LOST POWER AGAIN WHILE IN MOTION AND ENTERED ACCESSORY MODE. BROUGHT IT IMMEDIATELY TO LINCOLN SERVICE DEPARTMENT. THE SERVICE DEPARTMENT KEPT THE VEHICLE FOR TWO WEEKS TO ATTEMPT TO REPLICATE THE PROBLEM. AFTER SPEAKING WITH LINCOLN CORPORATE ENGINEERS, THE TECHNICIANS REPLACED THE THROTTLE BODY, ASSUMING THAT WAS WHERE THE ISSUE WAS ORIGINATING. LINCOLN REFUSED TO REPLACE THE VEHICLE AND INSISTED THAT THE THROTTLE BODY WAS AT THE BOTTOM OF THE ISSUE. AS OF OCTOBER 28, 2016, THE VEHICLE HAS NOT LOST POWER AGAIN. *TR
NHTSA ODI #10919890
10,400 miles · Oct 18, 2016
EnginePower Train
WHILE DRIVING ON A HIGHWAY IN RUSH HOUR TRAFFIC, MY VEHICLE SUDDENLY LOST ACCELERATION AND WARNING LIGHT/WRENCH SYMBOL CAME ON. I COULD NOT ACCELERATE OVER 10 MPH AND LIMPED TO SIDE OF ROAD. I TURNED OFF VEHICLE FOR ABOUT 20 MINUTES, AFTER THAT TURNED BACK ON AND VEHICLE WORKED COMPLETELY NORMAL. I DROVE TO DEALER IMMEDIATELY…
Read full complaint
WHILE DRIVING ON A HIGHWAY IN RUSH HOUR TRAFFIC, MY VEHICLE SUDDENLY LOST ACCELERATION AND WARNING LIGHT/WRENCH SYMBOL CAME ON. I COULD NOT ACCELERATE OVER 10 MPH AND LIMPED TO SIDE OF ROAD. I TURNED OFF VEHICLE FOR ABOUT 20 MINUTES, AFTER THAT TURNED BACK ON AND VEHICLE WORKED COMPLETELY NORMAL. I DROVE TO DEALER IMMEDIATELY, THEY REPLACED THROTTLE BODY AND UPDATED SOFTWARE. MY VEHICLE HAS 10,400 MILES. *TR
NHTSA ODI #10917221
5,395 miles · Sep 30, 2016
Engine
MY HUSBAND AND I WERE ALMOST KILLED IN THE FAST LANE ON THE INTERSTATE WHEN OUR 2016 LINCOLN MKX SHUT DOWN COMPLETELY, WE HAD TO CROSS THREE LANES OF TRAFFIC WHEN IT STARTED AGAIN ONLY TO SHUT DOWN AGAIN, WE WERE TERRIFIED, IT WAS TOWED TO THE DEALERSHIP WHERE A RECALL WAS JUST ISSUED ON IT CALLED "THROTTLE BODY REPAIR" I ASKED…
Read full complaint
MY HUSBAND AND I WERE ALMOST KILLED IN THE FAST LANE ON THE INTERSTATE WHEN OUR 2016 LINCOLN MKX SHUT DOWN COMPLETELY, WE HAD TO CROSS THREE LANES OF TRAFFIC WHEN IT STARTED AGAIN ONLY TO SHUT DOWN AGAIN, WE WERE TERRIFIED, IT WAS TOWED TO THE DEALERSHIP WHERE A RECALL WAS JUST ISSUED ON IT CALLED "THROTTLE BODY REPAIR" I ASKED THE SERVICE MANAGER TO REPLACE THIS DEFECTIVE PART , NOT REPAIR IT AND HE DID SO. OUR SERVICE MANAGER WAS PROACTIVE IN THIS AND I PRAY TO GOD WE NEVER EXPERIENCE THIS TYPE OF SITUATION AGAIN. !
NHTSA ODI #10910708
12,000 miles · Sep 19, 2016
Electrical SystemEngine
ON 3 SEPARATE OCCASIONS (MOST RECENT ON 9/16/16) POWER TO VEHICLE SIMPLY CUTS OUT - ON TWO OCCASIONS IT HAS OCCURRED AT HIGH SPEEDS ON BUSY INTERSTATE WITH HEAVY TRAFFIC. EXTREME DANGER, AS UNABLE TO TIMELY PULL TO SIDE OF THE ROAD CAUSING TRAFFIC JAMS AND POTENTIAL ACCIDENTS/REAR-ENDS. SELLING DEALER HAS BEEN UNABLE TO RESOLV…
Read full complaint
ON 3 SEPARATE OCCASIONS (MOST RECENT ON 9/16/16) POWER TO VEHICLE SIMPLY CUTS OUT - ON TWO OCCASIONS IT HAS OCCURRED AT HIGH SPEEDS ON BUSY INTERSTATE WITH HEAVY TRAFFIC. EXTREME DANGER, AS UNABLE TO TIMELY PULL TO SIDE OF THE ROAD CAUSING TRAFFIC JAMS AND POTENTIAL ACCIDENTS/REAR-ENDS. SELLING DEALER HAS BEEN UNABLE TO RESOLVE OR FIX PROBLEM.
NHTSA ODI #10907519
4,052 miles · Sep 13, 2016
Engine
LOST POWER WHILE IN MOTION ON CITY STREET, BEGAN RUNNING ROUGH. 'POWERTRAIN' INDICATOR (WRENCH) LIT ON DASH. LIMPED CAR TO PARKING LOT. CALLED SELLING DEALER. CAR TOWED TO DEALER. DEALER REPLACED AIR INTAKE THROTTLE BODY ON WARRENTY. MILEAGE ON CAR 4052. PRODUCTION DATE ON CAR IS 07DEC15, 3.7L V6 ENGINE.
NHTSA ODI #10906203
7,000 miles · Sep 6, 2016
EngineUnknown Or Other
THE VEHICLE WHEN ACCELERATING LETS EXHAUST AND CARBON MONOXIDE INTO CAR INTERIOR. TOOK THE SUV TO DEALER AND HAS BEEN WORKED ON SEVERAL TIMES WITH NO FIX. FORD MOTOR COMPANY FIELD ENGINEER WAS UNABLE TO FINE AND RECOMMEND A REPAIR. ASKED FORD TO REPURCHASE VEHICLE BUT THEY REFUSED SAYING ITS NORM FOR THE SUV. THEY DID NOT …
Read full complaint
THE VEHICLE WHEN ACCELERATING LETS EXHAUST AND CARBON MONOXIDE INTO CAR INTERIOR. TOOK THE SUV TO DEALER AND HAS BEEN WORKED ON SEVERAL TIMES WITH NO FIX. FORD MOTOR COMPANY FIELD ENGINEER WAS UNABLE TO FINE AND RECOMMEND A REPAIR. ASKED FORD TO REPURCHASE VEHICLE BUT THEY REFUSED SAYING ITS NORM FOR THE SUV. THEY DID NOT GIVE ANY REGULATIONS OR ANYTHING THAT WOULD SUPPORT THIS AS WE SHOULD NOT HAVE TO BREATHE GAS FUMES WHEN TRAVELING DOWN A HIGHWAY. WE WERE TOLD NOT TO USE INTERIOR CIRCULATION AND IT WOULD HELP, NOT TO USE AIR THE VEHICLE WHEN ACCELERATING LETS EXHAUST AND CARBON MONOXIDE INTO CAR INTERIOR. TOOK THE SUV TO DEALER AND HAS BEEN WORKED ON SEVERAL TIMES WITH NO FIX. FORD MOTOR COMPANY FIELD ENGINEER WAS UNABLE TO FINE AND RECOMMEND A REPAIR. ASKED FORD TO REPURCHASE VEHICLE BUT THEY REFUSED SAYING ITS NORM FOR THE SUV. THEY DID NOT GIVE ANY REGULATIONS OR ANYTHING THAT WOULD SUPPORT THIS OTHER THAN THEM JUST MAKING A STATEMENT HOPING WE GO AWAY, WE SHOULD NOT HAVE TO BREATHE GAS FUMES WHEN TRAVELING DOWN A HIGHWAY. WE WERE TOLD NOT TO USE INTERIOR CIRCULATION AND IT WOULD HELP, NOT TO USE AIR CONDITIONER ON MAX. THE CABIN ON CAR FILLS WITH THE GAS FUMES AND MAKES US TIRED AND FATIGUE WHEN DRIVING FOR EXTENDED PERIOD OF TIME. WE PURCHASE A LUXURY SUV AS FORD WOULD HAVE YOU TO BELIEVE BUT IT ACTUALLY MORE LIKE A GAS CHAMBER HAVING TO BREATH THIS SEEMS A LITTLE TOO MUCH. I HOPE THE NHTSA CAN GET FORD TO ACKNOWLEDGE THEY HAVE A PROBLEM AND MAKE THEM TAKE IT SERIOUSLY AND GET RID OF WHAT IS CAUSING THE PROBLEM.
NHTSA ODI #10903885
5,400 miles · Aug 2, 2016
Engine
SUDDEN LACK OF THROTTLE CONTROL. THREE TIMES DURING OUR TRIP THE PAST TWO WEEKS FROM FLORIDA TO MARYLAND AND BACK, GOING 75 MPH ON INTERSTATE 95, THE ENGINE SUDDENLY DROPPED TO 1000 RPM AND ALL THROTTLE CONTROL WAS LOST. MY WIFE NEARLY HAD AN ACCIDENT TRYING QUICKLY TO GET TO THE SHOULDER. I WAS NEARLY RE-ENDED BY AN ESCALADE AS…
Read full complaint
SUDDEN LACK OF THROTTLE CONTROL. THREE TIMES DURING OUR TRIP THE PAST TWO WEEKS FROM FLORIDA TO MARYLAND AND BACK, GOING 75 MPH ON INTERSTATE 95, THE ENGINE SUDDENLY DROPPED TO 1000 RPM AND ALL THROTTLE CONTROL WAS LOST. MY WIFE NEARLY HAD AN ACCIDENT TRYING QUICKLY TO GET TO THE SHOULDER. I WAS NEARLY RE-ENDED BY AN ESCALADE AS MY VEHICLE SO QUICKLY DECELERATED. TWO TIMES A WRENCH APPEARED AND A DRIVER AIRBAG WARNING. THE THIRD TIME WE GOT THE SERVICE ENGINE SOON LIGHT. EACH TIME I WAS ABLE TO SHUT DOWN THE CAR AND RESTART IT, BUT I DECIDED TO INTERRUPT OUR TRIP AND SEEK HELP AT THE NEAREST LINCOLN DEALER. THIS WAS ON MONDAY, JULY 25. THE DEALER WAS LAFAYETTE IN FAYETTEVILLE, NC, A LINCOLN/FORD DEALERSHIP. [XXX], THE SERVICE ADVISOR, AND [XXX] (LAST NAME ?), THE SERVICE MANAGER I BELIEVE, IMMEDIATELY CAME TO OUR AID. [XXX] DIAGNOSED THE PROBLEM WITH A DIAGNOSTIC TOOL, WHILE [XXX] WORKED US INTO THEIR BUSY SCHEDULE. THE FAILURE WAS THE THROTTLE BODY WHICH [XXX] SAID IS AN ALL TOO COMMON RECENT PROBLEM ON OUR V-6 ENGINE USED IN FORDS AND LINCOLNS. THEIR SERVICE AND PROFESSIONALISM WAS EXTREMELY APPRECIATED AND THEY HAD US BACK ON THE ROAD IN A LITTLE OVER TWO HOURS. I SENT THEM A THANK YOU IN THEIR SURVEY REQUEST. WE MET ANOTHER COUPLE AT THE DEALERSHIP THAT SUFFERED THE SAME PROBLEM, ONLY THEY WERE NOT ABLE TO RESTART IT AND HAD TO BE TOWED OFF I 95 TO THE DEALERSHIP. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10892676
6,700 miles · Jul 22, 2016
Electrical SystemEngineFuel/propulsion System
2016 LINCOLN MKX HAS STALLED NUMEROUS TIMES. WE LEFT HOME AND HAD DRIVEN ABOUT A MILE IN OUR SUBDIVISION WHEN I SLOWED FOR AND STOPPED AT STOP SIGN. THE ENGINE SHUDDERED AND SHOOK, ENGINE REVOLUTIONS SLOWED DOWN. SPED UP, SLOWED DOWN AND ENGINE QUIT. THE MESSAGE, "FULL ACCESSORY POWER ACTIVE' DISPLAYED ON THE DASH AND MY WIFE GO…
Read full complaint
2016 LINCOLN MKX HAS STALLED NUMEROUS TIMES. WE LEFT HOME AND HAD DRIVEN ABOUT A MILE IN OUR SUBDIVISION WHEN I SLOWED FOR AND STOPPED AT STOP SIGN. THE ENGINE SHUDDERED AND SHOOK, ENGINE REVOLUTIONS SLOWED DOWN. SPED UP, SLOWED DOWN AND ENGINE QUIT. THE MESSAGE, "FULL ACCESSORY POWER ACTIVE' DISPLAYED ON THE DASH AND MY WIFE GOT A PAD AND PENCIL AND COPIED IT DOWN FOR ME. THIS WAS THE SECOND TIME THAT HAS HAPPENED AND EVIDENTLY WAS THE SAME MESSAGE DISPLAYED WHEN THE ENGINE QUIT WHILE WE WERE ON VACATION IN NEW ORLEANS. CHECKED THE INTERNET AND FOUND SEVERAL INSTANCES TO THIS HAPPENING DUE TO A COMPUTER GLITCH. FORD HAS KNOWN ABOUT THIS PROBLEM FOR SOME TIME. DO WE HAVE TO GET KILLED BEFORE FORD CORRECTS THEIR FAULTY COMPUTERS? TO MAKE MATTERS WORSE, I HAD SCHEDULED AND APPOINTMENT WITH MY DEALER, DROVE 31 MILES, ONLY TO FIND OUT THE SERVICE DEPARTMENT HAD NO KNOWLEDGE OF MY APPOINTMENT. SPOKE WITH THE SERVICE MANAGER ON 21 JULY AND HE TOLD ME HE WOULD SEND ME AN EMAIL BY THE END OF THE WEEK. WELL THE END OF THE WEEK IS HERE AND I'VE NOT HEARD ANYTHING YET. IT IS MY UNDERSTANDING THAT THE MKX IS A GLORIFIED FORD EDGE AND THAT THE STALLING PROBLEMS WERE ON-GOING FOR SEVERAL YEARS.
NHTSA ODI #10887833
200 miles · Jul 11, 2016
Engine
VEHICLE RANDOMLY LOSES THROTTLE POWER WHEN DRIVING SLOWLY OR AT HIGHWAY SPEEDS
NHTSA ODI #10883991
5,000 miles · Jun 22, 2016
Electronic Stability Control (esc)Engine
MY VEHICLE HAS BEEN LOSING POWER WHILE I'M DRIVING, LEADING TO SOME VERY CLOSE CALLS ON SERIOUS ACCIDENTS. THE "CHECK ENGINE" LIGHT WILL COME ON, AND SOMETIMES THE "HILL ASSIST" MESSAGE WILL ALSO APPEAR. ONCE POWER IS LOST, THE VEHICLE LOSES POWER STEERING AND LITERALLY SHUTS DOWN; THE ACCELERATOR DOES NOT WORK. I HAVE TO BASICA…
Read full complaint
MY VEHICLE HAS BEEN LOSING POWER WHILE I'M DRIVING, LEADING TO SOME VERY CLOSE CALLS ON SERIOUS ACCIDENTS. THE "CHECK ENGINE" LIGHT WILL COME ON, AND SOMETIMES THE "HILL ASSIST" MESSAGE WILL ALSO APPEAR. ONCE POWER IS LOST, THE VEHICLE LOSES POWER STEERING AND LITERALLY SHUTS DOWN; THE ACCELERATOR DOES NOT WORK. I HAVE TO BASICALLY LIMP TO SAFETY. I TOOK THE VEHICLE INTO THE DEALERSHIP, AND THEY FOUND NOTHING, SENDING ME AWAY ONLY FOR IT TO HAPPEN AGAIN. ALL 5 TIMES THIS HAS HAPPENED, THE VEHICLE WAS IN MOTION ON A CITY STREET, AS I HAVE AVOIDED HIGHWAYS SINCE THE FIRST TIME IT HAPPENED. I'VE DONE EXTENSIVE ONLINE RESEARCH, AND HAVE FOUND HUNDREDS OF OTHERS WHO HAVE EXPERIENCED THE SAME ISSUE.
NHTSA ODI #10875816
Official recalls
7Aug 22, 2025
Ford Motor Company (Ford) is recalling certain 2016-2018 Lincoln MKX and 2015-2018 Edge vehicles. The rear brake jounce hose may rupture and leak brake fluid.
Consequence & remedy
Consequence: A brake fluid leak can extend the distance required to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the brake jounce hoses and adjust brake jounce hoses with no damage present, free of charge. Interim owner letters notifying owners of the safety risk were mailed September 8, 2025. Additional letters will be sent once the remedy is available, anticipated August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S87.
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence & remedy
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Additional source detail variants (2)
Service Brakes
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Jul 17, 2020
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence & remedy
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Additional source detail variants (3)
Seats:front Assembly:power Adjust
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Air Bags
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Electrical System:wiring:interior/under Dash
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2016-2017 Lincoln MKX vehicles equipped with 3.7L engines. The battery positive cable harness may contact the transmission shifter cable bracket resulting in a short circuit.
Consequence & remedy
Consequence: An electrical short increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will remove the battery harness clips and elbow guide, and install a wire channel shield and protective sleeve to the battery cable harness, free of charge. Interim notices informing owners of the safety risk were mailed on December 2, 2019. Owners will receive a second notice when the remedy becomes available, currently expected to be the end of April 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S41.
Aug 29, 2019
Ford Motor Company (Ford) is recalling certain 2013-2016 Ford Fusion and Lincoln MKZ, 2015-2016 Ford Edge, and 2016 Lincoln MKX vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. Road salt or other contaminants may corrode the electric power steering gear motor attachment bolts.
Consequence & remedy
Consequence: If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist, requiring a greater steering effort, especially at lower speeds, and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the steering gear motor bolts and apply a wax sealer. If any of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began October 18, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S26.
Feb 27, 2017
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Edge and Lincoln MKX vehicles and 2017 Lincoln Continental vehicles. In the event of a crash, the driver's frontal air bag may not fully inflate or the air bag cushion may detach from the air bag module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: During deployment, if the air bag does not fully inflate or the cushion detaches, there is an increased risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the driver frontal air bag module, free of charge. The recall began June 16, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C02.
May 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Lincoln MKX vehicles manufactured September 24, 2015. An incorrect seat back trim cover was installed on the affected vehicles, blocking the child seat tether anchors in the second row center seating position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child restraint anchorage systems."
Consequence & remedy
Consequence: An improperly anchored child seat can increase the risk of injury in a crash.
Remedy: Ford will notify owners, and dealers will replace the seat back trim cover and tether cover bezel on the second row, free of charge. The recall began on June 16, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C09.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration