NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
32 reportsClear category filter14,000 miles · Jun 11, 2019
Engine
THE MOTOR HAS TOTALLY GONE DEAD IN HEAVY TRAFFIC 5 TIMES. THE 1ST 3 TIMES THEY SHOWED UP ON THE INSPECTION AND A PART WAS REPLACED. AN INSPECTION THE LAST 2 TIMES SHOWED NOTHING. WHEN THE ENGINE STOPS, I PRESS N, THEN START AND IT RUNS, THEN D AND IT GOES AGAIN. MEANWHILE, TWICE ON HWY 80 AROUND CHICAGO IN BUMPER-TO-BUMPER TRA…
Read full complaint
THE MOTOR HAS TOTALLY GONE DEAD IN HEAVY TRAFFIC 5 TIMES. THE 1ST 3 TIMES THEY SHOWED UP ON THE INSPECTION AND A PART WAS REPLACED. AN INSPECTION THE LAST 2 TIMES SHOWED NOTHING. WHEN THE ENGINE STOPS, I PRESS N, THEN START AND IT RUNS, THEN D AND IT GOES AGAIN. MEANWHILE, TWICE ON HWY 80 AROUND CHICAGO IN BUMPER-TO-BUMPER TRAFFIC AT 70 MPH, CARS ARE SLAMMING ON THEIR BRAKES AND HONKING. 1. WHAT ACTION BEYOND THE DEALER NEED I TAKE? 2. MY INSURANCE WILL NOT COVER A MULTI-CAR ACCIDENT FROM A DEFECTIVE CAR UNDER WARRANTY. WHO DOES? 3. IF THE PROBLEM IS NOT CORRECTED HOW DO I GET A NEW ONE FROM LINCOLN? IT IS A GREAT CAR WITH ABOUT 33,000 MILES. I PREFER KEEPING IT. MY DAUGHTER SAID WHEN IT HAPPENED TO HER, SHE HAD JUST TURNED ON THE RADIO. PERHAPS IT IS AN ELECTRICAL OR COMPUTER DEFECT. TO MY KNOWLEDGE, THE DEALERSHIP HAS TAKEN NO ACTION TO CONTACT LINCOLN HEADQUAQRTERS. IT HAPPENED 3 TIMES OVER A 2 DAY PERIOD IN OCT. 2017, (REPAIRED) ONCE IN OCT. 2018 AND ONCE IN MAY 2019.
NHTSA ODI #11219366
25,000 miles · May 15, 2019
Electrical SystemEngine
ON 5/11/19, I WAS DRIVING ABOUT 50MPH WHEN THE ENTIRE DASH WENT DARK, WHICH ALSO CAUSED THE ENGINE TO STOP RUNNING (WITH 3/4 TANK OF GAS) AS I LOOKED AT AN 'ALL POWER OFF' DISPLAYED IN THE INFORMATION AREA OF THE DASH (THAT NORMALLY DISPLAYS THE TRIP MILEAGE INDICATOR). I IMMEDIATELY PRESSED THE EMERGENCY FLASH BUTTON WHICH …
Read full complaint
ON 5/11/19, I WAS DRIVING ABOUT 50MPH WHEN THE ENTIRE DASH WENT DARK, WHICH ALSO CAUSED THE ENGINE TO STOP RUNNING (WITH 3/4 TANK OF GAS) AS I LOOKED AT AN 'ALL POWER OFF' DISPLAYED IN THE INFORMATION AREA OF THE DASH (THAT NORMALLY DISPLAYS THE TRIP MILEAGE INDICATOR). I IMMEDIATELY PRESSED THE EMERGENCY FLASH BUTTON WHICH WORKED. FORTUNATELY, I WAS IN THE RIGHT HAND LANE AND HAD ENOUGH SPEED TO SIMPLY COAST TO A SAFE AREA ON THE RIGHT SHOULDER. WITH THE ENGINE NOT RUNNING, I FELT I HAD ONE CHANCE TO USE THE POWER BRAKE PEDAL TO STOP THE CAR. HAD THIS OCCURRED IN A DIFFERENT PLACE, MY ENTIRE FAMILY COULD HAVE BEEN KILLED AND NO ONE WOULD HAVE KNOWN THE REASON WAS DUE TO 'CAR FAILURE'. I LOOKED ON THE INTERNET AND FOUND A NUMBER OF COMPLAINTS ABOUT THE ENGINE JUST STOPPING THAT HAVE BEEN DOCUMENTED WITH CASES SENT TO NHTSA. THEIR FRUSTRATION IN SUMMARY IS THIS: THE SERVICE DEPARTMENT SAYS THEY CAN'T REPRODUCE THE PROBLEM. TO BE CLEAR; I JUST RECEIVED A CALL FROM MY LINCOLN DEALERSHIP ON 5/15/19, AS THE SERVICE REP SAID THEY CAN'T FIND A COMPUTER ERROR CODE FOR THE PROBLEM, AND THERE IS NOTHING ELSE THEY CAN DO AT THIS POINT IF THEY CAN'T REPLICATE THE PROBLEM. AT THIS POINT, I BELIEVE THAT IF YOU SEE SOMETHING FAIL, AND DON'T RESOLVE IT, YOU'LL SEE IT AGAIN. THEREFORE, I DON'T TRUST THIS CAR AS SAFE TO DRIVE. IT IS NOT AN ACCEPTABLE OPTION TO HEAR THAT YOUR SERVICE DEPARTMENT CAN'T REPRODUCE THE PROBLEM. THIS MAY REQUIRE YOUR DESIGN ENGINEERS TO BE INVOLVED. THE QUESTION IS SIMPLE, 'WHAT ITEMS CAN CAUSE THE COMPUTER TO 'ALL POWER OFF'. NO MIDDLE GROUND HERE AS IT IS A LIFE THREATENING ISSUE THAT I JUST LIVED THROUGH.
NHTSA ODI #11207822
21,000 miles · Apr 23, 2018
EngineFire
TL* THE CONTACT OWNS A 2016 LINCOLN MKX. WHEN THE VEHICLE WAS STARTED, SMOKE APPEARED UNDER THE HOOD OF THE VEHICLE. THE CONTACT NOTICED THAT THERE WAS A COOLANT LEAK UNDERNEATH THE FRONT OF THE VEHICLE, AND THE RADIATOR AND RESERVOIR CONTAINERS WERE EMPTY. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAG…
Read full complaint
TL* THE CONTACT OWNS A 2016 LINCOLN MKX. WHEN THE VEHICLE WAS STARTED, SMOKE APPEARED UNDER THE HOOD OF THE VEHICLE. THE CONTACT NOTICED THAT THERE WAS A COOLANT LEAK UNDERNEATH THE FRONT OF THE VEHICLE, AND THE RADIATOR AND RESERVOIR CONTAINERS WERE EMPTY. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.
NHTSA ODI #11089559
5,500 miles · Aug 21, 2017
EngineUnknown Or Other
CAR IS MOVING AT HIGHWAY SPEED AND SUDDENLY SHUTS OFF COMPLETELY AND STOPS. LUCKILY CAR BEHIND WAS ABLE TO STOP AVOIDING A REAR-END COLLISION. MY WIFE WHO WAS DRIVING DENIES TOUCHING ANY SHIFTING BUTTONS ON THE DASHBOARD. HOWEVER, DUE TO THE LOCATION OF THE START/STOP ENGINE BUTTON IT IS VERY POSSIBLE TO TOUCH THE STOP ENGINE B…
Read full complaint
CAR IS MOVING AT HIGHWAY SPEED AND SUDDENLY SHUTS OFF COMPLETELY AND STOPS. LUCKILY CAR BEHIND WAS ABLE TO STOP AVOIDING A REAR-END COLLISION. MY WIFE WHO WAS DRIVING DENIES TOUCHING ANY SHIFTING BUTTONS ON THE DASHBOARD. HOWEVER, DUE TO THE LOCATION OF THE START/STOP ENGINE BUTTON IT IS VERY POSSIBLE TO TOUCH THE STOP ENGINE BUTTON IF TRYING TO ADJUST THE RADIO OR CLIMATE CONTROLS WHICH ARE LOCATED ADJACENT TO THE STOP/START ENGINE CONTROL BUTTON. THIS IS A DESIGN FLAW! WHILE YOU MUST DEPRESS THE BRAKE TO START THE CAR, ALL YOU NEED TO DO IS BRUSH THE CONTROL BUTTON TO STOP EVERYTHING WHILE MOVING.
NHTSA ODI #11018658
27,000 miles · Jul 30, 2017
Engine
2016 LINCOLN MKX - UNDER HARD ACCELERATION, I AM GETTING EXHAUST FUMES AND ALSO ROTTEN EGG SMELL COMING INTO THE INTERIOR WITH A.C. ON AND IN RECIRCULATE MODE WITH WINDOWS UP. MY SUV ONLY HAS 27,000 MILES ON IT. I SHOULD NOT BE GETTING EXHAUST FUMES OF ANY KIND INSIDE OF MY SUV. THIS SHOULD BE INVESTIGATED BECAUSE EXHAUST FU…
Read full complaint
2016 LINCOLN MKX - UNDER HARD ACCELERATION, I AM GETTING EXHAUST FUMES AND ALSO ROTTEN EGG SMELL COMING INTO THE INTERIOR WITH A.C. ON AND IN RECIRCULATE MODE WITH WINDOWS UP. MY SUV ONLY HAS 27,000 MILES ON IT. I SHOULD NOT BE GETTING EXHAUST FUMES OF ANY KIND INSIDE OF MY SUV. THIS SHOULD BE INVESTIGATED BECAUSE EXHAUST FUMES INSIDE OF A SUV ARE DANGEROUS.
NHTSA ODI #11011586
7,450 miles · Jul 29, 2017
EngineFuel/propulsion System
VEHICLE IN MOTION LOSES ACCELERATION SUDDENLY WHILE DRIVING. THIS LOSS LEAVES YOU IN AN EXTREMELY DANGEROUS SITUATION WHEN ON AN INTERSTATE HIGHWAY OR ANY TRAFFIC SITUATION. DATE OF 07/12/17 ON INTERSTATE HIGHWAY.DATE OF 06/27/17 INTERSTATE HIGHWAY. 05/19 /17 VEHICLE IN MOTION ON INTERSTATE HIGHWAY. PROBLEM BEGAN WHEN VEHICLE RE…
Read full complaint
VEHICLE IN MOTION LOSES ACCELERATION SUDDENLY WHILE DRIVING. THIS LOSS LEAVES YOU IN AN EXTREMELY DANGEROUS SITUATION WHEN ON AN INTERSTATE HIGHWAY OR ANY TRAFFIC SITUATION. DATE OF 07/12/17 ON INTERSTATE HIGHWAY.DATE OF 06/27/17 INTERSTATE HIGHWAY. 05/19 /17 VEHICLE IN MOTION ON INTERSTATE HIGHWAY. PROBLEM BEGAN WHEN VEHICLE REACHED 7,000 MILES. WAS INITIALLY TOLD BY ONE DEALER SERVICE TO PULL OVER AND TURN OFF VEHICLE WAIT THEN RESTART. NEVER WAS RECALLED BY LINCOLN MOTOR IN SPITE OF NUMEROUS REPORTS BY OWNERS ON CARCOMPLAINTS WEBSITE. WHEN I CONTACTED LINCOLN I WAS TOLD THAT IT WAS THE RESPONSIBILITY OF THE NTSB TO ISSUE A RECALL. I WAS TOLD BY THE DEALER WHO MADE THE REPAIR THERE IS A RECALL BULLETIN ON THIS ISSUE TO THE DEALERS . NO RECALL NOTICES WERE EVER SENT TO OWNERS AS 07/29/2017
NHTSA ODI #11011467
33,450 miles · Jul 8, 2017
Engine
ENGINE HAS STALLED TWICE WHILE IN OPERATION. FIRST TIME WHILE BACKING OUT OF A PARKING SPACE,SECOND TIME WHILE DRIVING FORWARD IN TRAFFIC ON THE HIGHWAY. IN BOTH INSTANCES HAD TO COME TO A COMPLETE STOP, PLACE VEHICLE INTO PARK, SHUT OFF THE IGNITION AND THEN RESTART. BOTH INSTANCES VEHICLE WAS IN MOTION. SECOND INSTANCE WAS…
Read full complaint
ENGINE HAS STALLED TWICE WHILE IN OPERATION. FIRST TIME WHILE BACKING OUT OF A PARKING SPACE,SECOND TIME WHILE DRIVING FORWARD IN TRAFFIC ON THE HIGHWAY. IN BOTH INSTANCES HAD TO COME TO A COMPLETE STOP, PLACE VEHICLE INTO PARK, SHUT OFF THE IGNITION AND THEN RESTART. BOTH INSTANCES VEHICLE WAS IN MOTION. SECOND INSTANCE WAS IN MOVING TRAFFIC AND HAD TO PULL ONTO THE ROAD SHOULDER OUT OF TRAFFIC IN ORDER TO STOP AS VEHICLE WOULD NOT RESTART WHILE IN MOTION. DEALER CHECKED AND FOUND NO CODES STORED IN THE VEHICLE'S COMPUTER, THUS NO ACTION TAKEN TO ADDRESS THIS ISSUE.
NHTSA ODI #11003817
250 miles · Jun 21, 2017
Electrical SystemEngineFuel/propulsion System
TL* THE CONTACT OWNS A 2016 LINCOLN MKX. THE CONTACT NOTICED AN ABNORMAL TOXIC ODOR OF STRONG FUMES INSIDE THE VEHICLE WEEKS AFTER PURCHASING THE VEHICLE. THE VEHICLE WAS TAKEN TO MORE THAN TWO DEALERS (FIRST DEALER: WALLACE LINCOLN, 5555 US-1, FORT PIERCE, FL 34982, (772) 461-6060 AND SECOND DEALER: PARADISE FORD, 1360 W KING S…
Read full complaint
TL* THE CONTACT OWNS A 2016 LINCOLN MKX. THE CONTACT NOTICED AN ABNORMAL TOXIC ODOR OF STRONG FUMES INSIDE THE VEHICLE WEEKS AFTER PURCHASING THE VEHICLE. THE VEHICLE WAS TAKEN TO MORE THAN TWO DEALERS (FIRST DEALER: WALLACE LINCOLN, 5555 US-1, FORT PIERCE, FL 34982, (772) 461-6060 AND SECOND DEALER: PARADISE FORD, 1360 W KING ST, COCOA, FL 32922, (321) 632-2222), BUT THE ODOR ISSUE WAS NOT RESOLVED. THE CONTACT CONTINUED TO INHALE THE TOXIC FUMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT PROVIDE ANY FURTHER DIAGNOSTIC TESTING. THE CONTACT RECEIVED NO SOLUTION AND WAS UNCERTAIN OF A REPAIR REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS LESS THAN 250. UPDATED 08/24/17*LJ *JS
NHTSA ODI #11000401
5,107 miles · Apr 22, 2017
Electrical SystemEngineFire
AFTER START AND SHORT DRIVE INCLUDING A LEFT THAN RIGHT TURN. AT STOP SIGN, VEHICLE DASHBOARD LIT UP WITH SAFETY WARNINGS, STARTED SHAKING, LOST POWER, AND STARTED ON FIRE. SMOKE BEGAN IN DRIVERS SIDE ENGINE COMPARTMENT AND ENGULFED WHOLE ENGINE. VEHICLE WAS SERVICED TWO DAYS PRIOR.
NHTSA ODI #10979889
4,000 miles · Feb 16, 2017
Engine
I HAVE HAD PROBLEMS WITH MY 2016 MKX, PURCHASED IN JUNE OF 2016. THE EXHAUST SYSTEM HAS BEEN LEAKING INTO THE CABIN. I ACTUALLY TOOK THE CAR IN FOR SERVICE, BUT THE CAR DEALERSHIP COULD NOT FIND AN ISSUE. THEY CLEANED UNDERNEATH THE EXHAUST LINES AND IT HAS IMPROVED. THE VEHICLE IS USUALLY IN MOTION, I LIVE IN AN AREA WITH …
Read full complaint
I HAVE HAD PROBLEMS WITH MY 2016 MKX, PURCHASED IN JUNE OF 2016. THE EXHAUST SYSTEM HAS BEEN LEAKING INTO THE CABIN. I ACTUALLY TOOK THE CAR IN FOR SERVICE, BUT THE CAR DEALERSHIP COULD NOT FIND AN ISSUE. THEY CLEANED UNDERNEATH THE EXHAUST LINES AND IT HAS IMPROVED. THE VEHICLE IS USUALLY IN MOTION, I LIVE IN AN AREA WITH HILLS USUALLY AFTER CLIMBING UP A HILL OF A CITY STREET. I HAVE NOTICED THE SMELL LINGERING EVEN AFTER I'VE BEEN OUT OF THE CAR. I'VE SEEN ON OTHER SITES WHERE OTHER LINCOLN OWNERS HAVE COMPLAINED AS WELL. I'M POSTING THIS MESSAGE AS I BELIEVE THE EXHAUST SYSTEM ISSUE FOR FORD IS BEYOND JUST THE FORD LINE AND ALSO LINCOLN.
NHTSA ODI #10955176
Official recalls
7Aug 22, 2025
Ford Motor Company (Ford) is recalling certain 2016-2018 Lincoln MKX and 2015-2018 Edge vehicles. The rear brake jounce hose may rupture and leak brake fluid.
Consequence & remedy
Consequence: A brake fluid leak can extend the distance required to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the brake jounce hoses and adjust brake jounce hoses with no damage present, free of charge. Interim owner letters notifying owners of the safety risk were mailed September 8, 2025. Additional letters will be sent once the remedy is available, anticipated August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S87.
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence & remedy
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Additional source detail variants (2)
Service Brakes
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Jul 17, 2020
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence & remedy
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Additional source detail variants (3)
Seats:front Assembly:power Adjust
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Air Bags
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Electrical System:wiring:interior/under Dash
Ford Motor Company, Inc. (Ford) is recalling certain 2016-2018 Lincoln MKX and 2019-2020 Nautilus vehicles equipped with 16-way electric tilt seats. The seat cushion frame edge may contact the wire harness when the seat occupant uses the tilt function of the seat, potentially damaging one or more wires within the harness, which can result in either inadvertent deployment of the air bag or nondeployment of the air bag in the event of a crash.
Consequence: An air bag that deploys inadvertently increases the risk of a crash. An air bag that does not deploy in the event of a crash increases the risk of injury.
Remedy: Ford will notify owners, and dealers will install protective flocking tape onto the exposed edge of the 16-way seat cushion frames, and inspect the wire harness for damage, and repair or replace it as needed, free of charge. This recall began August 12, 2020. Owners may contact Ford/Lincoln customer service at 1-866-436-7332. Ford's number for this recall is 20S37.
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2016-2017 Lincoln MKX vehicles equipped with 3.7L engines. The battery positive cable harness may contact the transmission shifter cable bracket resulting in a short circuit.
Consequence & remedy
Consequence: An electrical short increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will remove the battery harness clips and elbow guide, and install a wire channel shield and protective sleeve to the battery cable harness, free of charge. Interim notices informing owners of the safety risk were mailed on December 2, 2019. Owners will receive a second notice when the remedy becomes available, currently expected to be the end of April 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S41.
Aug 29, 2019
Ford Motor Company (Ford) is recalling certain 2013-2016 Ford Fusion and Lincoln MKZ, 2015-2016 Ford Edge, and 2016 Lincoln MKX vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. Road salt or other contaminants may corrode the electric power steering gear motor attachment bolts.
Consequence & remedy
Consequence: If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist, requiring a greater steering effort, especially at lower speeds, and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the steering gear motor bolts and apply a wax sealer. If any of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began October 18, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S26.
Feb 27, 2017
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Edge and Lincoln MKX vehicles and 2017 Lincoln Continental vehicles. In the event of a crash, the driver's frontal air bag may not fully inflate or the air bag cushion may detach from the air bag module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: During deployment, if the air bag does not fully inflate or the cushion detaches, there is an increased risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the driver frontal air bag module, free of charge. The recall began June 16, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C02.
May 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Lincoln MKX vehicles manufactured September 24, 2015. An incorrect seat back trim cover was installed on the affected vehicles, blocking the child seat tether anchors in the second row center seating position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child restraint anchorage systems."
Consequence & remedy
Consequence: An improperly anchored child seat can increase the risk of injury in a crash.
Remedy: Ford will notify owners, and dealers will replace the seat back trim cover and tether cover bezel on the second row, free of charge. The recall began on June 16, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C09.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration