2017 Lincoln Mkc

My vehicle started stuttering & shaking when starting. Then the check engine light came on. It was diagnosed with cylinder 2 & 3 misfire. All spark plugs & coil packs replaced. It got better for about 3 months then the problem came right back. Have replaced coil packs multiple times. Took to dealer who said cylinder misfires were caused from coolant leaking & the only fix was to have engine replaced & quoted $11000. This started at about 95000 miles. Vehicle has had perfect maintenance, all oil changes done on Schedule. Dealer said motor can lock up at any moment & this was a manufacturer error.

Issue Description: The vehicle developed a check engine light and was diagnosed with a P0302 cylinder #2 misfire. The condition persisted after basic troubleshooting, and the vehicle was taken out of service to prevent further damage. The vehicle was subsequently brought to an authorized Lincoln dealership for diagnostic evaluation. The dealership confirmed that the vehicle requires a full engine replacement due to internal engine failure. The estimated cost of repair is approximately $9,500–$10,000. This failure occurred at approximately 64,000 miles, which is significantly earlier than expected for a major engine failure. Safety Concern: The engine misfire and internal failure can lead to loss of power while driving, creating a potential safety hazard, particularly at highway speeds or during acceleration. Additional Information: Manufacturer technical service bulletins describe coolant intrusion issues in 2.0L EcoBoost engines that can lead to misfires and engine damage. The symptoms experienced in this vehicle are consistent with those described conditions. The manufacturer was contacted for assistance but declined to provide support. Summary: Premature engine failure at low mileage requiring full engine replacement, with symptoms consistent with documented issues affecting this engine type. This condition presents a potential safety concern due to possible loss of power while driving.

In 2023 antifreeze was found in the engine cylinder chambers causing the engine to run rough. We purchased the repair/replacement of a new head gasket at a cost of $3500.00. Now, it is Apirl 2026 and we have developed the same issue plus internal oil leaking in the turbo. Our repair shop says we need to replace the engine and the turbo unit at approx cost $11,200.00 (parts and labor). We have come to learn that this Ford 2.0L 4cyn EcoBoost engine has been found to have a design defect causing regular head gasket failure. So, this is our complaint about this engine and product built by Ford Motor Company. We have come to realize we own a very unreliable vehicle built by Ford.

The engine in my 2017 Lincoln MKC (2.0L EcoBoost) has a documented manufacturing defect where the cylinder block design allows coolant to leak into the combustion chambers. This has caused persistent, unexplained coolant loss and rough engine performance on cold starts since February 2025, matching the diagnostic criteria in Ford TSB 19-2346. The defective engine assembly is available for inspection. This condition creates a significant safety hazard, including sudden power loss (Limp Mode) in traffic and a risk of engine fire from cracked cylinder heads. While Ford provided a service program (21N12) for 1.5L engines, they have failed to issue a safety recall for the 2.0L variant despite identical failure modes. This vehicle is part of the class in the consolidated litigation Miller, et al. v. Ford Motor Company (Case No. 2:20-cv-01796). I am filing this to assist NHTSA in determining the necessity of a mandatory safety recall.

Related to previous recall [XXX] I had the recall repair done. But my car with only 86,744 miles now has coolant in cylinder 3 and it's misfiring so badly the car shouldn't/can't be driven. Dealership says the entire engine needs to be replaced. I have NEVER had a car this low of mileage that an entire engine needed replacement. This is a design flaw in the 2.0 ecoboost and I now have a probably $20,000 or whatever it may have been worth when it ran... Paperweight. It's just sputtering and spitting out loads of smoke as described in original TSB. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

At approximately 64,000 miles my engine light came on and I took it to a shop. Cylinder 2 was misfiring so we changed the spark plugs and coils. At 67,000 miles light came on again with same issue and while having my oil changed they noted it was unusually dirty. I changed out plugs and coils again. At 72,000 miles light came on again and I took it to a different shop and learned I had a crack engine block, a problem with these vehicles with ECO boost. I was told I needed a new engine and the only thing I could do was add sealant to buy time. I took it to Lincoln to trade and they refused because of the issue and told me to reset the light and sell to Carmax. I couldn’t do that, it was wrong. I sold it for $1,000 to Nissan because I could no longer afford to be driving my grandson in this unsafe car. Also had a lot of issues with electrical starting from purchase with battery dying and lift gate not working. When I got rid of it the windshield wipers wouldn’t work and radio made aweful static sounds. Horrible car from day 1 purchased brand new.

After a repair/service visit at a national auto repair chain, my 2017 Lincoln MKC developed ongoing severe drivability and safety issues. The check engine light began flashing (active misfire), and the vehicle was unsafe for highway travel due to risk of loss of power/engine damage. Independent shop documentation reports cylinder #4 misfire (P0304) and additional engine timing-related code(s), low oil condition, and notes indicating internal engine damage and that the engine may require replacement. The vehicle also had a vacuum/brake booster line issue that affected brake assist until corrected. The problem has been confirmed by independent service centers and the vehicle is available for inspection. There was a near crash, but no fire, injury, or police report occurred.

My Lincoln MKC 2017 is having a recurring problem with a misfire in the 3rd cylinder due to a hood gasket, a crack in the coolant, and leaking on the sparks and coils. I have had my mechanic work on and look at it, and it is a manufacturing defect. When I called, there was no recall listed for my vehicle except the backup camera. However, when you look at Kelly Blue Book, it says there is more than one engine recall and issue, which is exactly what is happening to my Lincoln. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

The 2017 Lincoln MKC requires a full engine replacement due to a serious, well-documented defect: coolant intrusion. This is a major issue that can destroy critical engine components, including the head gasket, cylinders, and even the engine block. Ford/Lincoln is aware of this problem. They issued multiple TSBs (22-2133 and 22-2229, to name a few), yet customers are not informed. Because there is no recall, if the car is out of warranty, dealers refuse to perform the necessary repairs unless the customer pays tens of thousands of dollars for something that is a known manufacturing defect, leaving them vulnerable to catastrophic engine failure and potential accidents, injuries or worse. This is a known manufacturing defect, and consumers should not bear responsibility for the resulting safety hazards. Ford/Lincoln must take immediate action and issue a recall before it leads to serious injuries or fatalities.