STONG GAS ODOR INSIDE OF CAR WHEN GAS TANK IS NEAR EMPTY. ODOR DOES NOT OCCUR EVERYTIME GAS TANK IN CLOSE TO EMPTY, AND NEVER OCCURS WHEN TANK IS FULL. HAVE TAKEN CAR INTO DEALERSHIP TWICE, AND THEY CAN SMELL THE GAS, BUT HAD TROUBLE LOCATING THE PROBLEM. THEY FOUND SOMETHING IN THEIR TECHNICAL SERVICE BULLETIN FROM 1997 THAT…
Read full complaint
STONG GAS ODOR INSIDE OF CAR WHEN GAS TANK IS NEAR EMPTY. ODOR DOES NOT OCCUR EVERYTIME GAS TANK IN CLOSE TO EMPTY, AND NEVER OCCURS WHEN TANK IS FULL. HAVE TAKEN CAR INTO DEALERSHIP TWICE, AND THEY CAN SMELL THE GAS, BUT HAD TROUBLE LOCATING THE PROBLEM. THEY FOUND SOMETHING IN THEIR TECHNICAL SERVICE BULLETIN FROM 1997 THAT HAD TO DO WITH A VAPOR VENT HOSE THAT RUNS UNDER THE BACK SEAT OF VEHICLE AND WHEN REACHES TEMPS OF 90 DEGREES OR MORE, FUEL FUMES WERE COMING INTO VEHICLE WHEN THE MAX A/C IS ON. THIS IS VERY SIMILAR TO MY PROBLEM. THE KIT UNFORTUNATELY IS NO LONGER MANUFACTURED AND THEY COULD NOT LOCATE ONE, BUT ARE GOING TO TRY TO CREATE THEIR OWN KIT.
NHTSA ODI #10039591
Mileage unknown · Jul 20, 2000
Fuel System, GasolineFire
VEHICLE WAS PARK ON THE OUTSIDE OF CONSUMER'S HOUSE, AND HE HAD JUST GOTTEN OUT OF VEHICLE. A FEW MINUTES LATER, VEHICLE CAUGHT ON FIRE. FIRE DEPARTMENT WAS CALL OUT. DEALERSHIP WAS NOTIFIED THAT THE FUEL INJECTOR NEEDED TO BE REPLACED.*AK
NHTSA ODI #865783
Mileage unknown · Oct 28, 1999
EquipmentFuel System, Gasoline
WHIL EDRIVING ON ROAD TURNED ON A/C AND GAS FUMES FILLED THE COMPARTMENT. SMELLED GAS FUMES ALL THE TIME. CONTACTED THE DEALER , AND H ECOULDN'T FIND THE CAUSE. THEY REPLACED PLASTIC TUBING IN THE FUEL LINE. THIS HAS HAPPENED A SECOND TIME. CONTACTED DEALER AGAIN, AND WAS NOT ABLE TO ASSIST. *AK
NHTSA ODI #852104
Mileage unknown · Apr 7, 1999
Fuel System, Gasoline
STRONG, RAW GAS ODOR INSIDE AND OUTSIDE OF CAR WHEN GAS TANK IS NEAR EMPTY (5 GALLONS OR LESS). ODOR DOES NOT OCCUR EVERYTIME GAS TANK IS CLOSE TO EMPTY, AND NEVER OCCURS WHEN TANK IS FULL. HAVE TAKEN THE CAR INTO DEALERSHIP TWICE, THEY CAN SMELL THE GAS AGREE THERE IS A PROBLEM, BUT THEY CANNOT LOCATE THE PROBLEM. DOESN'T SE…
Read full complaint
STRONG, RAW GAS ODOR INSIDE AND OUTSIDE OF CAR WHEN GAS TANK IS NEAR EMPTY (5 GALLONS OR LESS). ODOR DOES NOT OCCUR EVERYTIME GAS TANK IS CLOSE TO EMPTY, AND NEVER OCCURS WHEN TANK IS FULL. HAVE TAKEN THE CAR INTO DEALERSHIP TWICE, THEY CAN SMELL THE GAS AGREE THERE IS A PROBLEM, BUT THEY CANNOT LOCATE THE PROBLEM. DOESN'T SEEM TO MATTER IF THE CAR IS HEATED FROM DRIVING OR A COLD ENGINE, ODOR WILL OCCUR. *AK
NHTSA ODI #705371
Mileage unknown · Mar 1, 1995
Electrical SystemEngine And Engine CoolingEquipment
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
THE BRAKE PEDAL PUSH ROD RETAINER (HAIRPIN CLIP) MAY BE MISSING OR NOT PROPERLY INSTALLED ON THE SERVICE BRAKE PEDAL. THIS CAN CAUSE DISENGAGEMENT OF THE BRAKE PUSHROD AND LOSS OF BRAKING ABILITY.
Consequence & remedy
Consequence: LOSS OF BRAKING ABILITY CAN RESULT IN A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE RETAINER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
1994 Lincoln Continental Problems, Complaints & Recalls | Skip That Year
Illustration