NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
73 reportsClear category filterMileage unknown · May 24, 2000
Electrical SystemEngine And Engine CoolingLatches/locks/linkages
MAJOR PROBLEMS STARTED AFTER MY CAR RECEIVED THE 144,000 MILE SERVICE CHECK (CAR HAD APPROX. $130,000 AT THAT TIME). IN ADDITION TO THE PROVIDED LIST: FEB 00 - TRUNK LATCH ASSEMBLY WENT OUT; FEB 99 - R/R HEADS & GASKETS/COOLANT/ THERMASTAT/ SENSOR/TUNEUP ($1602) DONE DUE TO WORN-OUT HEAD GASKETS; AUG 98 - CHECK ENGINE LIGHT ST…
Read full complaint
MAJOR PROBLEMS STARTED AFTER MY CAR RECEIVED THE 144,000 MILE SERVICE CHECK (CAR HAD APPROX. $130,000 AT THAT TIME). IN ADDITION TO THE PROVIDED LIST: FEB 00 - TRUNK LATCH ASSEMBLY WENT OUT; FEB 99 - R/R HEADS & GASKETS/COOLANT/ THERMASTAT/ SENSOR/TUNEUP ($1602) DONE DUE TO WORN-OUT HEAD GASKETS; AUG 98 - CHECK ENGINE LIGHT STUCK - OXYGEN SENSOR REPLACED ($133), NOV 97 - BLOWER MOTOR SPEED CONTROLLER IGNITION KEY LOCK CYCLINDER REPAIRED DUE TO DEFROST LIGHTS STAYED ON WITH KEY OFF, IGNITION SWITCH INOPERABLE ($375). MY COMPLAINT IS IN EVERY INCIDENT (WHETHER THE CAR HAD 75,000 OR 100,000 MILES), THE DEALER INFORMED ME THAT THIS IS A FACTORY PROBLEM WITH THE 1993 & 1994 LINCOLN CONTINENTALS. RECALL #97V019000 COVERING THE SAME GASKET/ELECTRICAL SYSTEM FOR THE 1994 SHOULD ALSO COVER THE 1993 LINCOLN. ALL REPAIRS AND MAINTENANCE UPKEEP WERE DONE BY THE DEALER REGULARLY. THE MORE THIS CAR IS TAKEN IN FOR MAINTENANCE UPKEEP, IT SEEMS TO DEVELOP INTO MORE EXPENSIVE PROBLEMS. REPLACEMENTS DONE TWICE: HEAD G
NHTSA ODI #723152
Mileage unknown · May 23, 2000
Engine And Engine Cooling
HEAD GASKET FAILED. NLM
NHTSA ODI #784649
Mileage unknown · May 18, 2000
Engine And Engine Cooling
PLEASE REFER TO ODI#722537 WHICH I FILED LAST WEEK REGARDING BAD HEAD GASKET. DEALERSHIP ADVISED ME THIS WEEK THAT ENGINE HAS FAILED AS A RESULT. FORD CO HAS DECLINED ANY ASSISTANCE IN THIS REGARD! NEW ENGINE WILL COST ME OVER $4000.00! AS PREVIOUSLY REPORTED THIS WAS NO NEGLIGENCE ON MY PART BUT A CONTINUED PROBLEM WITH ENGINE…
Read full complaint
PLEASE REFER TO ODI#722537 WHICH I FILED LAST WEEK REGARDING BAD HEAD GASKET. DEALERSHIP ADVISED ME THIS WEEK THAT ENGINE HAS FAILED AS A RESULT. FORD CO HAS DECLINED ANY ASSISTANCE IN THIS REGARD! NEW ENGINE WILL COST ME OVER $4000.00! AS PREVIOUSLY REPORTED THIS WAS NO NEGLIGENCE ON MY PART BUT A CONTINUED PROBLEM WITH ENGINE DESIGN. *AK
NHTSA ODI #722869
Mileage unknown · May 11, 2000
Engine And Engine Cooling
ENGINE HEAD GASKET FAILED ON MY CAR. BAD DESIGN OF 3.8L ENGINE. COMPANY HAS EXTENDED WARRANTY FOR YEARS 1994 AND 1995 CONTINENTAL. I HAVE A 1993 SAME ENGINE!! THIS IS THE SECOND VEHCLE (I OWN 1995 WINDSTAR WITH SAME PROBLEM!!) OUT OF WARRANTY HAD TO PAY FOR REPAIR!! FORD CLAIMS THEY CAN'T HELP ON MY LINCOLN!! DOESN'T MAKE SENSE …
Read full complaint
ENGINE HEAD GASKET FAILED ON MY CAR. BAD DESIGN OF 3.8L ENGINE. COMPANY HAS EXTENDED WARRANTY FOR YEARS 1994 AND 1995 CONTINENTAL. I HAVE A 1993 SAME ENGINE!! THIS IS THE SECOND VEHCLE (I OWN 1995 WINDSTAR WITH SAME PROBLEM!!) OUT OF WARRANTY HAD TO PAY FOR REPAIR!! FORD CLAIMS THEY CAN'T HELP ON MY LINCOLN!! DOESN'T MAKE SENSE IN VIEW OF SAME PROBLEM WITH SAME ENGINE RGARDLESS OF YEAR! MILEAGE IS LOW ENOUGH THAT THIS SHOULDN'T BE HAPPENING! PLEASE HELP!! IT'S GOING TO COST ME ANOTHER $1200.00 TO FIX!ELAG. *AK
NHTSA ODI #722537
Mileage unknown · Apr 27, 2000
Engine And Engine Cooling
WHILE TRAVELING NOTICED WHITE SMOKE COMING FORM THE TAIL PIPE AND ENGINE WAS RUNNING HOT. DEALER STATED THAT HEAD GASKET BLEW OUT. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #861053
Mileage unknown · Apr 11, 2000
Engine And Engine Cooling
I HAVE A 1993 LINCOLN CONTINENTAL WITH A V6 3.8 ENGINE; THE CAR IS IN THE SHOP HAVING THE HEAD GASKET REPLACED. I UNDERSTAND THAT FORD MOTOR COMPANY HAS RECALLED THE HEAD GASKETS OF V6 3.8 ENGINES ON OTHER VEHICLES, INCLUDING THE 1994 LINCOLN CONTINENTAL. THERE ARE MANY OTHER PEOPLE THAT FORD IS IGNORING, WITH THE SAME PROBLEM.…
Read full complaint
I HAVE A 1993 LINCOLN CONTINENTAL WITH A V6 3.8 ENGINE; THE CAR IS IN THE SHOP HAVING THE HEAD GASKET REPLACED. I UNDERSTAND THAT FORD MOTOR COMPANY HAS RECALLED THE HEAD GASKETS OF V6 3.8 ENGINES ON OTHER VEHICLES, INCLUDING THE 1994 LINCOLN CONTINENTAL. THERE ARE MANY OTHER PEOPLE THAT FORD IS IGNORING, WITH THE SAME PROBLEM. MY CAR WAS BUILT AT THE END OF 1993, AND I KNOW THAT MY ENGINE HAS THE SAME DEFECTIVE HEAD GASKET. I FEEL THIS ENGINE SHOULD BE INCLUDED IN THE RECALL PROGRAM. *AK
NHTSA ODI #721334
Mileage unknown · Apr 10, 2000
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
FUEL FILTER FAILED. YH
NHTSA ODI #551834
Mileage unknown · Apr 6, 2000
Engine And Engine CoolingService Brakes, HydraulicStructure
AT 50,000 MILES, NUMEROUS PROBLEMS STARTED OCCURRING. REPAIRS TOTALLED$2700. THE REPAIRS INCLUDED REPLACING THE ABS INDICATOR RING, WHEEL SPEED SENSOR, BLOWER CONTROLLER,DOOR LOCK ACTUATOR,HEAD GASKET, VALVE COVER, OXYGEN SENSORS & OIL PAN. THE MOST COSTLY REPAIRS INVOLVED THE HEAD GASKET ISSUE WHERE THE 4TH CYLINDER WAS LEAKING…
Read full complaint
AT 50,000 MILES, NUMEROUS PROBLEMS STARTED OCCURRING. REPAIRS TOTALLED$2700. THE REPAIRS INCLUDED REPLACING THE ABS INDICATOR RING, WHEEL SPEED SENSOR, BLOWER CONTROLLER,DOOR LOCK ACTUATOR,HEAD GASKET, VALVE COVER, OXYGEN SENSORS & OIL PAN. THE MOST COSTLY REPAIRS INVOLVED THE HEAD GASKET ISSUE WHERE THE 4TH CYLINDER WAS LEAKING COOLANT INTO THE ENGINE. THE FIRST SERVICE WAS PERFORMED ON THE CAR ON 11/30/99 WHEN THE HEAD GASKET ISSUE WAS DETECTED. THE CAR HAD TO BE TOWED TWO TIMES AND REQUIRED THREE ADDITIONAL VISITS TO THE GARAGE TO COMPLETE THE WORK. TO THIS DAY, THE CAR STILL IDLES ROUGH AND THE CHECK ENGINE WARNING LIGHT COMES ON PERIODIACALLY....INDICATING MORE THAN LIKELY, MORE HEAD GASKET PROBLEMS. *AK
NHTSA ODI #721123
Mileage unknown · Apr 5, 2000
Engine And Engine Cooling
ENGINE HEAD GASKET WAS REPLACED AT CONSUMERS COST. WANTED REIMBURSEMENT. MANUFACTURER WOULD NOT REIMBURSE CONSUMER AT FIRST BECAUSE VIN# DIDN'T MATCH RECALL, BUT FORD REP ADMITTED THAT THIS WAS THE SAME ENGINE AND REIMBURSED FOR HEAD GASKET REPLACEMENT. *AK *ML
NHTSA ODI #859736
Mileage unknown · Apr 5, 2000
Engine And Engine Cooling
BECAUSE MY CAR IS A93 MODEL FORD WILL NOT COVER THE COST OF REPAIRS KNOWING THAT THEY HAVE A PROBLEM WITH THE 3.8 ENGINE PLEASE HELP IF YOU CAN. *AK
NHTSA ODI #721051
Official recalls
4Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
Jan 21, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration