IllustrationSUNROOF EXPLODED ON HIGHWAY GOING 60 MPH TEMPERATURE AT 35 DEGREES.
2004 Lexus RX330
Owner reports · Recalls · Investigations
More warning signs than most RX330 years
Owner complaints for the 2004 Lexus RX330 are substantially higher than the model-year median of 36.
About this comparison →How this year compares
Owner complaints by model year
Compare all RX330 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
810–25K
2525–50K
2450–75K
2275–100K
26100–150K
10150K+
188 reports with mileage · 99 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports1 fire reports20 injury reports
Unknown Or Other complaints
20 reportsTHE DASHBOARD IS CRACKING UP BAD AND WHEN I'M DRIVING I BE HERRING POPING SOUND COMING FROM THE DASHBOARD AND WHEN THE HEAT IS ON IT BE MAKING LOAD SOUND
WE LATELY HAVE HAD DASHBOARD CRACKS OR MELTING ALTHOUGH WE HAVE GARAGE MAINTAINED OUR CAR VERY CAREFULLY WITH VERY LOW MILEAGE OF 70,000 ONLY. THIS IS NOT HEALTHY AND VERY HARMFUL TO OUR LEXUS EXPERIENCE. BY THE WAY, WE HAVEN'T HAD SUCH CRACKS UNTIL NOW DUE TO OUR WELL MAINTENANCE SO THAT WE MISSED DASHBOARD RECALL WHICH WAS EX…
Read full complaint
WE LATELY HAVE HAD DASHBOARD CRACKS OR MELTING ALTHOUGH WE HAVE GARAGE MAINTAINED OUR CAR VERY CAREFULLY WITH VERY LOW MILEAGE OF 70,000 ONLY. THIS IS NOT HEALTHY AND VERY HARMFUL TO OUR LEXUS EXPERIENCE. BY THE WAY, WE HAVEN'T HAD SUCH CRACKS UNTIL NOW DUE TO OUR WELL MAINTENANCE SO THAT WE MISSED DASHBOARD RECALL WHICH WAS EXPIRED ON MAY 31 2017.
DASHBOARD CRACKED
I HAVE BEEN WAITING FOR OVER 2 YEARS NOW FOR THE DASHBOARD REPLACEMENT RECALL AND WOULD LIKE TO SELL THE CAR BUT THE DASHBOARD IS CRACKING AND UNSIGHTLY.
BACKING UP MY SPARE TIRE FELL RIGHT ON THE GROUND I THOUGHT I HIT SOMEONE LOOKS LIKE THE CABLE ROTTED I WAS LUCKY WAS ON MY WAY TO GO ON HIGHWAY WITH MY GRAND DAUGHTER AND IF IT HAPPENED ON HIGHWAY SOMEONE COULD OF CAUSED A MAJOR ACCIDENT
THE MAIN DASHBOARD IS CRACKED ALL AROUND THE PASSENGER AIRBAG, IGNITION SWITCH, FROM THE DRIVER SIDE ALL THE WAY TO THE PASSENGER SIDE. IT IS GETTING WORSE BY THE MINUTE! IT IS PART OF THE LEXUS WARRANTY ENHANCEMENT PROGRAM AND I HAVE BEEN GETTING THE RUN AROUND FOR TWO YEARS. EACH TIME I CALL, ITS THE SAME OLD STORY: 'NOT ENOUG…
Read full complaint
THE MAIN DASHBOARD IS CRACKED ALL AROUND THE PASSENGER AIRBAG, IGNITION SWITCH, FROM THE DRIVER SIDE ALL THE WAY TO THE PASSENGER SIDE. IT IS GETTING WORSE BY THE MINUTE! IT IS PART OF THE LEXUS WARRANTY ENHANCEMENT PROGRAM AND I HAVE BEEN GETTING THE RUN AROUND FOR TWO YEARS. EACH TIME I CALL, ITS THE SAME OLD STORY: 'NOT ENOUGH DASHBOARDS COMING IN AND THEY ARE BEING REPLACED AS THEY COME IN." I AM NUMBER 452 OUT OF 1400 LEXUS RX'S THAT NEED REPLACEMENT. ITS RIDICULOUS THAT IN 2 YEARS THEY HAVEN'T REPLACED A THIRD OF THE DASHBOARDS??? ITS A SCAM, THEY ARE JUST WAITING PEOPLE OUT UNTIL THEY RUN OUT OF TIME. THOUGH THEY WILL TELL YOU THAT THE WARRANTY PASSES TO ANYONE YOU SELL THE CAR TO BUT WHO IS GOING TO BELIEVE THAT?? THEY'VE WASTED 2 YEARS AND AREN'T EVEN CLOSE TO REPLACING THE DASHBOARDS.
AS OF 3/18/2016 I PURCHASED AN NEW RADIATOR FOR A TOTAL OF $945 AT MCGRATH LEXUS DEALERSHIP IN CHICAGO ON DIVISION ST BECAUSE THE OLD RADIATOR WAS LEAKING. AS OF 3/31/2017 THE NEW RADIATOR IS NOW LEAKING AND THE CAR WOULD NOT START BECAUSE THE CAR WAS OVER HEATING. AS OF 4/1/2017 THE TIMING BELT AND WATER PUMP FOR THE STEERING W…
Read full complaint
AS OF 3/18/2016 I PURCHASED AN NEW RADIATOR FOR A TOTAL OF $945 AT MCGRATH LEXUS DEALERSHIP IN CHICAGO ON DIVISION ST BECAUSE THE OLD RADIATOR WAS LEAKING. AS OF 3/31/2017 THE NEW RADIATOR IS NOW LEAKING AND THE CAR WOULD NOT START BECAUSE THE CAR WAS OVER HEATING. AS OF 4/1/2017 THE TIMING BELT AND WATER PUMP FOR THE STEERING WILL NEEDS TO BE REPLACED. TODAY 4/1/2017 MCGRATH LEXUS DEALER STATED I WILL COST AT LEAST $1200 WITH LABOR INCLUDED FOR THEM TO REPAIR. AFTER FURTHER RESEARCH ON RECALLS FOR MY 2004 LEXUS RX330 I DISCOVERED THESE REQUIRED REPAIRS ARE LEXUS DEAKER RECALLS. WHY WOULD MCGRATH LEXUS CHARGE ME IF THESE ARE RECALLS ON MY LEXUS.
THE DASHBOARD MELTED AND CHEMICALS ARE SEEPING FROM IT. THE KEY WAS STUCK IN THE IGNITION AND BROKEN WHEN I ATTEMPTED TO REMOVE IT.
I WAS DRIVING ON THE 59 FREEWAY 1/20/17, WHEN I HEARD A LOUD POP, LIKE A ROCK HITTING THE WINDSHIELD. HOWEVER THERE WAS NO DAMAGE, SO I KEPT DRIVING. I HEARD A NOISE WHERE THE SUNROOF IS THIS MORNING (1/21), AND FOUND THAT THE SUNROOF WAS COMPLETELY SHATTERED. HOUSTON HAS HAD A LOT OF RAIN AND HAIL THE LAST COUPLE DAYS, BUT I PA…
Read full complaint
I WAS DRIVING ON THE 59 FREEWAY 1/20/17, WHEN I HEARD A LOUD POP, LIKE A ROCK HITTING THE WINDSHIELD. HOWEVER THERE WAS NO DAMAGE, SO I KEPT DRIVING. I HEARD A NOISE WHERE THE SUNROOF IS THIS MORNING (1/21), AND FOUND THAT THE SUNROOF WAS COMPLETELY SHATTERED. HOUSTON HAS HAD A LOT OF RAIN AND HAIL THE LAST COUPLE DAYS, BUT I PARK IN A GARAGE, SO MY CAR HASN'T BEEN OUTSIDE.
Official recalls
511V539000 · Engine And Engine Cooling
Nov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
Consequence & remedy
Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V112000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
Consequence & remedy
Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
06V253000 · Vehicle Speed Control:accelerator Pedal
Jul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
Consequence & remedy
Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
06V023000 · Seat Belts:rear/other
Jan 27, 2006
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE ANCHOR BOLT FOR THE REAR, LEFT-HAND SIDE SEAT BELT BUCKLE DIRECTLY BEHIND THE DRIVER'S SEAT DOES NOT HAVE SUFFICIENT STRENGTH.
Consequence & remedy
Consequence: THE REAR SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE FREE OF CHARGE THE REAR, LEFT-HAND SIDE SEAT BELT BUCKLE ANCHOR BOLT WITH AN IMPROVED ONE. THE RECALL BEGAN ON FEBRUARY 3, 2006. OWNERS MAY CONTACT LEXUS AT 800-255-3987.
04V558000 · Exterior Lighting:brake Lights:switch
Nov 22, 2004
CERTAIN PASSENGER VEHICLES MAY BE EQUIPPED WITH AN IMPROPERLY DESIGNED BRAKE LIGHT SWITCH. A SILICON OXIDE BUILD-UP OCCURS ON THE CONTACTS INSIDE THE BRAKE LIGHT SWITCH, WHICH CAN MAKE IT INOPERABLE.
Consequence & remedy
Consequence: IF THE SWITCH IS INOPERABLE, THE BRAKE LIGHTS WILL NOT ILLUMINATE AND CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRAKE LIGHT SWITCH. THE RECALL BEGAN DURING DECEMBER 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
PE05009 · Vacuum Brake Booster Failure
Opened Feb 10, 2005 · Closed Jun 15, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:master Cylinder; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:vacuum; Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (6)
Service Brakes, Hydraulic:foundation Components:master Cylinder
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:foundation Components
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist:vacuum
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.