Air Bags. Review the 101 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

14 crash reports2 fire reports11 injury reports

Air Bags complaints

101 reports

Clear category filter

Mileage unknown · Mar 19, 2018

Air Bags

TAKATA AIR BAG RECALL; RECEIVED NOTICE OF RECALL IN FEBRUARY, 2017; AS OF 3/19/2018, WE HAVE HAD NO CORRESPONDENCE TO SCHEDULE REPAIR

NHTSA ODI #11080301

39,000 miles · Feb 19, 2018

Air Bags

Read full complaint

FAULTY AIRBAG HARNESS WIRRING. DEAR SIR OR MADAM, THIS IS TO REPORT THAT 2007-2012 IS 250, IS 350 AND ES 350 HAS FAULTY AIRBAG WIRING HARNESS WHICH DISABLES THE AIRBAGS. CLUBLEXUS.COM HAS RECEIVED HUNDREDS OF COMPLAINTS REGARDING THIS. THE REPAIRS WILL ONLY BE DONE OR CORRECT IF THE VEHICLE IS UNDER 6 YEARS OLD OR 70,000 MILES, WHICHEVER COMES FIRST. FEW THOUSAND CUSTOMERS HAVE CARS LESS THAN 70,000 MILES BUY BEYOND 72 MONTHS BUT LEXUS REFUSES TO RECTIFY THIS TSB WARNING UNDER THE WARRANTY. IT IS NOT OUR FAULTS THAT THE VEHICLES HAVE BEEN DRIVEN LESS THAN 70,000 MILES IN 6 YEARS. THE COST TO REPAIR THIS IS IN THE UPWARDS OF 4000$. THIS IS RIDICULOUS ON THE PART OF LEXUS AND NHTSA. THE AIRBAG WIRING SHOULD BE INCLUDED IN THE RECALLS ALONG WITH THE TAKATA RECALLS AS THEY ARE CONNECTED BUT LEXUS REFUSES TO AGREE TO THE CONSUMER COMPLAINTS AND HAVE DARED MANY CUSTOMERS TO CHALLENGE NHTSA TO GET IT COVERED UNDER RECALL. PLEASE HELP THOUSANDS OF LEXUS DRIVERS AND THEIR FAMILIES FROM THIS FATAL TSB FAULT WHICH LEXUS REFUSES TO FIX. FURTHER, LEXUS STATED THAT "IF THE FAULT IS COVERED BY THE RECALL, IT WILL BE FIXED WITHOUT FAIL". SO FAR LEXUS WANTS TO GET RICHER BY CHARGING CONSUMERS $4000.00 FOR A PART THAT THEY INSTALLED TO BIG WITH. PLEASE CHECK THE CLUBLEXUS.COM FORUM REGARDING THE AIRBAG LIGHTS COMING ON AND THE REACTION THAT LEXUS HAS SUBMITTED TO ITS CUSTOMERS. THEY ARE WILLING TO PUT THEIR CUSTOMERS AND THEIR FAMILIES LIVES IN DANGER JUST BECAUSE NHTSA DID NOT TELL THEM TO INCLUDE AIRBAG HARNESS WIRING IN THE TAKATA RECALL, EVEN IF THE VEHICLES ARE BEYOND WARRANTY REPAIRS. PLEASE HELP US IN THESE DIRE AND UNSAFE CIRCUMSTANCES. THANK YOU

NHTSA ODI #11073588

Mileage unknown · Dec 20, 2017

Air Bags

Read full complaint

TL* THE CONTACT OWNS A 2009 LEXUS ES350. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V006000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. LEN STOLER LEXUS IN OWINGS MILLS, MARYLAND WAS MADE AWARE OF THE RECALL AND STATED THAT THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. *TT

NHTSA ODI #11055731

55,000 miles · Dec 18, 2017

Air Bags

TAKATA RECALL I RECEIVED RECALL NOTICE IN THE PAST AND WAS TOLD I WOULD BE NOTIFIED WHEN PARTS WERE AVAILABLE. NOW DEALER TELLS ME THERE IS NO RECALL. DEALER IS LEXUS OF ROCKVILLE CENTRE NY

NHTSA ODI #11055214

Mileage unknown · Dec 12, 2017

Air Bags

TAKATA INFLATORS- TAKATA RECALL WE SUBMITTED TO THE DEALERSHIP THE REQUEST TO REPLACE THE AIRBAGS PER THE RECALL AND AT THE TIME THESE WERE NOT BEEN AVAILABLE. IT'S BEEN SEVERAL MONTHS, AND THESE HAVE NOT BEEN REPLACED.

NHTSA ODI #11054077

Mileage unknown · Dec 6, 2017

Air Bags

Read full complaint

TL* TAKATA RECALL. THE CONTACT OWNS A 2009 LEXUS ES350. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V006000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (LEN STOLER LEXUS, 11311 REISTERSTOWN RD, OWINGS MILLS, MD 21117 (410) 773-9613) WAS CONTACTED AND RECALL REPAIR APPOINTMENTS WERE SCHEDULED. THE APPOINTMENTS WERE CANCELLED BY THE DEALER, STATING THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT STATED THAT THIS OCCURRED SEVERAL TIMES IN THE PAST YEAR. THE CONTACT CALLED THE MANUFACTURER AT 800-255-3987, BUT WAS GREETING BY A RECORDING, STATING TO CONTACT THE LOCAL LEXUS DEALER TO SCHEDULE A RECALL REPAIR APPOINTMENT. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ODI #11052789

Mileage unknown · Nov 22, 2017

Air Bags

Read full complaint

TL* TAKATA RECALL. THE CONTACT OWNS A 2009 LEXUS ES350. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V34000 (AIR BAGS) WAS RECEIVED IN MAY OF 2016. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE PROVIDED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE. *TT *TR

NHTSA ODI #11048056

Mileage unknown · Nov 2, 2017

Air Bags

TAKATA RECALL - LEXUS STATES THAT THEY CURRENTLY DO NOT HAVE THE PARTS FOR MY VEHICLE

NHTSA ODI #11042810

Mileage unknown · Oct 30, 2017

Air Bags

TAKATA RECALL WHAT DO I HAVE TO DO TO GET THIS AIRBAG REPLACED? I RECEIVED A LETTER FROM LEXUS IN MARCH DETAILING THE PROBLEM, AND TELLING ME THAT IT WOULD BE ADDRESSED. IT WAS SUPPOSED TO HAVE BEEN DONE IN SEPTEMBER. IT IS NOW 10/30. PLEASE HELP!

NHTSA ODI #11041090

Mileage unknown · Oct 29, 2017

Air Bags

TAKATA RECALL MY VEHICLE IS NOT REPAIRED, LEXUS HAS FAILED TO ADDRESS THE ISSUE IN TIMELY MANNER. I AM UNABLE TO USE THE FRONT PASSENGER SEAT AS THE FRONT PASSENGER IS IN THE RISK OF SERIOUS INJURY

NHTSA ODI #11040865

Official recalls

19V741000 · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

Oct 17, 2019

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Additional source detail variants (2)

Air Bags:frontal:passenger Side:inflator Module

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Air Bags:frontal:driver Side:inflator Module

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

18V024000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2018

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013 Scion xB, Toyota Corolla, Corolla Matrix, Sienna, 4Runner, Lexus IS250, IS350, IS250C, IS350C, IS-F, and GX460 vehicles sold, ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP (Saipan), and the U.S. VI or "Zone A." Toyota is also recalling certain 2010 Scion xB, Toyota Corolla, Corolla Matrix, Yaris, 4Runner, Lexus IS250, IS350, IS250C, IS350C, ES350, IS-F, GX460, and Pontiac Vibe vehicles sold, ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Toyota is also recalling certain 2009 Scion xB, Toyota Corolla, Corolla Matrix, Yaris, Lexus IS250, IS350, ES350, IS-F, and Pontiac Vibe vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify the Toyota, Scion and Lexus owners. General Motors will contact the Pontiac owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began on January 29, 2018. Owners may contact Toyota customer service at 1-800-331-4331, or Pontiac customer service at 1-800-762-2737. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.

17V006000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2017

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2012 Toyota 4Runner, Corolla, Corolla Matrix, Sienna, Yaris, Scion xB, Lexus ES350, GX460, IS-F, IS250, IS350, IS250C, IS350C, and Lexus LFA vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain 2009 Toyota Corolla, Corolla Matrix, Yaris, Yaris HB, Scion xB, Pontiac Vibe, Lexus, ES350, IS250, IS350, and IS-F vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Toyota is recalling certain 2006-2008 Lexus IS250 and IS350, 2007-2008 Lexus ES350, Toyota Yaris, Yaris HB, and 2008 Lexus IS-F and Scion xB vehicles originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Toyota will notify the Toyota, Scion and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on February 1, 2017. Owners may contact Toyota customer service at 1-800-331-4331, or Pontiac customer service at 1-800-762-2737. Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), H0A (Toyota Zone C), GLG (Lexus Zone A), GLH (Lexus Zone B) and HLA (Lexus Zone C).

16V340000 · Air Bags:frontal:passenger Side:inflator Module

May 23, 2016

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on December 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).

09V388000 · Vehicle Speed Control:accelerator Pedal

Oct 5, 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

Air Bags:frontal:passenger Side:inflator Module

DP15005 · Low-speed Surging

Opened Jul 9, 2015 · Closed Aug 19, 2015

Status: closed (inferred from source dates) · Vehicle Speed Control

The Agency received a petition on June 19, 2015, requesting an investigation into low-speed surging in different models of Toyota automobiles in which the car starts accelerating and the engine RPM increases even when the accelerator pedal is not depressed.The petition is based upon the petitioner's interpretation of pre-crash Event Data Recorder (EDR) data from a crash his wife experienced in a model year (MY) 2009 Lexus ES350 vehicle and from two other crashes involving a MY 2010 Toyota Corolla and a MY 2009 Toyota Camry.The petitioner's allegations regarding the three crashes are based upon several misconceptions about the manner in which the EDR samples and records pre-crash data in the ES350, Corolla and Camry vehicles.In each of the three crashes, the vehicles accelerated as the drivers were attempting to park the vehicles.All three accelerations occurred as the vehicles were entering the intended parking spaces and in the times and positions where driver braking should be initiated to safely park the vehicles.No braking was recorded in two of the crash events until the EDR trigger point (t = 0 seconds) and in the third crash no braking was recorded at all.The crashes are all consistent with pedal misapplications by the driver mistaking the accelerator pedal for the brake when attempting to park the vehicle.In addition, contrary to the petitioner's assertion regarding previous studies by NHTSA and NASA, the issues raised in the petition are fully within the scope of prior studies which have carefully examined the subject of low-speed sudden acceleration in Toyota vehicles equipped with electronic throttle control.Taking into account the allocation of agency resources, agency priorities, and the likelihood that an additional investigation would not result in a finding that a defect related to motor vehicle safety exists, NHTSA has concluded that further investigation of the issues raised by the petition is not warranted. The agency accordingly has denied the petition.The official petition denial, as published in the Federal Register, is available in the document file for this defect petition, as well as copies of reference material related to the denial.