LEFT EXHAUST MANIFOLD CRACKED, RIGHT EXHAUST MANIFOLD BROKEN IN 2! CAST IRON EXHAUST MANIFOLD BOTH DIAGNOSED AS CRACKED - I REPLACED WORSE OF 2 THEN BETTER ONE BROKE. ENGINE BLOCK ALUMINUM - CREEP/FATIGUE FAILURE DUE TO THERMAL EXPANSION RATES OF MANIFOLD VERSUS BLOCK SHOULD BE INVESTIGATED. I BELIEVE WARRANTS A RECALL - ESPEC…
Read full complaint
LEFT EXHAUST MANIFOLD CRACKED, RIGHT EXHAUST MANIFOLD BROKEN IN 2! CAST IRON EXHAUST MANIFOLD BOTH DIAGNOSED AS CRACKED - I REPLACED WORSE OF 2 THEN BETTER ONE BROKE. ENGINE BLOCK ALUMINUM - CREEP/FATIGUE FAILURE DUE TO THERMAL EXPANSION RATES OF MANIFOLD VERSUS BLOCK SHOULD BE INVESTIGATED. I BELIEVE WARRANTS A RECALL - ESPECIALLY IN CA WITH TIGHT SMOG LIMITS.*AK
NHTSA ODI #10078636
Mileage unknown · Dec 10, 2003
Engine And Engine Cooling
WHILE DRIVING VEHICLE MADE A LOUD NOISE. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER DETERMINED THAT THERE WAS A HAIRLINE CRACK IN THE MANIFOLD WHICH CAUSED THE LOUD NOISE. *AK
NHTSA ODI #10050372
65,000 miles · Dec 10, 2003
Engine And Engine Cooling
WHILE DRIVING A LOUD NOISE CAME FROM UNDER THE HOOD. THE NOISE OCCURRED BECAUSE THE MANIFOLD HAD A HAIR LINE CRACK. A MANUFACTURER'S IMPROVEMENT CAMPAIGN WAS ISSUED. THE MANUFACTURER INDICATED THAT THE VEHICLE'S VIN WAS 1 DIGIT OFF, THUS NOT COVERED BY THE WARRANTY. *AK
NHTSA ODI #10050367
Mileage unknown · Jul 17, 2002
Engine And Engine Cooling
ONE CYLINDER BLEWOUT AND ALL 8 HAD TO BE REPLACED. WHILE DRIVING AND WHEN CYLINDER MALFUNCTIONS IT AFFECTS EVERYTHING IN THE CAR ,INCLUDING SPEEDOMETER. *AK
NHTSA ODI #8014124
Mileage unknown · Aug 17, 2000
Engine And Engine CoolingService Brakes, HydraulicVehicle Speed Control
ON SEVERAL OCCASIONS, DASHBOARD WENT BLANK WHILE DRIVING LOSING ALL POWER, DEALER FOUND THAT THE SECURITY SYSTEM HAD FAILED, CAUSING IT TO CUT THE IGNITION SWITCH, THEN AFTER HAPPENING AGAIN DEALER SAID THE PROBLEM WAS CASUED BY A DEFECTIVE CRANK SHAFT SENSOR.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. AS A RESULT OF CHAFFING OF A CRUISE CONTROL WIRE, THE STEERING WHEEL ROTARY COUPLER CAN OVERHEAT AND INADVERTENTLY DEPLOY THE DRIVER'S AIR BAG.
Consequence & remedy
Consequence: DEPLOYMENT OF THE AIR BAG RESTRAINT SYSTEM WITHOUT WARNING CAN CAUSE A DRIVER TO LOSE VEHICLE CONTROL.
Remedy: DEALERS WILL INSTALL A FUSIBLE LINK WHICH WILL PROTECT THE ROTARY COUPLER FROM OVERHEATING.
Additional source detail variants (2)
Vehicle Speed Control
VEHICLE DESCRIPTION: PASSENGER VEHICLES. AS A RESULT OF CHAFFING OF A CRUISE CONTROL WIRE, THE STEERING WHEEL ROTARY COUPLER CAN OVERHEAT AND INADVERTENTLY DEPLOY THE DRIVER'S AIR BAG.
Consequence: DEPLOYMENT OF THE AIR BAG RESTRAINT SYSTEM WITHOUT WARNING CAN CAUSE A DRIVER TO LOSE VEHICLE CONTROL.
Remedy: DEALERS WILL INSTALL A FUSIBLE LINK WHICH WILL PROTECT THE ROTARY COUPLER FROM OVERHEATING.
Air Bags:frontal
VEHICLE DESCRIPTION: PASSENGER VEHICLES. AS A RESULT OF CHAFFING OF A CRUISE CONTROL WIRE, THE STEERING WHEEL ROTARY COUPLER CAN OVERHEAT AND INADVERTENTLY DEPLOY THE DRIVER'S AIR BAG.
Consequence: DEPLOYMENT OF THE AIR BAG RESTRAINT SYSTEM WITHOUT WARNING CAN CAUSE A DRIVER TO LOSE VEHICLE CONTROL.
Remedy: DEALERS WILL INSTALL A FUSIBLE LINK WHICH WILL PROTECT THE ROTARY COUPLER FROM OVERHEATING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1997 Land Rover Discovery Problems, Complaints & Recalls | Skip That Year
Illustration